2000 CHEVROLET MALIBU Complaints

VEHICLE STALLED WHILE DRIVING 60-70 MPH, THEN AGAIN 3 DAYS LATER. VEHICLE TAKEN TO DEALER BOTH TIMES, COULD NOT FIND CAUSE.

VEHICLE WOULD JUMP WHEN TRYING TO STOP. ROTORS WERE WARPED. CONSUMER HAD TO PUT ON 5 SETS OF ROTORS SINCE JAN 2001. CONTACTED DEALER WHO WANTED CONSUMER TO EXTEND WARRANTY.*AK THE CONSUMER STATED THAT THE FRONT ROTORS ARE WARPED CAUSING BRAKE PULSATION. THE A/C DOES NOT FLOW OUT OF THE CORRECT VENTS DUE TO A/C CONTROL FAILURE, THE A/C CONTROL HEAD ALSO SHORTED OUT. THE DOOR WAS HARD TO OPEN AND CLOSE DUE TO THE LOCK BEING MISALIGNED. ENGINE MAKES A CLUNK NOISE. WHILE DRIVING THE VEHICLE SURGES. LEFT REAR SPEAKER SHORTED OUT. THERE IS A CLICKING NOISE COMING FROM THE FRONT WHEN TURNING, CONSUMER LATER STATED THAT THERE WAS A CHIRPING NOISE COMING FROM THE STEERING COLUMN. *YH

ROTORS GLAZING TWICE WITHIN 21,000 MILES. WAS TOLD THE ROTORS COULD BE REPLACED,BUT EXPECTED IT TO HAPPEN AGAIN DUE TO A KNOWN PROBLEM WITH THE ROTORS.

VIN IS [XXX] MANUFACTURED 05/00. RAIN WATER COLLECTS AND IS RETAINED IN RIGHT TAIL LIGHT ASSEMBLY. ONE LAMP OF FOUR SHORTED AND BLEW. ASSEMBLY IS INADEQUATELY SEALED AND INSULATED AGAINST WATER. COST OF NEW REPLACEMENT TAIL LIGHT ASSEMBLY IS $249.*AK INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ALTHOUGH THE DEALER SAYS THAT THE BRAKES ARE DESIGNED TO PRODUCE A SLIGHT CLICKING NOISE WHEN THE PADS BEGIN TO WEAR, NO SUCH NOISE WAS HEARD. WITH ONLY 23,450 MILES ON CAR, THE PADS ON ONE SIDE OF THE ROTOR WORE DOWN CUTTING GROOVES INTO THAT SIDE OF THE ROTOR WHILE PADS ON OTHER SIDE OF SAME ROTOR HAD A WAY TO GO BEFORE BEING WORN DOWN. I UNDERSTAND THIS SAME PROBLEM OCCURRED ON THE CHEVROLET S10 AND FOR WHICH THE S10 WAS RECALLED. DEALER SAID IT IS NOT UNCOMMON FOR ROTORS TO GO BAD SOON AS PADS WEAR OUT ON THE MALIBU. IT IS RIDICULOUS TO HAVE TO PAY FOR ROTORS EACH TIME THE PADS GO BAD, ESPECIALLY AT ONLY 23,000 MILES.*AK

BOUGHT MY CAR NEW OFF SHOW ROOM FLOOR AND HAVE HAD NUMEROUS PROBLEMS SINCE HAD IT IN FOR STARTING PROBLEMS BATTERY PROBLEMS FUEL PROBLEMS WINDOW PROBLEMS DOOR LOCK PROBLEMS ENGINE NOISE ENGINE OIL LEAKS VIBRATION PROBLEMS BRAKE PROBLEMS DYING PROBLEMS POPPING NOISES IN FRONT END STRUTS BOTTOMING OUT ROUGH RIDE AND STEERING PROBLEMS AND SO ON TOO MANY TO LIST ALL HAVE HAD FRONT END REALIGNED STUTS CHECKED AND REPALCED BRAKES CHECKED AND REPLACED WHEEL STUDS REPLACED FUEL PUMP AND FLOAT REPLACED PISTONS REPLACED BATTERY REPLACED REMOTE START SYSTEM REPLACED ALARM SYSTEM REPLACED WINDOW REGULATOR REPLACED FRONT CRANK SEAL REPLACED ALT CHECKED AND TESTED STARTED CHECKED STILL HAVING FUEL PROBLEMS BRAKE PROBLEMS VIBRATION ECT HAD IN THIS LAST WEEK FO 6 DAYS AND WHEN RETURNED STILL HAVING ENGINE NOISE STEERING PROBLEMS RADIO PROBLEMS FUEL PROBLEMS AND FOUND IMPACT MARK ON L/FRONT OF BUMPER ONE OF DEALERS TECH'S HIT SOMETHING AND NOW WANDERS TO LEFT LEFT HEAD LIGHT OUT OF LINE AND PUSHED BACK UNDER FENDER HOOD OUT OF LINE FENDERS BUMPERS DRIVING LIGHTS AND NUMEROUS OTHER PROBLEMS AND DAMAGE POSSIBLE THAT I AM UNABLE TO DETECT AT THIS TIME HAVE CONTACTED CHEVY AND COMPLAINED HAVE TALKED WITH DEALER AND STILL NO RESPONSIBILITY TAKEN AND STATEMENTS OF WE MIGHT HAVE BRUISED IT IT HAS BEEN WRECKED NOW I AMD PAYING GOOD MONEY FOR JUNK AND WANT REFUND OF ALL COSTS TO ME AND THE CAR TAKEN BACK ENGINES SHOULD NOT NEED TO BE OVERHAULED AT 14000 MILES THE CAR IS 2 YAERS OLD AND ACTS LIKE ITS 20 NEED RESPONESE AND INFO TO HELP RESOLVE PROBLEMS TRYING TO HAVE RETURNED UNDER LEMON LAW UNIFORM CONFORMITY ACT AND MAGNUSON-MOSS ACT CAR HAS BECOME INSTRUMENT THAT IS SUBSTANTIALLY IMPAIRED AND WHOSE OPPERATION IS FROUGHT WITH APPREHENSION SINCERLY UNHAPPY AND HURT CONSUMER IS THE HIGHWAY SAFTY DEVISION INTERESTED AND GOING TO DO ANYTHING FOR ALL OF US WHO ARE HAVING PROBLEMS OR ARE WE OUT OF LUCK ????????? RESPONSE REQUESTED

