2004 CHEVROLET SILVERADO Complaints

DT: THE CONTACT STATED THE SPEEDOMETER STOPPED WORKING WITHOUT WARNING. HE TOOK THE VEHICLE TO A LOCAL DEALERSHIP TO BE CHECKED. THEY DETERMINED THE INSTRUMENT CLUSTER PANEL WAS FAULTY. THIS CAUSED THE SPEEDOMETER TO MALFUNCTION. HE CONTACTED THE MANUFACTURER, AND THEY APPROVED THE REPAIRS TO BE MADE WITHOUT COST TO THE CONTACT. *AK

EARLY 2004 SILVERADO 3500 DIESEL. THE EXTENSION HOUSING BETWEEN THE TRANSMISSION AND THE TRANSFER CASE CRACKED DUE TO VIBRATION FROM THE DRIVE SHAFT U-JOINT FAILURE. TECHNICAL BULLETINS FROM CHEV ADDRESS THIS AS A COMMON PROBLEM. THEY HAVE REDESIGNED THE PARTS BUT WILL NOT STAND BEHIND THEIR PRODUCT TO REPAIR ANY EXISTING PROBLEMS. *NM

FAILURE OF THE NEUTRAL POSITION SAFETY SWITCH, 2004 CHEV SILVERADO DIESEL WITH ALLISON TRANSMISSION. THE SAFETY SWITCH SHORTS OUT AND FAILS DUE TO WET DRIVING CONDITIONS. THIS FAILURE RESULTS IN THE TRANSMISSION GOING INTO A "FAIL SAFE" CONDITION THAT DOES NOT ALLOW THE TRANSMISSION TO SHIFT, STRANDING THE VEHICLE. CHEVROLET HAS REDESIGNED THE PART NOW 3 TIMES, BUT WILL NOT WARRANTY OR STAND BEHIND THEIR PRODUCT. THIS SWITCH HAS FAILED ON ME TWICE DURING SNOW CONDITIONS. *NM

DT: THE CONTACT STATED SINCE PURCHASE OF THE VEHICLE THE BRAKES HAVE BEEN WEAK AND SPONGY. THE BRAKES WERE NOT ABLE TO STOP THE VEHICLE PROPERLY AND IT TOOK AN EXTREME AMOUNT OF PRESSURE TO STOP. THE VEHICLE HAS BEEN INSPECTED BY THE SALES DEALERSHIP AND TWO OTHER DEALERSHIPS AND THEY ALL STATED THERE WAS NOTHING WRONG WITH THE BRAKES. *AK UPDATED 1/11/2006. *NM

WHEN VEHICLE HAS BEEN DRIVEN FOR LESS THAN 2-3 MILES AND WHEN TRANSMISSION IS COLD THE FOLLOWING OCCURS: WHEN THE VEHICLE OPERATOR STOPS AT AN INTERSECTION, STOP SIGN, OR STREET CORNER - THE ENGINE AND TRANSMISSION CONTINUES TO PROPEL THE VEHICLE FORWARD WHILE THE BRAKES ARE APPLIED. THE RESULT IS THAT THE BRAKES ARE FIGHTING AGAINST THE ENGINE. THE VEHICLE OPERATOR MUST PUT THE VEHICLE IN NEUTRAL TO STOP THE VEHICLE. IN MANY CASES, THE VEHICLE TRAVELS WELL INTO THE INTERSECTION OR WELL PAST THE NORMAL STOPPING POINT BEFORE IT FINALLY COMES TO A HALT. THE RESULT HAS BEEN SEVERAL NEAR COLLIISIONS WITH CROSS TRAFFIC. THE DEALER HAS BEEN CONSULTED, BUT THE RESPONSE HAS BEEN: "UNABLE TO DUPLICATE THE PROBLEM - ALL SYSTEMS OPERATING CORRECTLY" "THIS IS NOT TRUE!! THIS VEHICLE HAS ONLY 16,000 MILES AND IS 18 MOS OLD - BUT THIS HAS OCCURRED NEARLY 10 TIMES. THE MOST RECENT IS 12/2/05. *NM

