2004 CHEVROLET SILVERADO Complaints

WHILE EXITING OF A HIGHWAY AND TRAVELING 25 MPH MY BRAKES COMPLETELY FAILED. I PUSHED THE PEDAL TO THE FLOOR SEVERAL TIMES BUT IT DID NOT SLOW THE TRUCK. AS A RESULT I REAR ENDED A VEHICLE IN FRONT OF ME. I HAD NOW WARNING OR CHECK LIGHT FOR THE BRAKES PREVIOUS OR SINCE. UPON INSPECTION I DISCOVERED CORRODED AND LEAKING BRAKE LINES IN THE MIDDLE SECTION OF MY TRUCK.

TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND. THE BRAKE FLUID WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED ON TWO OTHER OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.

I WAS DRIVING ALONG AND HAD TO HIT THE BRAKES IMMEDIATELY. I ALMOST HIT THE CAR IN FRONT OF ME. I NOTICED I HAD TO START PUTTING THE BRAKES ALL THE WAY TO THE FLOOR IN ORDER TO STOP, ESPECIALLY ON AN INCLINE. THE BRAKE LIGHT WENT ON AND OFF A FEW TIMES SO I TOOK IT TO A SHOP TO HAVE IT LOOKED AT. THEY TOLD ME THAT MY BRAKE LINE BLEW AND ALL THE OTHER BRAKE LINES ARE RUSTED AND THE TRUCK IS NOT SAFE TO DRIVE. THIS TRUCK IS ONLY 11 YEARS OLD, THAT IS ABSOLUTELY UNACCEPTABLE THAT ALL THE BRAKE LINES ARE RUSTED. THE TRUCK ONLY HAS 108K MILES. I CALLED A LOCAL CHEVY DEALERSHIP AND THEY QUOTED ME 3K+ TO FIX IT. IT INVOLVED AT LEAST 20 HOURS OF LABOR AND THEY NEEDED TO LIFT THE FRAME OFF TO FIX. I CAN NOT BELIEVE THEIR ARE NO RECALLS FROM GM OR ATLEAST THEM OFFERING ANY HELP TO PAY FOR THIS. THE DEALER DID NOT OFFER ME ANY HELP OR REMEDY TO THE SITUATION, JUST WANTED ME TO FORK UP 3K.

TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKE PEDAL WAS DEPRESSED AND EXTENDED TO THE FLOORBOARD. THE CONTACT PLACED THE VEHICLE IN NEUTRAL AND WAS ABLE TO STOP THE VEHICLE. THE CONTACT THEN PLACED THE VEHICLE IN PARK, DEPRESSED THE BRAKE PEDAL ONCE MORE AND THE BRAKE PEDAL WENT TO THE FLOORBOARD AND THE BRAKE WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT UPON INSPECTION, THE BRAKE LINES UNDERNEATH OF THE VEHICLE WERE CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,527.

MY BROTHER INLAW OWNS A 2003 GMC SIERRA AND EXPERIENCED TOTAL BRAKE FAILURE DUE TO CORRODED BRAKE LINES IN 2009. UPON INSPECTING MY BRAKE LINES ON MY 2004 SILVERADO I OBSERVED THE THE BRAKE LINES WERE CORRODED AND WOULD HAVE TO BE REPLACED BEFORE THEY FAILED AS WELL. MY TRUCK WAS ONLY 5 YEARS OLD AT THE TIME! AFTER MUCH DISCUSSION WITH THE DEALERSHIP WHERE I PURCHASED THIS VEHICLE I DETERMINED THAT THEY WOULD NOT STAND BEHIND THEIR PRODUCT AND HAD TO PAY OUT OF POCKET FOR THE REPAIRS. I STILL HAVE THE CORRODED BRAKE LINES, RECEIPT AND PICTURES OF LINES ON TRUCK BEFORE REPLACEMENT. KEEPING ALL EVIDENCE IN CASE OF RECALL. BY THE WAY, MY EXHAUST SYSTEM LOOKS LIKE BRAND NEW. WHY DIDN'T THEY USE THE SAME MATERIAL FOR THE BRAKE LINES? I DON'T EXPECT ANYTHING TO BE DONE ABOUT THIS UNTIL CNN STARTS RUNNING STORIES ABOUT PEOPLE GETTING KILLED BY THIS PROBLEM!

THE BRAKE LINES ON MY TRUCK ARE COMPLETELY ROTTED OUT. WHEN I WENT TO GET INTO MY TRUCK AND DRIVE AWAY NO BRAKE PEDAL EXSISTED. YET AGAIN ANOTHER QUALITY GM PRODUCT MADE FROM INFERIOR MATERIALS.

