2001 CHEVROLET SILVERADO 1500 Complaints

BRAKE LINES RUPTURED ON REAR AXLE DUE TO EXTERNAL CORROSION CAUSING TOTAL LOSS OF BRAKING. STEERED VEHICLE TO SIDE OF ROAD AND COASTED TO STOP. *TR

TL* THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE BRAKE LINES HAD EXTENSIVE RUST TO THE POINT OF CORROSION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NO REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 135,000. ...UPDATED 09-05-14 *BF UPDATED 3/30/2015 *JS

WHEN BACKING OUT OF DRIVE WAY BRAKES FAILED, I WAS LUCKING NO CAR WERE COMING ON THE ROAD I BACKED ONTO. AFTER GETTING IT STOPPED I PULLED BACK IN DRIVE WAY AND CHECKED IT OUT. THE BRAKE LINE GOING TO THE BACK BRAKES HAD A HOLE IN IT. I HAD THIS HAPPEN TO ME IN SEPT 2013 ON ANOTHER BRAKE LINE. *JS

DURING DECELERATION THE BRAKE PEDAL EXHIBITED LITTLE PRESSURE AND TRAVELED TO THE FLOOR. BRAKING ABILITY WAS SEVERELY COMPROMISED BUT THE VEHICLE CAME TO A STOP. INSPECTION OF THE UNDERCARRIAGE REVEALED A SEVERELY CORRODED BRAKE LINE LOCATED JUST AFT OF THE CAB WHICH HAD RUPTURED AND RELEASED A SIGNIFICANT AMOUNT OF BRAKE FLUID. *JS

MY TRUCK WAS PARKED AND WHEN I STARTED IT UP THE BRAKE PEDAL WENT STRAIGHT TO THE FLOOR WITHOUT STOPPING. I STEPPED OUT OF MY VEHICLE AND THERE WAS A POOL OF BRAKE FLUID ON THE GROUND. THE MECHANIC HAD TO REPLACE ALL THE BRAKE LINES DUE TO THEM ALL BEING BADLY CORRODED. *TR

SOMEONE RAN A RED LIGHT AND CREAMED INTO US AT ABOUT 50-55 MPH. THE IMPACT AREA WAS THE PASSENGER WHEEL WELL AREA AND THE IMPACT WAS SO VIOLENT THAT IT SMASHED EVERYTHING OVER AND INCLUDING THE STARTER... OUR AIR BAGS DID NOT DEPLOY AND I ALWAYS WONDERED IF IT WAS BECAUSE THE CRASH SMASHED THE STARTER AND HAD SOMETHING TO DO WITH THE GM RECALLS NOW. BOTH MY SON AND I HAVE NEVER BEEN THE SAME AFTER THAT CRASH AND NEITHER OF US CAN EVEN SLEEP IN A BED FROM NECK AND BACK PAIN... WE BOTH HAD BRAIN INJURIES AND MINE WAS RATHER SEVERE WHERE I LOST MY SUPERIOR INTELLIGENCE AND PHOTOGRAPHIC MEMORY...AND HAD SEVERE LANGUAGE AND SPEECH PROBLEMS... IT WAS ALMOST LIKE I WAS DYSLEXIC AND I HAVE NEVER BEEN THE SAME. BOTH OUR HEALTH DETERIORATED SINCE... I WAS TOLD 'OUR AIR BAGS WOULD HAVE DEPLOYED' IF IT WOULD HAVE BEEN A HARD IMPACT (WHICH IT WAS), SINCE THE MAN'S CAR WAS TOTALED FOR HOW HE HIT US WITHOUT EVER BRAKING OR SLOWING DOWN... SINCE THE IMPACT WAS THE PASSENGER WHEEL WELL AREA AND CORNER BUMPER CLEAR OVER TO THE DRIVER SIDE AND EVEN BROKE THE STARTER, I WONDER IF THE IGNITION DID SOMETHING TO MAKE THE AIR BAGS NOT DEPLOY. I ALWAYS FELT THERE WAS MORE TO THIS ACCIDENT, BUT NO ONE WOULD DO ANYTHING FOR US. NOW WITH ALL THESE GM RECALLS, I WONDER IF THERE WAS AN ISSUE WITH THIS ACCIDENT. CAN SOMEONE PLEASE LET ME KNOW IF OUR AIRBAGS SHOULD HAVE DEPLOYED WITH SUCH A VIOLENT CRASH AND IF WHEN THE CRASH BROKE THE STARTER IF IT COULD HAVE PREVENTED THE AIR BAGS FROM DEPLOYING? THANK YOU SO VERY MUCH. *TR

