2002 CHEVROLET MALIBU Complaints

GM V6 DEFECTIVE INTAKE MANIFOLD GASKET FAILED, CAUSING COOLANT TO DISAPPEAR THROUGH ENGINE OR INTO ENGINE OIL. CAUSES ENGINE TO OVERHEAT, AND POSSIBLE SEVER INTERNAL DAMAGE. LAST FAILURE WAS ON 2002 CHEVROLET MALIBU AT 39000 MILES,IT FAILED 2 TIMES ON 1998 PONTIAC MONTANA UNDER 80000 MILES, FAILED 2 TIMES ON 2000 CHEVROLET VENTURE UNDER 80000 MILES. FAILED 1 TIME ON 2002 MALIBU. MANUFACTURER WAS AWARE OF DEFECT, BUT DID NOT TELL CUSTOMER. *AK

TL* - THE CONTACT OWNS A 2002 CHEVROLET MALIBU, WHICH WAS PURCHASED ON 02/28/2007, AND WORKED WELL UNTIL 03/16/2007 WHEN THE ENGINE LIGHT TURNED ON. ON 03/23/2007 THE VEHICLE WOULD NOT START, AND WAS TAKEN TO THE DEALER, AND THE DEALER HAS BEEN UNABLE TO GET THE VEHICLE TO TURN ON SINCE THAT TIME. THE CONTACT STATED THAT THERE WAS A 3 YEAR WARRANTY ON THE VEHICLE. THE FAILURE MILEAGE WAS 54,700 AND THE CURRENT MILEAGE WAS 54,667. *AK

I OWN A CAR RENTAL COMPANY AND THE PRIMARY VEHICLE IN MY FLEET IS THE 01-03 CHEVY MALIBU. OVER THE PAST 14 MONTHS THE IGNITION ANTI-THEFT SYSTEM HAS LEFT MY CUSTOMERS STRANDED AND FRUSTRATED. ONE CUSTOMER WAS STRANDED AT NIGHT IN A WAL-MART PARKING LOT WITH HER SMALL KID WHILE SITTING THROUGH A HEAVY RAIN STORM. ALL OF OUR KEYS/SPARES ARE ORIGINAL AND PURCHASED FROM GM DEALERS BUT THE PROBLEMS REMAINS. *JB

DRIVING CAR AND IT WOULD DIE. FIRST OCCURANCE WAS UNDER WARRANTY. CAR TAKEN TO DEALER. DEALER SAID FUEL PUMP WAS BAD AND REPLACED PUMP. SAME PROBLEM OCURRED OUT OF WARRANTY. NOTICED THAT SOME OF THE GAGES AND LIGHTS ON DASH ALSO QUIT WHEN THIS HAPPENED. I COULD HIT THE KEY AND THEY WOULD COME BACK ON, AND THE CAR WOULD RESTART. DEALT WITH THIS FOR ABOUT 2 YRS BECAUSE THE COST OF A NEW SWITCH WAS MORE THAN I COULD AFFORD AT THE TIME.FINNALLY DISSASSEMBLED THE IGNITION SWITCH WHEN PROBLEM GOT TOO BAD. DISCOVERED THAT GM HAD NOT USED THE NORMAL HEAVY WIPER STYLE CONTACTS THAT MOST IGNITION SWITCHES HAVE. THEY USED A PLASTIC CAM THAT PUSHES PINS THAT OPERATE VERY LIGHT SPRING STYLE CONTACTS. I FOUND THAT THE CONTACTS HAD ARCED AND WERE NOT MAKING GOOD CONTACT. USED VERY FINE EMERY CLOTH TO CLEAN CONTACTS, REASSEMBLED SWITCH, AND PROBLEM WAS SOLVED.CAR STARTS AND RUNS FINE FOR NOW, BUT AS SOON AS CONTACTS ARC ENOUGH, PROBLEM WILL RETURN. I HAVE NOTICED THAT THERE ARE MANY MANY PEOPLE WHO HAVE THE SAME PROBLEM AND THE DEALERSHIP IS TELLING THEM THAT THE PROBLEM IS IN THE SECURITY SYSTEM. WELL ITS NOT. ANYONE WHO HAS A MINOR AMOUNT OF MECHANICAL ABILITY CAN FIX THE PROBLEM IN ABOUT AN HOUR. BE SURE AND CONSULT A REPAIR MANUAL ON THE PROPER REMOVAL OF THE IGNITION SWITCH FROM THE DASH. ITS NOT HARD, BUT THERE IS A TRCK TO IT.*AK