THIS IS THE (2) TIMES LOSING MY BRAKES DUE TO RUSTED BRAKE LINES. TODAY 7-11-2015 I LOST THEM AGAIN AND ONCE AGAIN DUE TO RUSTED BRAKE LINES. I ENDED UP DRIVING INTO SOME BUSHES TO STOP AND JUST MISSING (2) TREES. IM NOT THE ONLY ONE IN THE US THAT IS HAVING THIS DANGEROUS PROBLEM WITH RUSTED BRAKE LINES ON THIS TYPE OF MAKE. I ASK THAT YOU RECALL THIS MAKE A.S.A.P. BEFORE ANY LIVES ARE LOST. ONCE AGAIN I REPEAT RECALL THIS MAKE A.S.A.P. IF I HIT THOSE TREES I'D BE DEAD!! P.S. HELP HELP!!!!!!

WIFE WAS DRIVING ON 301 SOUTH IN MARYLAND ON 10\27\2012 WHEN SHE APPLIED THE BRAKES WHEN PULLING OVER TO GET GAS. PEDAL WENT TO THE FLOOR AND BRAKE FLUID WAS VISIBLE ON GROUND BY THE DRIVERS SIDE DOOR. SHE HAD TO LEAVE IT AT THE GAS STATION UNTIL I WAS ABLE TO REPAIR. BRAKE LINE WAS RUSTED THROUGH I REPLACED IT AND GOT TRUCK HOME. REPLACED 2ND BRAKE LINE ON 11/08/15. NOW 07/10/2015 ANOTHER LINE HAS RUSTED THROUGH IN THE PROCESS OF REPLACING THE REMAINING LINES.

AIR BAG WARNING LIGHT OCCASIONALLY STARTED COMING ON. TOOK TRUCK TO SEVERAL INDEPENDENT SVC PLACES. THEY SAID DO NOT HAVE COMPUTER READER FOR AIRBAGS. LIGHT STARTED STAYING ON CONSTANTLY. TOOK TRUCK TO DEALERS AND THEY SAID BECAUSE OF LIABILITY, THE DIAGNOSTICS ARE $900 AND COULD RUN ANOTHER $1500 OR MORE TO FIX PROBLEM. AND, THEY WANTED TO KEEP TRUCK. TRUCK IS USED DAILY FOR SHORT RUNS AND HAS A BUNCH OF EQUIPMENT ON IT THAT WOULD HAVE TO BE REMOVED IN ORDER TO LEAVE IT SOMEWHERE. BECAUSE OF THE STAGGERING COST, AND THE INCONVENIENCE OF HAVING TO OFF LOAD THE TRUCK AND NOT HAVE ITS USE AND THE LACK OF PLACES TO WORK ON IT AT ALL, WE HAVE LEFT IT ALONE. I HAVE DRIVEN VEHICLES WITHOUT AIRBAGS OVER 3 CONTINENTS AND THROUGH JUNGLES & ALL TYPES OF TERRAIN OVER THE LAST 40 YEARS WITH OUT EVER NEEDING AIRBAGS. NOW TAKATA MAKES A SAFETY DEVICE THAT CAN SHOOT AND KILL YOU -- DO I NEED THIS? IF SO, WHO PAYS THE REPAIR BILL?

ON MAY 29TH MY SERVICE AIR BAGS LIGHT CAME ON. IN TALKING WITH OTHER CHEVY SILVER OWNERS OF THE SAME YEAR AND AROUND THAT YEAR IT SEEMS THIS IS COMMON. I PAID $521.18 TO GET THESE AIR BAG SENSORS REPLACED ON 17 JUN15 AT A DEALER IN HARRISBURG PA., BECAUSE I WAS TOLD WITHOUT THE SENSORS THE AIR BAGS WOULD NOT GO OFF. THIS IS A SAFETY ISSUE I AM BEING TOLD B Y OTHER DRIVERS THEY ARE JUST DRIVING AROUND WITH THE SERVICE AIR BAG SENSOR LIGHT ON. THATS UP TO THEM. ALSO ON 21 JAN 14 I HAD TO HAVE ALL THE BRAKE LINES REPLACED BECAUSE THEY HAD RUSTED AND WOULD NOT BE SAFE TO DRIVE THE TRUCK COSTING $720.00. I WAS TOLD IT WAS BECAUSE OF NORTHEASTERN WINTERS AND ROAD SALTS, WHICH I FIND TO BE A UNEXCEPTABLE ANSWER TO THE PROBLEM. ON 23 DEC 03 I PAID $356.96 TO REPLACE DASH CLUSTER WHICH ALSO IS A SAFETY PROBLEM. I THESE SAFETY PROBLEMS WITH THE SILVERADOS ARE BE IGNORED. MY QUESTION IS HOW MANY PEOPLE HAD BE AFFECTED OR INJURED BY THESE PROBLEMS?