3 MONTHS AFTER I BOUGHT MALIBU IN JULY, 2000 I WAS DRIVING AT 65 MPH WHEN MY CARE LOST ALL POWER. DEALER TOLD ME THAT THERE WAS SOMETHING WRONG WITH THE FUEL INDICATOR WIRING AND WAS FALSELY READING THE AMOUNT OF GAS I HAD WHICH RESULTED IN MY RUNNING OUT OF GAS AT 65MPH. PROBLEM HAS NOT REPEATED ITSELF. AT 21,000 MILES MY SIGNAL INDICATOR LIGHTS FAILED AND MY HAZARD SWITCH HAD TO BE REPLACED. AT 23,000 MILES MY EVAPORATOR VENT VALVE HAD TO BE REPLACE (ENGINE LIGHT REMAINED ON CONSTANTLY). AT 20,000 MILES MY CAR WAS VIBRATING WHENEVER MY BRAKES WERE APPLIED. DEALOR SAID FRONT BRAKES WORN OUT AND ROTORS OUT OF ROUND AND THEY REPLACED THE FRONT BRAKES AND REFACED THE ROTORS. AT 33,000 MILES, CARE AGAIN VITRATED WHENVER BRAKES APPLIED AND DEALER TOLD ME AGAIN THAT IT WAS NOT UNDER WARRANTY AND WAS HAPPENING BECAUSE OF "HOT SPOTS" AND THAT MY ROTORS NEEDED TO BE CUT EVEN THOUGH THEY HAD JUST BEEN FIXED AT 20,000 MILES. WAS NEVER TOLD THAT MANUFACTURER WAS HAVING A PROBLEM WITH MALIBU BRAKES AND WAS TOLD IT WOULD COST APPROXIAMTELY $700.00 TO FIX ROTORS AND IT WAS MY RESPONSIBILITY. MY SEVICE FOR THE BRAKES WAS DONE AT FUTURE CHEVROLET IN OLD BRIDGE, NJ. *AK

CONSUMER STATES THAT THE BRAKES ARE TERRIBLE, THE DEALER STATED THEY COULD DO NO MORE AND THAT THE BRAKING SYSTEM IN THE MALIBU CARS ARE DEFICIENT, CONSUMER IS CONCERNED AND DOES NOT FEEL SAFE DRIVING THE VEHICLE. *SLC

VEHICLE WAS GOING 25MPH ON A STRAIGHT ROAD. THERE WAS NO WARNING AND LEFT FRONT END DROPPED. LEFT TIRE BLEWOUT, AND VEHICLE SKIDDED/ HIT THE CURVE. LOWER BALL JOINT BROKE, CAUSING REAR END TO SPIN AROUND. MANUFACTURER HAD A TSB MENTIONING PROBLEM ,BUT WILL NOT COVER THE PROBLEM WITHIN WARRANTY AGREEMENT.*AK

THE BRAKING SYSTEM ON THE 2000 CHEVROLET MALIBU IS INADEQUATE. MY VEHICLE HAS 31000 MILES ON IT AND DURING BRAKING IT HAS A SHIMMY ON OCCASIONS. THE DEALER STATED THIS WAS DUE TO THE BRAKE PADS BEING WORN AND THE BRAKE ROTORS NEEDED TURNING. I'VE DONE SOME RESEARCH AND THIS AND SOME TIRE PROBLEMS SEEMS TO BE A MAJOR COMPLAINT FROM OTHER MALIBU OWNERS WHO'S PROBLEMS HAVE STARTED SOONER THAN MINE IN MOST CASES IN FACT IN SOME CASES WHILE THE CAR IS STILL UNDER THE 12000 MILE WARRANTY. IT BEING A BRAKE AND TIRE PROBLEM SEEMS TO BE PUTTING SOME LIVES AT STAKE. I MYSELF CONTACTED CHEVROLET ABOUT THIS PROBLEM AND THEY SIMPLY STATED I'M SORRY YOUR HAVING PROBLEMS WITH YOUR CAR. *AK