ENGINE COOLANT LIGHT CAME ON. I REPLACED 1/2 GALLON OF COOLANT. AT MY NEXT OIL CHANGE, I NOTICED AN ORANGE GEL ON MY OIL CAP. I FIGURED IT WAS AN INTERNAL COOLANT LEAK; THEREFORE, IT WAS PROBABLY A HEAD GASKET LEAK. I TOOK MY CAR TO LOCAL CHEVROLET DEALERSHIP FOR SERVICE. THE SERVICE TECHNICIAN DETERMINED IT WAS AN INTAKE MANIFOLD GASKET LEAK. IF THE GASKET WAS NOT REPLACED PROMPTLY, THE ENGINE OIL WOULD FAIL TO LUBRICATE THE ENGINE PROPERLY. THE RESULT COULD BE CATASTROPHIC DAMAGE TO THE ENGINE. 8JB

MY BLINKERS ON MY CHEVY MALIBU 2002 WORK INTERMITTENTLY. THIS IS A PROBLEM BECAUSE I NEED TO TURN THE BLINKER TO THE LEFT TO TURN ON MY CAR AS A SAFETY PROCEDURE INSTALLED BY THE PRODUCER. IT IS ALSO A PROBLEM BECAUSE WHEN I DRIVE I HAVE TO CHANGE LANES AND EVEN THOUGH I TURN MY BLINKERS ON THEY DO NOT WORK SO I AM CUTTING PEOPLE OFF ALL THE TIME. I TRIED TAKING IT TO THE GM DEALERSHIP BUT THEY TOLD ME THERE WAS NO RECALL FOR THAT KIND OF PROBLEM. IT IS GETTING VERY ANNOYING AND TODAY I HAD TO WAIT ABOUT 10 MINUTES TO TURN MY CAR ON WHEN I WAS TRYING TO GET SOME MONEY FROM THE ATM. IT IS ANNOYING BECAUSE IF THE LEFT BLINKER DOES NOT TURN ON AND I START MY CAR IT DOES NOT START AND THE HORN SOUNDS. PEOPLE WERE LOOKING AT ME FUNNY BECAUSE THE HORN SOUNDED LIKE 30 TIMES. *JB

ANTI THEFT SYSTEM IS DEFECTIVE. BOUGHT THE CAR 1 YEAR AGO. FIRST HAPPENED IN AUGUST 06. HAPPENED AGAIN IN JANUARY. NOW IN FEBRUARY IT HAS HAPPENED 3 TIMES IN THE PAST WEEK. CAR WILL NOT START, HAVE TO RESET THE KEY AND I HAVE FOUND NO ONE WHO HAS TAKEN THIS PROBLEM TO THE DEALER HAVE IT COMPLETELY FIXED. THERE ARE HUNDREDS OF COMPLAINTS ABOUT THIS PROBLEM ON MALIBU'S STARTING WITH 99-04 MODELS. NOW LIGHT WILL COME ON WHILE DRIVING DOWN THE ROAD. HAVE READ SEVERAL COMPLAINTS ABOUT THE CAR SHUTTING OFF WHILE DRIVING. AFRAID FOR MY SAFETY, MY CHILDREN'S SAFETY, AND THE SAFETY OF OTHERS. GM WILL NOT ACKNOWLEDGE THIS PROBLEM EVEN EXISTS, BUT THOUSANDS OF OTHER MALIBU OWNERS HAVE. "QUICK FIX" SOLUTIONS ARE NOW GOING AROUND THE INTERNET TELLING PEOPLE TO CUT WIRES IN THEIR DASH TO "FIX" THE PROBLEM. GM NEEDS TO FIX THIS BEFORE SOMEONE CUTS THE WRONG WIRE AND KILLS SOMEONE IN RESULT TO FIXING GM SCREW UP. *JB

CONSISTENT PROBLEMS WITH THE "THEFT DETERRENT" SYSTEM, RESULTING IN FAILURE TO START. DEALER HAS REPLACED THE SAME PART THREE TIMES. LAST TIME THEY REPLACED IT AGAIN, AND CHARGED ME FOR THE TOW TO GET THE CAR BACK. THIS HAS HAPPENED SIX TIMES NOW IN THE PAST YEAR. *NM

