2004 CHEVROLET SILVERADO Complaints

DRIVING A WELL MAINTAINED TWO WHEEL DRIVE 2004 CHEVROLET SILVERADO 2500 CREW CAB PICKUP AT 30 MPH ON A SUBURBAN ROADWAY. I APPLIED HARD BRAKING AND PEDAL WENT TO FLOOR. I WAS ABLE TO SHIFT AUTOMATIC TRANSMISSION TO LOW 1 AND APPLY E-BRAKE TO STOP BEFORE CRASH. EXAMINATION OF STEEL BRAKE LINES FROM MASTER CYLINDER TO THE ABS MODULE UNDER THE DRIVERS FLOOR SHOWED EXCESSIVE CORROSION AS REASON FOR FAILURE. THE LINES THAT WERE SPECIFICALLY AFFECTED TRAVEL OVER DRIVER SIDE FRAME RAIL AND ARE OUT OF SIGHT FOR ROUTINE VISUAL INSPECTION. THIS VEHICLE OPERATED IN THE "SALT BELT" (NEW ENGLAND) AND ROAD SPRAY FROM THE LEFT FRONT TIRE DIRECTLY IMPACTS THIS AREA. AFTER REPLACING ALL STEEL LINES WITH STAINLESS LINES (OVER $500.00 IN PARTS & LABOR) THE BRAKE SYSTEM WORKED AS DESIGNED. *TR

AFTER CHECKING THE UNDERSIDE OF MY 04 SILVERADO 1500 4X4 FOR A FUEL FILTER( WHICH IT DOESN'T HAVE) I NOTICED THE BRAKE LINES TO BE SEVERELY CORRODED. MOST OF THE WORST AREAS WERE IN THE BENDS AROUND THE FRAME FROM THE MASTER CYLINDER AND ALONG THE FRAME. *TR

WHILE EXITING A PARKING LOT, I APPLIED THE BRAKES TO STOP BEFORE PULLING OUT INTO TRAFFIC. THE BRAKE PEDAL WENT TO THE FLOOR SUDDENLY AND WITH NO WARNING. MY TRUCK WENT OUT INTO THE ROAD WHERE I QUICKLY TURNED HARD RIGHT TO AVOID CROSSING THE ROAD. I THEN USED THE EMERGENCY BRAKE TO PULL OVER AND STOP. I AM A MECHANIC BY TRADE, AND I KNEW RIGHT AWAY WHAT HAD HAPPENED. MY TRUCK IS IN EXCEPTIONAL CONDITION AS I AM ONLY THE SECOND OWNER. THE FIRST OWNER HAD GARAGE KEPT THIS VEHICLE AND IT HAS NEVER BEEN WRECKED. I DO NOT PLOW SNOW OR OFF-ROAD IT. I HAD A GM CERTIFIED MECHANIC FIX THE TRANSFER CASE ISSUE (GM ALSO KNOWS ABOUT THIS) LAST SUMMER. HE INSPECTED MY TRUCK THEN AND FOUND NOTHING TO BE ALARMED ABOUT. I DID TALK TO HIM ABOUT THE BRAKE LINES, TO WHICH HE TOLD ME THAT HE HAD TO REPLACE HIS IN HIS 2004 SUBURBAN. TWO OTHER FRIENDS OF MINE THAT BOTH HAVE 2004 TAHOES, HAD TO REPLACE THEIR BRAKE LINES DUE TO THE EXACT ISSUE. MY BROTHER-IN-LAW HAS A 2006 SILVERADO, HE REPLACED HIS LINES LAST YEAR, AGAIN FOR THE SAME PROBLEM! THIS IS A MAJOR SAFETY ISSUE AND GM WON'T STAND BEHIND THEIR OWN PRODUCT? I HAVE BEEN A GM OWNER SINCE I COULD DRIVE. I WON'T BE ANYMORE! I AM VERY DISAPPOINTED THAT A RECALL OR SOME TYPE OF ACTION IS NOT BEING DONE. *TR

TL* THE CONTACT OWNS A 2004 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 35 MPH, THE INSIDE OF THE VEHICLE EMITTED SMOKE AND THE CONTACT SMELLED BURNING WIRES. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 55,000.