BOUGHT A 2004 CHEVORLET 2500HD USED. ONE WEEK AFTER PURCHASE THE TAILGATE BEZEL TRIM PIECE WAS LOST ON THE HIGHWAY. THEN A FEW MONTHS LATER THE SPEEDOMETER DIES ON QUITS WORKING, OR WORKS INTEMITTENTLY SOMETIMES STICKING. *NM

DT: THE REAR VIEW MIRRORS THAT WERE SPECIAL ORDERED FOR THE VEHICLE DID NOT EXTEND FAR ENOUGH TO ALLOW FOR PROPER VISION WHEN TOWING A EIGHT FOOT WIDE TRAILER. THE DEALER AND THE MANUFACTURER INFORMED AND THEY EXPLAINED THAT THEY COULD NOT OFFER A FREE REMEDY.*AK UPDATED 12/7/2005. *NM

DT: THE CONTACT STATED VEHICLE STALLED INTERMITTENTLY. THE DEALER REPLACED THE FUEL PUMP ON TWO SEPARATE OCCASIONS. THIS DID NOT CORRECT THE PROBLEM. ALSO, THE DEALER REPLACED THE IGNITION SYSTEM. THIS REPLACEMENT DID NOT CORRECT THE PROBLEM AGAIN. THE DEALER COULD NOT FIND THE CAUSE FOR THE PROBLEM. THE VEHICLE IS STILL HAVING INTERMITTENT STALLING. PROBLEMS. *AK

THE PROBLEM STARTED SOON AFTER I DROVE THE NEW 2004 CHEVROLET SILVERADO EXTENDED CAB OFF THE LOT. WHEN TRAVELING BETWEEN 60-70 MPH, THE TRUCKS SUSPENSION WILL BOUNCE ALMOST AS IF THERE ARE NO SHOCK ABSORBERS. THIS BOUNCING WILL CONTINUE UNTIL THE SPEED IS REDUCED TO BELOW 55 MPH. I BROUGHT THE TRUCK IN TO THE PITTSBURGH, CA DEALER AND COMPLAINED. THEY SAID IT WAS ONLY A "CALIFORNIA CONCRETE HIGHWAY" PROBLEM. THEY SAID IT WAS THE ROAD AND NOT THE TRUCK. I HAVE THIS PROBLEM ALMOST CONTINUALLY NOW, I COMPLAINED TO CHEVROLET'S CUSTOMER COMPLAINT SECTION, WHO GAVE ME THE SAME ANSWER. THE PROBLEM WITH THEIR ANSWER IS THAT I OWN A 1996 CHEVROLET SILVERADO EXTENDED CAB TRUCK THAT DOES NOT GO INTO UNCONTROLLABLE BOUNCING AS THIS ONE DOES. I ALSO DRIVE A CHEVROLET AVALANCHE THAT DOES NOT BOUNCE UNCONTROLLABLY AS THIS ONE DOES WHEN DRIVEN AT THE SAME SPEEDS ON THE SAME STRETCHES OF ROADWAY. I BELIEVE THERE IS EITHER SOMETHING WRONG WITH THE SHOCK ABSORBERS OR THE FRAME OF THE TRUCK. THE BOUNCING IS SO BAD THAT IT FEELS LIKE THE WHEELS ARE ACTUALLY LEAVING THE GROUND. I BELIEVE THIS IS A SERIOUS SAFETY ISSUE THAT CHEVROLET SHOULD ADDRESS. MY PROBLEM REMAINS UNRESOLVED. *NM

DT: THE CONTACT STATED THE COMPANY TRUCK THAT HE DROVE WAS INVOLVED IN AN ACCIDENT. UPON IMPACT, THE AIRBAGS DID NOT DEPLOY. THE ENTIRE FRONT END OF THE VEHICLE WAS DESTROYED. THE CONTACT SUSTAINED INJURIES. HE BRUISED HIS CHEST, SHIN AND TORE THE TENDON IN HIS ANKLE. THERE HAD BEEN NO ACCIDENTS IN THIS VEHICLE PRIOR TO THIS. A POLICE REPORT WAS TAKEN AT THE SCENE. *AK