2019 CHEVROLET MALIBU HYBRID Complaints

Suddenly my vehicle would not allow me to shift into different gears and was stuck in drive gear. The shift selector does not allow me to change gears even though it has the same resistance on the shift selector lever. In order to allow the vehicle to shift gears, I had to go under the vehicle to manually switch gears by pulling the transmission selector located under the vehicle. Each time I drive my truck I have to go under my vehicle and manually pull the transmission selector to change gears out of drive.

The contact owns a 2019 Chevrolet Silverado. The contact stated while driving at an undisclosed speed, the steering wheel failed to steer in the intended direction. The service power steering warning light illuminated. The contact stated that, fortunately, the failure occurred while the contact was driving in the contact's residential driveway. The vehicle was taken to the dealer where it was diagnosed with a failed electrical ground strap. The contact was informed that the electrical ground strap needed to be replaced. The vehicle was repaired. The contact referenced a Customer Satisfaction Program N25251590, however the contact was informed that the repair was not covered under the program. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline and report the failure. The failure mileage was approximately 60,000.

On Tuesday April 28 while I was driving the engine suddenly started making a strange noise and the engine died. It would not restart. I had it towed to the dealer and was told the cam shaft “spun” and destroyed the engine. I am now having to replace the engine at a cost of $11,000!

I purchased the truck in 2021 from a chevy dealer with 32k miles on it, truck looked great and performed great, at 42k miles it started to be sluggish and it would vibrate between 30-40 and 60-70 as i feathered the gas pedal to maintain speed, but if i gave it more gas or take my foot off the pedal it would stop vibrating, I've taken it to 2 chevy dealers, the first one said it drives within GM spec's. the 2nd one looked more promising but my warranty ran out at 75k and i was at that mileage. So today at 93k on it, it still vibrates and sluggish from a start. I looked online and many people have similar problems. ALSO: The paint around my front wheels is peeling off down to the primer, I've had many vehicles and never had this happen to me, It's just flaking off, When i had the truck at the chevy dealer for maintenance and told him about it, He said GM will not fix it and they know about the issue. Now these trucks are not cheap, It seems like once they sell the vehicle GM washes their hands of it, I guess that's why they only give you 36,000 mile warranty because they don't even trust their product to last.

I want to start off by saying that I have taken meticulous care of this vehicle and the intention was to keep this truck forever. However, that will not be possible after this incident. I was driving the vehicle at 60 mph when I noticed smoke coming out of the back of the vehicle and at that moment, the dash cluster started warning to shut off the engine immediately due to a lack of oil. I know there was plenty of oil in the engine because I just had the oil changed at a shop two weeks prior to the incident. I was able to verify that it was a total of 22 seconds from the time I noticed the smoke to the time I was able to pull off safely and shut the engine off. At that time, the engine had not seized, and I was able to manually shut off the engine on my own. I never tried to restart the engine and I had it towed to a shop that was nearby. 48 hours later the mechanic inspected it and discovered that the oil cooling line had somehow disconnected from the engine block, which had resulted in a catastrophic loss of oil. When that repair was made, the mechanic discovered that the engine would not start either by hand or automatically and deemed the engine to be seized. The engine in question is the Chevrolet 6.2L L87 engine that was involved in a manufacturer recall for models made in 2020 through 2024. My vehicle is the 2019 model and although there have been numerous occasions that I’ve been able to find in only a short period of research that revealed similar issues with a 2019 L87 6.2L engine, there still is no official recall on my specific model year. It was 1:30 in the morning, and I was rushing my sick dog to the emergency vet when this happened. Not only did it cause a major inconvenience trying to get him there in a timely manner, but our safety was also compromised in the process.

6.2 gas Engine was knocking and shaking while driving it Engine is currently being replaced , but not finished yet Mechanic thinks some rod bearings are bad and maybe some pushrods No warning lights came on

I Was traveling home one night and the truck shut off while driving and lost all power, loosing all steering, braking power aswell as all my lights while traveling down the road in the dark. . When I went to start it again all I would get was a cranking noise but no firing. After 30 minutes of waiting the truck started again. In which I drove it 3 more miles before it shut down again. After that it would not crank nor start. I then had the vehicle towed to my local Chevrolet dealer, and they had notified me that the engine had failed and locked up. In the process it had also taken out the FPCM (fuel pump control module) aswell as the high pressure fuel pump located on top of the motor. Causing me to have a new motor from GM installed. I had no previous problems or lights before this had happened.

I have a 2019 Chevrolet trialboss with a 5.3 L engine and the lifters went out on this vehicle! Now it’s needs a new engine! And there seems to be a huge trend with this.

I am filing this complaint to report a critical manufacturing safety defect regarding the rear differential in my 2019 Chevrolet Silverado 1500. During a recent dealership inspection at approximately 40,400 miles, an authorized GM service center (Jack Hanania Chevrolet) discovered that the vehicle's rear differential was completely "bone dry" of gear oil . Because there is no history of catastrophic fluid leaks, seal blowouts, or external damage, this strongly indicates that the rear differential was either never filled or improperly filled with lubricant at the factory during vehicle assembly. This issue originally presented as a persistent drivetrain vibration, shudder, and "skipping" sensation starting as early as 12,000 miles . I brought the vehicle to the dealership for this exact vibration at approximately 21,000 miles. The dealership misdiagnosed the issue as "low transmission fluid" (despite the transmission being a sealed system) and failed to inspect the rear differential . The symptoms persisted until the vehicle was immobilized in November 2025, which is when the bone-dry rear differential was finally discovered . A vehicle operating with an empty rear differential poses an extreme and immediate safety hazard. The lack of lubrication causes severe internal heat and friction, inevitably leading to a sudden, catastrophic mechanical seizure of the rear axle . If the rear wheels lock up while driving at highway speeds, it will cause an immediate loss of vehicle control, resulting in a high-speed collision. I urge NHTSA to investigate GM's factory fluid-fill procedures and quality control for 2019 Silverado differentials to prevent a fatal lock-up event for other drivers on the road.

The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that the vehicle required an oil change every 1,000 miles driven due to excessive oil consumption. Additionally, there was an abnormally loud sound coming from the lifters. The vehicle was taken to a dealer and was diagnosed with excessive oil consumption and failures with the lifters. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 198,000.