2004 CHEVROLET MALIBU MAXX Complaints

DRIVER'S SIDE SEAT SUDDENLY SHIFTED FORWARD AND DOWN WHILE DRIVING. INSPECTION REVEALED BROKEN WELD ON SEAT FRAME. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. WHILE DRIVING 5 MPH, THE POWER STEERING LOCKED UP SUDDENLY. THE ENGINE WAS TURNED OFF, RESTARTED AND THE STEERING RESET ITSELF. THE CONTACT PLANNED TO HAVE THE VEHICLE INSPECTED BY AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 65,000.

POWER STEERING COLUMN IS ABOUT TO FAIL FOR THE THIRD TIME. FIRST TIME AT 45,000 MILES, SECOND TIME AT 83,000, NOW AT 169,000. *TR

MY 2004 MALIBU MAXX HAS A BROKEN WELD OF THE SEAT COMPONENT. THE CAR IS OUT OF WARRANTY, HAS APPROXIMATELY 55,000 MILES ON IT, AND THE REPAIR IS CLOSE TO $1000 AS THE ENTIRE SEAT FRAME HAS TO BE REPLACED. THERE ARE NUMEROUS COMPLAINTS BY OTHERS ON THE SAME CAR, SAME YEAR, SAME MODEL, SAME MAKE. SEE HTTP://WWW.ARFC.ORG/COMPLAINTS/2005/CHEVROLET/MALIBU_MAXX/SEATS/PROBLEM.ASPX. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. WHILE DRIVING APPROXIMATELY 10 MPH OVER A SPEED BUMP, THE FRONT DRIVER SEAT COLLAPSED THREE TO FOUR INCHES INTO A TILTED POSITION. THE CONTACT ADJUSTED THE POWER SEAT TO THE LOWEST LEVEL TO SECURE THE SEAT AND THE CONTACT WAS ABLE TO RESUME DRIVING THE VEHICLE WITH CAUTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE DEALER WHERE THEY INFORMED THE CONTACT THAT THE DRIVER SEAT MOUNTING BRACKET WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

IN A TURN AT HIGHER SPEEDS, THE STEERING WHEEL BECOMES STIFF, HARD TO TURN, AND THE BELL ALARM GOES OFF. *TR

TL*THE CONTACT OWNS A 2004 CHEVROLET MALIBU MAXX. THE DRIVERS SEAT FRAME THAT SUPPORTS THE SEAT WAS BROKEN SINCE 2008. THE VEHICLE WAS TAKEN TO THE DEALER WHO INFORMED HIM THAT IT WOULD COST HIM $1000 FOR REPAIRS. THE VEHICLE WAS NEVER REPAIRED. THE MANUFACTURER WAS NEVER NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 100,000.

I OWN A 2004 CHEVROLET MALIBU MAXX. THE POWER STEERING IN THE VEHICLE GOES OUT WHILE THE CAR IS IN MOTION. WHEN POWER STEERING GOES OUT, I HAVE TO STOP THE VEHICLE WHERE I AM AND TURN THE CAR OFF AND RESTART THE VEHICLE TO GET POWER STEERING TO COME BACK ON. ALSO THE LEFT TURN SIGNAL LIGHT CONTINUES TO GO OUT. I HAVE REPLACED THE LIGHT SEVERAL TIMES AND IT CONTINUES TO BLOW AFTER A DAY. THE TURN SIGNAL BEING OUT MAKES IT HARD FOR ME TO TURN WHEN AT STOP SIGNS. OTHER DRIVERS DON'T KNOW I AM TURNING AND TRY TO DRIVE WHILE I AM MAKING A TURN. *TR

DATE: 11/15/10. 2004 MALIBU MAXX LT. WHILE EXITING A LIMITED ACCESS HIGHWAY AT 25 MPH, THE DRIVER'S SEAT SUDDENLY DROPPED TWO OR THREE INCHES DOWN AND TO THE RIGHT, NEARLY CAUSING THE OPERATOR TO CRASH INTO THE SAFETY BARRIER. ONCE THE VEHICLE WAS STOPPED, AN INSPECTION REVEALED THE SEAT FRAME WELD HAD SEPARATED. RESEARCH SHOWS THIS IS A PROBLEM THAT HAS BEEN REPORTED TO THE NHTSA ON A NUMBER OF OCCASIONS WITHOUT CORRECTIVE ACTION. THE DEALER HAS INSPECTED THE DAMAGE AND CLAIMS THIS IS A RECURRING ISSUE. REPAIR IS OVER $1,000. THE RESULTING LITIGATION WILL RUN IN THE 10'S OF MILLIONS AS THE DEALERSHIP NOTES THAT IN A COLLISION THE SEAT MAY NOT STAY ANCHORED. THE SAFETY RESTRAINT IS ALSO ATTACHED TO THE SEAT, SO IT WILL BE INEFFECTIVE AS WELL. INVESTIGATE AND ISSUE THE RECALL! *TR

I NOTICED THE DRIVER SEAT WAS "ROCKING" TO THE RIGHT WHEN I SAT DOWN. WHEN I LOOKED UNDER THE SEAT I NOTICED THAT THE CROSSBAR WAS BROKEN AT THE WELD JOINT ON THE RIGHT SIDE OF THE SEAT. *TR