2004 CHEVROLET MALIBU Complaints

THE 6 WAY FRONT DRIVERS SEAT HAS FAILED 6 TIMES SINCE 2006. THE MOST RECENT INCIDENT WAS 3/15/2019. THE FIRST FAILURE WAS IN 2007. THE WELDS THAT SUPPORT THE FRAME BREAK AND I HAVE REPLACED THE SEAT 3 TIMES, WELDED 3 TIMES. THIS IS A SIGNIFICANT SAFETY ISSUE AS IT HAS OCCURRED WHILE DRIVING AFTER HITTING A BUMP AND CAUSED ME TO LOOSE CONTROL OF THE CAR. I AM REPORTING THIS NOW AS THE DEALERS IGNORE THIS AS AN ISSUE AND JUST WANT OVER A $1000 TO REPLACE THE SAME DEFECTIVE PART WHICH WILL FAIL AGAIN. NHTSA IS MY LAST HOPE THAT LIVES WILL BE SAVED. THIS IS NOT AN UNUSUAL PROBLEM AS THERE ARE MANY REPORTS OF THIS DEFECT.

ELECTRIC POWER STEERING STOPPED WORKING WHILE I WAS ON THE HIGHWAY GOING 75MPH. TURNED CAR OFF THEN BACK ON AND IT DIDN'T HAVE AN ISSUE. THEN CUT OUT AGAIN WHILE I WAS DRIVING. ELECTRIC POWER STEERING HAS COMPLETELY FAILED

THE DIM HEADLIGHT ON PASSENGER SIDE KEEPS GOING OUT. THE WIRES ARE MELTED WHERE IT PLUGS IN TO THE LIGHT

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. WHILE TURNING THE STEERING WHEEL IN EITHER DIRECTION, A POPPING NOISE WAS PRESENT AND THE STEERING ABILITY SEIZED. UPON INSPECTION, IT WAS DISCOVERED THAT THE STEERING SHAFT PULLED OUT OF THE RACK. THE AIR BAG WARNING INDICATOR ILLUMINATED AFTER THE FAILURE. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. ELM CHEVROLET (301 E. CHURCH ST, ELMIRA, NY) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 157,000.

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU. THE CONTACT STATED THAT THE GEAR SHIFTER FAILED TO MOVE INTO GEAR WHEN ATTEMPTING TO DRIVE OR REVERSE. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT CALLED TRACY CHEVROLET AT (209) 835-4500 (LOCATED AT 3400 AUTO PLAZA WAY, TRACY, CA 95304) AND WAS INFORMED TO SCHEDULE AN APPOINTMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER DUE TO THE DIAGNOSTIC AND REPAIR FEES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. NO FURTHER ASSISTANCE WAS OFFERED. THE APPROXIMATE FAILURE MILEAGE WAS 295,000.

THE ELECTRONIC STEERING ASSIST WOULD FAIL WHILE DRIVING DOWN THE ROAD CAUSING THE VEHICLE TO LOOSE STEERING AND HAVE TO COME TO A STOP AND TURN VEHICLE OFF TO AVOID A CRASH. IT IS SCAREY AND DANGEROUS. MINE ISN'T THE ONLY MALIBU MAXX THAT HAS HAD THIS DANGEROUS PROBLEM.

THE STEERING ASSIST STOPS WORKING INTERMITTENTLY WITHOUT WARNING. I AM AN ELDERLY PERSON AND IT MAKES IT ALMOST IMPOSSIBLE TO STEER AT TIMES. IT DOESN'T NORMALLY DO IT WHEN GOING OVER 35 MPH. WHEN IT IS COLD OUTSIDE IT SEEMS TO DO IT MORE. I MAY JUST NOTICE IT MORE IN THE COLD BECAUSE I DRIVE SLOWER IN THE BAD WEATHER.