FIRST INCIDENT OF LEAKING HAPPENED AFTER DEALERSHIP WORKED ON CAR. ARRIVED HOME COOLANT POURED OUT ON GROUND TOWED BACK. DEALERSHIP SAID RESERVOIR CAP SEAL. 10/2006 OR 11/2006, PICKING UP AT SCHOOL AND SMELLED NOT ENGINE. PARKED SAW COOLANT ON GROUND. NO ENGINE LIGHT ON BUT NEEDLE WAS PAST MIDDLE. FAMILY BROUGHT COOLANT FILLED IT UP AND WENT 5 BLOCKS TO DEALERSHIP. THEY SAID NOTHING WAS WRONG. YESTERDAY, 1/9/2007 CAR OVERHEATED IN THE SCHOOL LINE. ADDED COOLANT. I BROUGHT IT TO A NON DEALERSHIP RADIATOR SHOP OWNER THINKS INTAKE MANIFOLD GASKET LEAKING. CAR AT DEALERSHIP. I REALLY DON'T KNOW WHAT THE REAL PROBLEM IS BUT BECAUSE MY WARRANTY EXPIRED FEEL DEALERSHIP WILL TELL ME IT IS A NEW PROBLEM FROM THE FIRST EVENT SO I WILL BE RESPONSIBLE. AT LEAST TWO ROTORS REPLACED ON THE FRONT DRIVER'S WHEEL & 5 SETS OF PADS. REPORTED TO GM THEY CLAIM IT IS THE WAY I DRIVE! A NON DEALERSHIP TIRE COMPANY HAD THE PADS REPLACED WITH A GOOD BRAND. 1 1/2 YEARS SINCE I HAD TO HAVE PADS. PROBLEM WITH THE RIGHT FRONT PASSENGER DOOR LOCKS. CAR IS RUNNING AND THE DRIVER GETS OUT LEAVING CAR ON AND THEN THE PASSENGER TURNS OFF THE CAR AND GETS OUT, LOCKS CAR, THE RADIO STAYS ON. I WENT INSIDE THE STORE AND CAME OUT AND THE RADIO WAS STILL PLAYING. WHEN YOU UNLOCK THE CAR BUT ENTER ONLY THE PASSENGER FRONT DOOR AND THEN CLOSE IT AND WALK AWAY, THE CAR LOCKS ITSELF. HAPPENED SEVERAL TIMES. I HAD NOT PLACED THE KEYS ON THE SEAT OF THE CAR AND SHUT THE DOOR OR I WOULD HAVE BEEN LOCKED OUT. I REPORTED THIS BUT NO ONE SEEMED TO CARE. RADIO WAS REPLACED FOR LEFT BUTTON PAINT (NOT SURE IF IT IS PAINT OR COVER ON BUTTON) RUBS OFF. IGNITION SWITCH WAS REPLACED. FUEL PUMP REPLACED.. I TRANSPORT GRANDCHILDREN AND I NEED A SAFE CAR. *JB

MY 2002 CHEVY MALIBU SUFFERS FROM SUDDEN ACCELERATION. MOST OF THE ARTICLES I HAVE READ ON THE INTERNET STATE THAT THEY WERE UNABLE TO REPLICATE THE RESULTS. ON MY CAR, I CAN REPRODUCE THE RESULTS ANYTIME. THE FIRST TIME THIS HAPPENED, I THOUGHT THAT MAYBE I HAD PRESSED THE GAS INSTEAD OF THE BRAKE, BUT I QUICKLY REALIZED THAT EVEN AFTER RELEASING THE ACCELERATOR PEDAL, THE CAR CONTINUED TO ACCELERATE ON ITS OWN. FORTUNATELY, FOR ME, THERE WERE NO CARS ON THE ROAD WHEN THIS HAPPENED. THE SECOND TIME, I WAS PULLING INTO A GAS STATION AND HAD TO TURN OFF THE CAR WHILE IT WAS STILL MOVING TO KILL THE ENGINE. THE THIRD TIME, I WAS IN THE CITY AND I KNOW THAT I MUST HAVE REALLY WORN OUT MY BRAKES. THE PROBLEM STILL EXISTS AND I HAVE CALLED GM TO LET THEM KNOW ABOUT IT. THEY OFFERED LITTLE HELP AND ONLY SUGGESTED ME THAT I TAKE THE CAR INTO THE DEALERSHIP TO HAVE IT CHECKED. THAT TOO, THEY SAID I WOULD HAVE TO PAY FOR THE CHECK-UP. I WOULD LIKE SOME FEEDBACK AS WHAT I CAN DO TO RESOLVE THIS MATTER AND ALSO, I WOULD LIKE TO KNOW IF THERE WAS A RESOLUTION, IF ANY, IN CASES THAT WERE SIMILAR TO MINE. *JB