2002 CHEVROLET S10 Complaints

2002 CHEVY S-10 CREW CAB REAR AXLE FAILURE FAILURE DUE TO WATER IN AXLE HOUSING DUE TO VENT PIPE BEING LOCATED BETWEEN CAB AND BED, OCCURRED ONCE, REAR AXLE LOCKED UP COMPLETE REBUILD OF REAR AXLE RELOCATION OF VENT PIPE. *TR

DOOR HINGES WERE WELDED FROM FACTORY THE WELDS LOOKED POOR JUST SPOT WELDED. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET S10. WHILE DRIVING APPROXIMATELY 10 MPH AND EXITING A PARKING LOT, THE CONTACT HEARD A LOUD NOISE OUTSIDE OF THE VEHICLE. IMMEDIATELY, THE VEHICLE WAS PULLED OVER AND THE DRIVER OBSERVED THAT THE DRIVER'S SIDE TAILGATE CABLE FAILED WITHOUT WARNING. WHILE THE VEHICLE WAS IN OPERATION, THE TAILGATE DRAGGED ONTO THE ROAD SURFACE DUE TO THE FAULTY CABLE. THE TAILGATE WAS REMOVED FROM THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. SHE HAS PICTURES OF THE FAILURE. THE FAILURE MILEAGE WAS 49,000 AND CURRENT MILEAGE WAS 50,000.

THIS IS THE THIRD VEHICLE OF THIS TYPE THAT I HAVE HAD TO HAVE A DOOR HINGE, BUSHINGS AND/OR HINGE PINS REPAIRED ON. 2004 CHEVROLET BLAZER FOUR DOOR (ODI NUMBER) 10255992. 2003 CHEVROLET BLAZER TWO DOOR (ODI NUMBER) 10256634. THE DOOR IS DROPPING CAUSING A PROBLEM TO EITHER OPEN OR CLOSE THE DOOR. DOOR STARTED CREAKING ABOUT A MONTH AGO AND SUBSEQUENTLY BECAME A SAFETY PROBLEM TO CLOSE IT PROPERLY. IT WAS RUBBING ON THE LOCK STRIKE. DOOR WAS TAKEN TO THE DEALER AFTER THE OTHER TWO WERE FOUND TO HAVE A PROBLEM WITH THE DOORS. I PRESUME THAT THE SAME REPAIRS WERE MADE TO THIS AS IT IS STILL IN THE DEALERS SHOP AS OF TODAY. WHEN ALL IS SAID AND DONE IT WILL HAVE COST FOUR HUNDRED DOLLARS PLUS TO REPAIR THESE DOORS AND MAKE THEM SAFE. IT IS NOT A NEW PROBLEM FOR GM AS IT HAS BEEN GOING ON IN VARIOUS MODELS SINCE THE 80'S. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET S10. THE CONTACT STATED THAT THE TAILGATE STRAPS FAILED AND WERE RUSTED. THE DEALER STATED THAT NHTSA WOULD BE THE ONE RESPONSIBLE FOR ISSUING A RECALL FOR THIS FAILURE. THERE ARE RECALLS ON OTHER CHEVROLET VEHICLES, BUT NOT THE CONTACT'S MODEL. THE FAILURE MILEAGE WAS 65,000.

THE MECHANISM TO OPEN THE 3RD DOOR ON MY CHEVY S10 PICKUP HAS BROKEN THREE TIMES. I HAVE STOPPED REPLACING IT, AS IT SEEMS FUTILE. THIS COULD PRESENT A SAFETY HAZARD IF SOMEONE IS SITTING IN THE BACK IN THE BENCH SEAT AND THERE IS AN ACCIDENT OR FIRE. IT WOULD BE VERY DIFFICULT FOR THEM TO EXIT THE VEHICLE (OR BE RESCUED FROM THE SEAT), ESPECIALLY IF THE DRIVER AND/OR PASSENGER OR INCAPACITATED. *TR

I HAVE A 2002 CHEVY S10 EXT. CAB PICKUP TRUCK WITH A VORTEX 4.3 LITRE ENG. WITH AUTOMATIC TRANSMISSION. WHILE BAKING OUT OF DRIVEWAY I NOTICED I HAD NO REVERSE GEAR, IT IS ALSO SLIPPING IN ALL OTHER GEARS. THIS TRUCK HAS NEVER HAULED ANYTHING HEAVY AND ONLY HAS 49,500 MILES ON IT . I GOT DOWN TO THE STOP SIGN AND TRIED TO PROCEED AND THE FORWARD GEARS STARTED TO SLIP AND I COULDN'T GET OUT OF THE WAY OF ONCOMING TRAFFIC AND ALMOST GOT HIT BY AN ONCOMING CAR. I HAVE HEARD AND TALKED TO MANY OTHER PEOPLE WHO OWN THESE VEHICLES WITH THE 4L60E/4O65E TRANSMISSIONS. I FEEL THESE COULD BE DANGEROUS. THEY SEEM TO ALL HAVE THE SAME SUN SHELL AND SUN GEAR PROBLEMS. I FEEL GENERAL MOTORS SHOULD RE-CALL THEM. *TR

THERE WAS NO INDICATION THE SPARE TIRE WAS ABOUT TO COME OFF. I WAS DRIVING AT APPROX. 60MPH AND ALL OF A SUDDEN THERE WAS A LOUD THUD AND THE TRUCK SHOOK. I LOOKED BEHIND ME TO SEE MY SPARE TIRE SLIDING DOWN THE ROADWAY, ALMOST CAUSING A SERIOUS ACCIDENT BEHIND ME. IT ALSO PUT A DENT AND REMOVED SOME PAINT FROM THE UNDERSIDE OF THE BUMPER. THIS OCCURRED AT 32,000 MILES ON TRUCK. I WENT BACK AND RETRIEVED THE SPARE AND THREW IT INTO THE BED OF THE TRUCK. UPON FURTHER INSPECTION, I NOTICED THE DROP DOWN CABLE UNDER THE BED HAD CORRODED AND SNAPPED LESS THAN AN INCH FROM THE END, DROPPING THE TIRE AND LEAVING NOTHING BUT THE FRAYED CABLE BEHIND. THIS IS THE FIRST OCCURRENCE, AND IT HAS NOT BEEN REPAIRED BECAUSE THAT PART IS NOT COVERED UNDER WARRANTY. *TR

TAIL GATE CABLES ON 2 YEAR OLD S-10 TRUCK FAILED. DEALER WOULD NOT COVER COST OF REPLACEMENT. TWO YEARS LATER COMPANY HAD A RECALL FOR REPLACEMENT AND DEALER STILL WOULD NOT REIMBURSE COST OF REPLACEMENT. CALLED GM AND FOLLOWED THEIR INSTRUCTIONS TO SEND IN RECEIPT FOR REIMBURSEMENT BUT NEVER HEARD FROM THEM, CALLS NOT RETURNED. COMPANY AND DEALER WERE LONG ON TALK, VERY SHORT ON SERVICE. THIS IS ONE OF THREE SERIOUS S-10 DEFECTS, SO FAR. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET S-10. WHILE DRIVING APPROXIMATELY 70 MPH AND APPROACHING A STOP SIGN, THE FRONT DRIVER'S SIDE LOWER BALL JOINT DETACHED FROM THE VEHICLE. THE TIRE FOLDED AT A 45 DEGREE ANGLE. THE CURRENT MILEAGE WAS 80,300 AND FAILURE MILEAGE WAS 80,000. UPDATED 10/16/08 *BF UPDATED 10/20/08. *JB