2002 CHEVROLET MALIBU Complaints

CONSUMER STATED THERE WERE BLACK SPOTS WHEN USING THE HEADLIGHTS. AS A RESULT VISIBILITY WAS IMPAIRED. *AK RECALL#2V107000 *SC

OVER HEATING PROBLEMS AND COOLANT LEAKS DUE TO A FAULTY INTAKE GASKET. DEALERSHIP WANTS $660.00 TO REPAIR. THIS IS A KNOWN PROBLEM AND GM NEEDS TO DO RECALL. VEHICLE INFO 2002 CHEVROLET MALIBU V6 ENGINE.*AK THIS PROBLEM LEFT ME STRANDED ON THE SIDE OF A BUSY HWY

BRAKE ROTORS WERE SO THIN AFTER LESS THAN 30K COMMUTER MILE THAT THEY HAD TO BE REPLACED. DEALERSHIP JUST TOLD ME THAT ROTORS WERE CONSUMABLES.

THE ROTORS ON THIS VEHICLE WARPED WITHIN THE FIRST YEAR AND CONTINUE TO WARP EVERY TWO TO FOUR MONTHS. THIS IS CAUSING WEAR ON THE BRAKES WHICH HAD TO BE REPLACED AT 21338 MILES AT MY COST AND AGAIN AT 31474 MILES AT THE DEALERS COST.

THE BRAKES FAILED AT 13000 MILES CREATING A SAFETY ISSUE FOR MYSELF AND FAMILY. THEY WERE DEFECTIVE AND WORN DOWN TO NOTHING, CREATING AN UNSAFE STOPPING CONDITION FOR MYSELF AND FAMILY. *NLM

MANY MAKES OF CARS NOW HAVE THE WINDSHIELD WASHER FLUID COMING OUT OF SMALL RUBBER TUBES ATTACHED TO THE WINDSHIELD WIPERS. WHEN I WAS DRIVING ON THE PENNSYLVANIA TURNPIKE IN JANUARY THE WINDSHIELD WASHER FLUID FROZE WITHIN THE TUBES AND WOULD NOT COME OUT. THIS CREATES A DANGEROUS SITUATION IN WHICH ROAD SALT SPLASHED FROM OTHER CARS FAIRLY QUICKLY BUILDS UP ON YOUR WINDSHIELD AND YOU CAN HARDLY SEE OUT OF THE WINDSHIELD WHILE DRIVING OVER 60 MPH ON AN INTERSTATE HIGHWAY. THE DAY WAS COLD, PERHAPS 14 DEGREES, BUT NOT EXTREMELY COLD AND THIS WAS PENNSYLVANIA NOT MINNESOTA NOR CANADA. MY GUESS IS THAT THE 14 DEGREES WEATHER PLUS DRIVING AT 70 MILES PER HOUR CREATES A WINDCHILL THAT IS BELOW THE -20 DEGREES THAT THE WASHER FLUID IS GOOD FOR. BUT IT IS ON COLD WINTER DAYS THAT YOU SPECIFICALLY NEED THE WINDSHIELD WASHER FLUID BECAUSE OF THE SALT LEFT ON THE ROAD. THE FLUID BEGAN TO FLOW AGAIN WHEN I GOT INTO SLIGHTLY WARMER TEMPERATURES IN MARYLAND. I NEVER DILUTED THE WINDSHIELD FLUID WITH WATER. FOR THIS WINTER I HAVE BOUGHT WINDSHIELD WASHER FLUID THAT IS GOOD TO MINUS 38 DEGREES AND HAVE ALSO BOUGHT AN ALCOHOL ADDITIVE FOR THE FLUID THAT WILL MAKE IT GOOD TO ABOUT MINUS 40 DEGREES AND I WILL SEE IF THAT WORKS. BUT MANY DRIVERS WON'T KNOW AHEAD OF TIME TO DO THAT, AND ALMOST ALL GAS STATIONS ONLY SELL THE STANDARD -20 FLUID. I THINK THAT CAR MANUFACTURERS IN DESIGNING FUTURE MODELS SHOULD GO BACK TO THE OLD SYSTEM OF WINDSHIELD WASHER FLUID COMING OUT OF SLITS IN THE HOOD INSTEAD OF COMING OUT OF THE WINDSHIELD WIPERS. *LA

PURCHASED A 2002 CHEVROLET MALIBU 07-04-03 WITH 4500 MILES. NOTICED THE TIRES HAD CRACKS BETWEEN THE TREAD AND SIDEWALLS. DEALER WOULD NOT REPLACE TIRES. FIRESTONE DEALERSHIP REPLACED WITH A DIFFERENT TIRE AT NO CHARGE, STATED IT LOOKED LIKE PREMATURE DRY ROT. FIRESTONE AFFINITY, DOT 8XMWAAA4501, P215/60R15. *AK

WHILE TRAVELING ON THE HIGHWAY AND WITHOUT PRIOR WARNING VEHICLE WILL SHUT DOWN, AND WILL NOT RESTART. *AK

PROBLEMS GETTING DEALERSHIP TO PAY FOR RECALL REPAIR. *MR THE DEALER STATED THE VEHICLE MILEAGE NEEDED TO BE BETWEEN 43K-45K MILES. THE CONSUMER REQUESTED HER MONEY BACK. *SCC *JB

INSIDE DISC PADS WORE OUT AT 21000 MILES. HAD PADS REPLACED AND ROTORS CHECKED. CALIPER IS NOW STICKING AGAIN AND INSIDE PAD IS RUBBING*AK