BACKING OUT MY DRIVEWAY I APPLIED BRAKES AND PEDAL WENT TO THE FLOOR AND SAW BRAKE FLUID LEAKING TO GROUND BELOW DRIVER SIDE FRONT WHEEL AND DOOR. *TR

THE DASH INSTRUMENT CLUSTER FAILED AND DOES NOT READ A CORRECT TEMPERATURE NOR DOES THE OIL GAUGE READ CORRECTLY. THERE IS A CLICKING SOUND WITHIN THE INSTRUMENT PANEL CONTINUOUSLY. THE VEHICLE WAS TAKEN IN FOR SERVICE AT THE GM COMPANY. IT WAS DETERMINED THAT THE CLUSTER IS FAILING AND THE READING ARE NOT CORRECT ON THE DASHBOARD PANEL ARE NOR RIGHT. IT WILL REQUIRE REPLACEMENT. GM SAYS THAT THE SPECIAL RECALL FOR THIS PROBLEM IS EXPIRED AND THEY WILL NOT FIX MY TRUCK. THE SPECIAL RECALL EXPIRED IN 2011. *TR

EXHAUST MANIFOLD BOLT ON DRIVER SIDE AT REARMOST PART OF ENGINE HAS BROKEN OFF. *TR

MY BRAKE PEDAL WENT TO THE FLOOR DUE TO A RUSTED BRAKE LINE. I WAS ABLE TO STOP BUT VERY SCARY. UPON INSPECTION I REALIZED EVERY METAL LINE IN THE TRUCK IS RUSTED AND EITHER ALREADY LEAKING OR WILL BE SOON. I'VE HAD 5 CHEVY TRUCKS AND NEVER ENCOUNTERED ANYTHING LIKE THIS WITH ANY OF THEM. IF I WANT TO KEEP MY TRUCK SAFELY ON THE ROAD THAT I STILL OWE $10,000 ON, I AM NOW FACED WITH THE EXPENSE OF REPLACING EVERY BRAKE LINE, THE TRANSMISSION COOLER LINES, THE ENGINE OIL COOLER LINES, THE POWER STEERING LINES, PUMP AND COOLER, AND THE FUEL LINES. THIS IS RIDICULOUS! CHEVROLET GETS GOOD MONEY FOR THESE TRUCKS AND THEY OBVIOUSLY MESSED UP ON THIS DESIGN. THE RUST PROBLEM WITH THE WORKING PARTS UNDER THE TRUCK IS UNBELIEVABLE. I SHOULD BE ABLE TO GET MORE THAN 100,000 MILES OUT OF A TRUCK THAT COST $40,000! I AM SHOCKED THAT CHEVROLET PUT A STAINLESS STEEL EXHAUST ON THIS TRUCK THAT WILL LAST THE LIFE OF THE VEHICLE, BUT THE HIGH PRESSURE FUEL LINES THAT CAN CAUSE A FIRE OR THE BRAKE LINES THAT COULD KILL MY FAMILY ARE MADE OF INFERIOR RUST PRONE MATERIALS! GENERAL MOTORS SHOULD BE ASHAMED AND TUCK THEIR HEADS BETWEEN THEIR LEGS AS THEY WATCH THEIR LOYAL CUSTOMERS BECOME LOYAL TO ANOTHER AUTOMAKER THAT MIGHT HAVE MORE RELIABLE VEHICLES OR AT LEAST STAND BEHIND THEIR PRODUCTS AND DESIGNS. SHAME ON THEM! *TR

WAS COMING UP TO A RED LIGHT AND WHEN I PUSH ON THE BRAKE PEDAL , IT FAILED. LOST OF BRAKE PEDAL PRESSURE. GOT OUT AND LOOKED AND THERE WAS A HUGE PUDDLE OF BRAKE FLUID ON THE ROAD BELOW THE DRIVERS SIDE DOOR. *TR

APPROACHING STOP SIGN, BRAKE PEDAL WENT TO THE FLOOR WITHOUT ANY BRAKING. INSPECTION IDENTIFIED CORROSION THROUGH BRAKE LINE TUBING WALLS CAUSING LOSS OF PRESSURE AND FLUID. MASSIVE SYSTEM FAILURE OCCURED WITHOUT WARNING. *TR