I PURCHASED MY USED 2004 CHEVROLET MALIBU NOVEMBER 23, 2016, THE DAY BEFORE CHRISTMAS. I WAS IN MOTION MERGING INTO PHILADELPHIA'S SCHUYKILL EXP WHEN MY STEERING WHEEL LOCKED IN PLACE FOR 2-3 SECONDS AS I WAS GOING OVER 55 MPH ON A SLIGHT TURN. I REMEMBER THE WRENCH LIGHTING UP IN THE TOP LEFT CORNER OF THE DASHBOARD AND READING 'POWER STEERING' MESSAGE ON MY THE SCREEN. THE STEERING WHEEL STIFFENS AS IF YOU HAVE THAT CAR THAT RUNS OUT OF STEERING FLUID. ANOTHER INCIDENT HAPPENED AGAIN WHILE IN MOTION, WHEN I WAS COMING DOWN PHILADELPHIA PIKE MERGING ON THE I-95 SOUTH. AGAIN, THE STEERING WHEEL LOCKS FOR A FEW SECONDS, READS POWER STEERING ON THE SCREEN WITH THE ORANGE WRENCH IN THE BOTTOM LEFT CORNER OF THE DASHBOARD. IT'S FRIGHTENING BECAUSE MY CAR COULD GO IN ANOTHER LANE AND HIT AN INCOMING CAR, OR VICE VERSA. THE FIRST TIME I COULDN'T PULL OVER TO RECOOPERATE BECAUSE THERE ARE NO SHOULDER LANES. I'M STILL HAVING THIS ISSUE AND IT HAS BEEN TWO YEARS. EVEN WHEN I AM PARALLEL PARKED SOMETIMES, MY STEERING WHEEL TIGHTENS AND I CAN'T FULLY TURN THE WHEEL. WHEN I CALLED CHEVROLET THE FIRST TIME, THE REPRESENTATIVE ASSURED ME THAT THERE WERE NO RECALLS SHOWN FOR MY VIN NUMBER. I WAS DIRECTED TO GO TO CHEVY AND TOLD ME IT WAS A STEERING COLUMN ISSUE. THE COST AND LABOR ITSELF IS STEEP. I CALL TO FOLLLOW UP AND THEY BASICALLY TOLD ME THEY COULD NOT DO ANYTHING ABOUT THE PROBLEM BECAUSE IT WAS OUT OF THE TIME FRAME FOR THE WARRANTY WHICH DOESN'T MAKE SENSE BECAUSE NO MANUFACTURER EXPECTS TO RECALL TO HAPPEN.. AND PAYING FOR THAT REPAIR IS NOT EVEN A GUARANTEE THAT IT WILL FIX THE ISSUE BASED ON THE OTHER COMPLAINTS.

CAR WAS RUNNING A LITTLE ROUGH GOING UP HILLS AT 106,000 MILES SO I HAD A TRANSMISSION SERVICE DONE AT AAMCO. 2 DAYS LATER THE CAR IS IN LIMP MODE BARELY MADE IT HOME COASTED. LOW RPMS HAS NO POWER AND FOR SOME REASON IT WILL NOT GO INTO REVERSE NOW. GETS HIGHER RPMS AND PULLS IN NEUTRAL. BEFORE THAT THE CAR WAS FINE BESIDE A SUSPENSION/ SHOCKS THAT WERE NEVER ABLE TO BE REPAIRED BY EVERY MECHANIC I WENT TO.

TAKATA RECALL. MY RADIO STARTED DISPLAYING A SERVICE AIR BAG MESSAGE AND MY HORN STOPPED WORKING. THE WIRING IN THE CAR HAS STOPPED WORKING. I BEGAN TO REPLACE LIGHTBULBS THINKING THEY WERE BLOWN BUT JUST WILL NOT WORK. HEARD THIS CAR WAS RECALLED FOR THESE EXACT PROBLEMS I AM HAVING BUT FOR SOME REASON MY CAR HAS NO RECALLS. MY STEERING WHEEL MAKES A KNOCKING NOISE WHEN TURNING VERY SHARP. SOUNDS LIKE A PIECE IS BROKEN KNOCKING AROUND