AFTER RETURNING TO THE TRUCK FROM AN ERRAND I STARTED THE ENGINE AND, UPON DEPRESSING THE BRAKE PEDAL IN ORDER TO PUT THE VEHICLE IN GEAR, THE BRAKE PEDAL WENT TO THE FLOOR. NO WARNING LAMPS OF ANY SORT WERE ILLUMINATED PRIOR TO THE BRAKE PEDAL GOING TO THE FLOOR. PUMPING OF THE PEDAL DID NOT PRODUCE ANY RESISTANCE. AFTER A FEW MINUTES THE BRAKE FLUID LEVEL WARNING LAMP CAME ON. BRAKE FLUID WAS ADDED BUT DID NOT RESULT IN ANY RESISTANCE FROM THE PEDAL. HAD TO HAVE THE TRUCK TOWED HOME WHERE IT THEN SAT OVER-NIGHT. I OBSERVED A LARGE WET SPOT ON THE DRIVEWAY JUST BELOW THE DRIVER?S SIDE DOOR. I LOOKED UNDERNEATH AND SAW THAT ALL OF THE BRAKE LINES GOING INTO OR OUT OF THE ABS MODULE WERE SEVERELY CORRODED AND AT LEAST ONE HAD OBVIOUSLY BEEN LEAKING BRAKE FLUID. THE TRUCK WAS TOWED TO A CHEVROLET DEALER. I ARRIVED AS THEY WERE RAISING THE TRUCK ON A LIFT. EVIDENTLY THEY ALSO ADDED SOME BRAKE FLUID BECAUSE QUITE A LARGE PUDDLE WAS FORMING ON THE SHOP FLOOR BELOW WHERE THE BRAKE LINES ENTER THE ABS MODULE. THE TECHNICIAN, THE SERVICE CONSULTANT, AND I ALL OBSERVED THE RUSTED BRAKE LINES, AND FLUID WAS LITERALLY DRIPPING FROM ONE THAT HAD OBVIOUSLY BURST. THE DEALER ADVISED THAT GM DOES NOT MAKE REPLACEMENT STEEL BRAKE LINES SO ALL THE LINES WOULD NEED TO BE HAND FABRICATED BY THE TECHNICIAN. DEALER ALSO ADVISED THAT THE ABS MODULE MAY HAVE TO BE REPLACED BECAUSE OF HOW CORRODED THE BRAKE LINE FITTINGS ARE (FITTINGS ARE STEEL, ABS MODULE IS ALUMINUM) WHERE THEY SCREW INTO THE MODULE. WE ALSO OBSERVED THAT THE FUEL LINES WERE SEVERELY CORRODED. I HAVE OWNED MANY VEHICLES FAR OLDER AND WITH FAR MORE MILEAGE AND HAVE NEVER HAD TO REPLACE THE STEEL BRAKE LINES. I BELIEVE THE DESIGN IS FLAWED (THE ROUTING AND PLACEMENT OF LINES AND MODULE) OR THE BRAKE LINE MATERIAL (STEEL, INSTEAD OF STAINLESS STEEL) IS INSUFFICIENT. *TR

BRAKE LINES ARE EXTREMELY CORRODED. THESE COULD RUPTURE AT ANY TIME WITH NO WARNING. CONTACTED GM WAS TOLD SINCE VEHICLE IS OUT OF WARRANTY THEY ARE NOT RESPONSIBLE. I HAVE OTHER CARS/TRUCKS THAT ARE OLDER AND HAVE NO BRAKE LINE CORROSION. THIS SHOULD REQUIRE A RECALL IMMEDIATELY BEFORE THERE ARE DEATHS FROM THESE INFERIOR BRAKE LINES. *TR

I HAVE A 2001 CHEVY SILVERADO 1500 EXTENDED CAB PICKUP TRUCK THAT I PURCHASED NEW. A NUMBER OF YEARS AGO THERE WAS A RECALL FOR ANTILOCK BRAKES IN RUST BELT STATES. SUPPOSEDLY THE SENSORS WERE DIRTY AND NEEDED TO BE CLEANED. WISCONSIN WAS INITIALLY NOT A RUST BELT STATE BUT EVENTUALLY WAS INCLUDED. PRIOR TO ITS INCLUSION MY ANTILOCK BRAKES WERE MALFUNCTIONING ON A REGULAR BASIS AND CAUSED THREE NEAR MISS ACCIDENTS BEFORE I PULLED THE FUSE TO CUT POWER TO THE SYSTEM. AFTER WISCONSIN WAS INCLUDED I TOOK MY CAR IN - THE SENSORS HAD RUSTED AWAY TO NON EXISTENCE. THEY REPLACED THE SENSORS. ABOUT 9 MONTHS AGO THE TRUCK BEGAN TO EXHIBIT THE SAME FAILURES CAUSING MORE NEAR MISSES. I CONTACTED GM. THEY REFUSE THE REPAIR IT A SECOND TIME. SO I HAVE DISABLED ANTILOCK BRAKES AGAIN. I THINK GM SHOULD BE MADE TO REPLACE THEIR SENSORS AND THEY SHOULD BE DESIGNING SENSORS THAT DON'T RUST AWAY. *TR

FIRST INCIDENT OF THE FUEL SENSOR FAILING (LOW FUEL LIGHT AND FUEL GAUGE INDICATOR FALSE) WAS AT 68,400 MILES. 2ND TIME FAILED ON 04/16/2011 AT 98,500 MILES WHICH COSTS ME ANOTHER 800.00 BUCKS. THIS IS THE 3RD TIME ITS STARTING TO ACT UP AGAIN AT 118,300 MILES, AND WILL PROBABLY COST ME AGAIN!! I CAN SEE IT HAPPENING ONCE, BUT NOT UNDERSTAND HOW IT CAN HAPPEN 3 TIMES THAT IS RIDICULOUS, NOT TO MENTION THE EXPENSE! CHEVROLET SHOULD HAVE HAD SOME TYPE OF RECALL ON THIS OR LEAST FIGURE OUT WHAT IS CAUSING THE PROBLEM. THERE IS NO DOUBT IN MY MIND THIS IS A DEFECT WITH THE PART AND VERY EXPENSIVE TO REPAIR. I HAVE RESEARCHED THIS PROBLEM AND IT SEEMS A LOT OF PEOPLE HAVE EXPERIENCED THIS ISSUE. THIS ISSUE COULD BE DANGEROUS AND PEOPLE HAVE LITTLE CHOICE FOR SAFETY REASONS BUT TO CORRECT THIS PROBLEM AT GREAT EXPENSE. THIS NEEDS A RECALL ..NOT EVERYONE HAS $800.00 LAYING AROUND AND GM SHOULD FIX THIS FOR FREE ESPECIALLY WHEN IT HAPPENS A 2ND, 3RD TIME! COME ON GM YOUR REP IS ON THE LINE.. *TR