2000 CHEVROLET MALIBU Complaints

THE FRONT WINDSHIELD WIPER/TURN SIGNAL WAS HARD TO ACTIVATE. THE CAUSE HAS NOT BEEN DETERMINED. *NM

2000 CHEVY MALIBU SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC:ROTOR

ON YOUR SITE I HAVE FOUND MANY COMPLAINTS REGARDING COOLANT LEAK DUE TO POOR SEALING OF THE MANIFLOD GASKET THAT ACCORDING THE SEVICE BULLETIN ON THIS SITE, REQUIRES NEW GASKET TYPE TO REPLACE THE OLD, AND THE INTAKE MANIFOLD BOLTS CLEANED AND COATED WITH THREDLOCKER AND TORQUED TO A REVISED SPEC. THIS HAS ALREADY BEEN DONE ONCE TO MY CAR AT ABOUT 30K MILES AND FORTUNATELY COVER UNDER WARRANTY, IF NOT IT WOULD HAVE COST ME $1050, PROBLEM IS NOW THE CAR IS DOING THE SAME THING AGAIN AT 79K MILES AND IS NO LONGER UNDER WARRANTY....HOW MANY TIMES SHOULD THIS HAPPEN? WAS THE SERVICE BULLETIN PUT OUT AS A PERMAMANT SOLUTION FOR THIS PROBLEM? IF NOT HOW LONG SHOULD THIS WORK BE GUARANTEED? WHY WAS THERE NOT A RECALL ON THIS PROBLEM? DOES THERE HAVE TO BE A FATALITY TO RECALL A VECHICLE? IN ADDITION I ALSO HAVE HAD THE PROBLEM WITH THE HAZARD WARNING SWITCH THAT ALSO EFFECTED THE WIPERS, NEITHER WOULD WORK, AGAIN THIS REPAIR WAS SUBMITTED AS WARRANTY WORK. I HAVE COMPLAINED SEVERAL TIMES TO BOB BELL CHEVY ABOUT HOW HOT THE DASH INSTRUMENTS GET TO TOUCH AND HAVE ALREADY HAD TO HAVE RELATED ELECTRICAL PROBLEMS REPAIRED, TO NOTE..WHEN I FIRST COMPLAINED ABOUT THE HEAT WHEN TOUCHED TO CHANGE INTRUMENT SETTINGS I WAS TOLD "THAT'S NORMAL". GRANTED MY EXTENDED WARRANTY COVERED SOME OF THE WORK BUT I STILL HAD TO PAY A $250 DEDUCTABLE W/EACH PROBLEM. ALL THESE PROBLEMS HAVE BEEN REPORTED ON THIS NHTSA SITE BY MANY PEOPLE AND ADDITION OTHERS I KNOW PERSONALLY AND WHO I HAVE HAD MANY DISCUSSIONS WITH ALSO HAVE THE SAME YEAR MALIBU WITH ALL THE SAME PROBLEMS....WHY HASN'T THE MANUFACT. RECALLED THE CAR FOR THESES PROBLEMS, SURELY ALL CAN CAUSE FIRE SAFETY PROBLEMS. HOW ARE RECALLS DETERMINED AND WHAT CAN WE ALL DO????????????? I NEVER DREAMED CHEVROLET WOULD BE SO CHEESY. MY LAST CAR WAS 12 YEARS OLD AND OLDS CUSTOM CRUISER WAGON - NEVER GAVE ME A PROBLEM THAT WAS SO MAJOR AS THESE NOTED HERE, I SHOULD HAVE NEVER GOT RID OF IT FOR THIS MALIBU!*AK

TURN SIGNALS ARE WORKING INTERMITTENTLY. INDEPENDENT REPAIR SHOP INDICATED THAT HAZARD SWITCH NEEDED TO BE REPLACED. *AK

THE TURN SIGNALS / HAZARD FLASHERS ON MY 2000 CHEVROLET MALIBU DO NOT WORK PROPERLY. THIS IS AN IMPORTANT PROBLEM THAT COULD RESULT IN AN ACCIDENT. *AK I REACHED MY DEALER WHO WAS HELPFUL HOWEVER THEY SAID THEY COULD NOT RECTIFY THIS PROBLEM AS THE VEHICLE HAS NOT BEEN RECALLED. I ALSO SAW AN ARTICLE IN THE 12/03 EDITION OF CONSUMER REPORTS CITING THIS ISSUE. PLEASE ADVISE WHAT IS BEING DONE TO CORRECT THIS MATTER.

VEHICLE EXPERIENCED A "TICKING NOISE IN THE ENGINE." *PH THE CONSUMER LEFT FRONT CALIPER BOLT IS STRIPPED CAUSING A VIBRATING/ GRINDING NOISE THAT RADIATES FROM THE LEFT FRONT WHEEL UNDER THE DRIVER SIDE WHEN THE VEHICLE COMES TO A COMPLETE STOP. WHEN THE DEALER WAS CONTACTED THEY STATED THAT THEY COULD NOT DUPLICATE THE PROBLEM. AND THE CONSUMER IS TRYING TO OBTAIN AN OVER ALL INSPECTION OF THE MECHANICAL DEFECTS OF THE VEHICLE SO GM CAN BE HELD RESPONSIBLE FOR THE FAULTY AUTOMOBILE. *CB

THIS CAR HAS BEEN ONE PROBLEM AFTER ANOTHER. THE DAY AFTER WE LEASED THE CAR IT WAS IN THE SHOP FOR THE BRAKES, THE CAR HAS HAD 2 ENGINES IN IT. THE TRANSMISSION HAS BEEN REBUILT. THE BRAKES ARE STILL NOT CORRECT. TRANSMISSION IS SLIPPING AGAIN AND THE 3 YEAR WARRANTY IS UP. WE COMPLAINED TO CHEVROLET AND THE BBB. TO NO AVAIL THEY SEEMED TO BE ON CHEVROLET'S SIDE IN THE CASE. WE WERE TO THE POINT THAT WE WERE JUST GOING TO LET THE CAR GO BACK BUT THAT WOULD ONLY HURT MY HUSBAND'S CREDIT MORE THEN IT WAS ALREADY. WE HAD TO KEEP THE CAR THROUGH THE LEASE. THIS LEFT A REALLY BAD TAST IN MY MOUTH FOR PURCHASING NEW VEHICLES BECAUSE YOU ARE STUCK WITH IT FOR THE DURATION OF THE LEASE OR PURCHASE.

I BOUGHT MY CAR ON 7/21/01, IT HAS BEEN IN FOR REPAIRS 10/3/01, 7/12/02,12/11/02, 6/23/03 AND 6/24/03. THE PROBLEM IS ELECTRICAL AND THE ENGINE AS WELL. CHEVROLET HAS RUN DIAGNOSTICS MANY TIMES BUT IS NOT ABLE TO FIX THE PROBLEM FOR GOOD. EVERYTIME I TAKE MY CAR IN, I AM TOLD IT'S NOW SOMETHING DIFFERENT THAT HAS BROKEN. MY CAR WILL BREAK DOWN AND SOMETIMES IF I ALLOW IT TO SIT FOR 10 - 20 MINUTES IT WILL START RIGHT BACK UP. FOR AS MANY TIMES AS MY CAR HAS BEEN REPAIRED, IT HAS BROKEN DOWN AT LEAST THREE TIMES BEFORE I TAKE IT IN. MY DISPUTE WITH CHEVY IS MY CAR IS A LEMON. THEY CANNOT DETERMINE WHAT IS WRONG WITH IT BECAUSE DIAGNOSTICS IS UNABLE TO DUPLICATE THE PROBLEM. CHEVY INFORMED ME THAT DOES NOT MEAN THERE ISN'T A PROBLEM IT JUST MEANS THE COMPUTER CANNOT DETECT IT. I HAVE FILED WITH THE BBB AUTO LINE BUT BECAUSE MY CAR HAS MORE THAN 24,000 MILES THEY SAY I AM OUT OF LUCK. CHEVY IS UNWILLING TO DO ANYTHING ABOUT THE PROBLEMS I AM HAVING WITH MY CAR. MY DISPUTE IS SHOULD A CAR BREAK DOWN AT LEAST 5-10 TIMES A YEAR?

THE PAINT ON HOOD STARTED CHIPPING @ OR ABOUT 30K DEALER SAID NOT WARRANTY PROBLEM. BEGINNING APR 2002 CAR INTERMITANTLY HAS HAD A "SURGING" IMMEDIATELY AFTER STARTING & PUTTING IN GEAR. AT FIRST JUST 1 OR 2 TIMES IN 3 OR 4 MOS. NOW THE LAST 8-9 WEEKS IT HAS HAPPENED MORE & MORE FREQUENTLY, THEN 2 WEEKS AGO THE CRUISE CONTROL BECAME ERRATIC IN ACTIVATION & NOW WON'T WORK AT ALL.

THE LOWER INTAKE IS LEAKING COOLANT, CAUSING LOSS OF COOLANT OVER A SHORT PERIOD OF TIME CAUSING IT TO OVERHEAT. WITH THE EXTENDED WARRANTY IT WOULD NOT COVER IT UNLESS THE LOSS OF COOLANT CAUSED A HEAD GASKET TO BLOW OR ANOTHER TYPE OF MAJOR DAMAGE. I WORK WITH 2 OTHER PEOPLE THAT HAVE MALIBU'S AND THEY HAD THE SAME PROBLEM.