2018 CHEVROLET SILVERADO 1500 Complaints

An independent service center confirmed that the water pump failed and fell apart. This water pump is a 4-groove pulley (part number 12685259) specific to my vehicle. Most other Silverados have a 6-groove pulley system. This 4-groove pulley water pump is unavailable from the dealer or any of the part stores, as they are on back order with no resolution or availability date. GM has notified some parts stores that this part has been discontinued and is no longer available. This truck is less than 10 years old. There are no other parts, either aftermarket or otherwise, to replace my water pump. The water pump is a vital engine component needed to prevent significant engine damage, and without it, the truck can not run independently without overheating. It is essentially the heart of the automotive cooling system, because the truck water pump function is to continuously circulate the engine coolant from the radiator to the engine and back to the radiator. I have had my truck in an independent service center since January 2025, waiting for this part, which is unavailable. I do have the original part at the shop available for inspection. There were no warning lamps, messages, or other symptoms of the problem before the failure; it just started making a clanking sound, and I immediately took it to a shop, and have been out of a vehicle for 5 months.

The contact owns a 2018 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the vehicle intermittently shuddered. No warning lights was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the torque converter needed to be replaced. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 47,000.

While driving steering wheel will lock up and become really hard to move, making it difficult to maneuver out of the road

The contact owns a 2018 Chevrolet Silverado 1500. The contact stated while driving 35 MPH, the vehicle went into LIMP Mode and was slow to respond as needed. The contact stated that there was smoke coming from the exhaust. While driving, the rear end locked up. The contact stated that the vehicle was slipping, and the vehicle shut off while driving. The contact stated that several unknown warning lights were illuminated. The contact replaced the spark plugs, coil pack, and spark plug wires with a misfire in cylinder #6. The contact stated that the fluids were replaced at an unknown local dealer prior to the failure. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 170,000.

Engine all of a sudden had no power or acceleration. Started shaking and thumping extremely loud.

The contact owns a 2018 Chevrolet Silverado 1500. The contact stated while driving 30 MPH, the transmission became stuck in second gear. The contact pulled over the right side of the road and turned off the vehicle for two minutes. The vehicle was then restarted and there was an abnormal banging sound coming from the gear shifter. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The Insurance Company had not yet been contacted. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 141,000.

I purchased a used 2018 Chevrolet Silverado High Country (VIN: [XXX] ) on [XXX], with 24,375 miles. On the day of pickup, the truck felt like it was driving over rumble strips. Dimmitt Chevrolet flushed the transmission and used the updated Mobil 1 HP LV fluid. This worked temporarily, but the shudder returned. CarMax then sent the truck to Burke’s Transmission in Sarasota, where they replaced the torque converter. However, the shop declined to rebuild the transmission, citing its complexity. I later brought the truck to Cox Chevrolet in Bradenton. Despite clearly describing the shudder, harsh shifting, and driveline clunk, they told me the behavior was “normal” and refused to investigate further, stating, “We’ll look into it once the unit fails completely.” The symptoms have worsened. Harsh 1–2, 2–3, and 3–4 shifts are back. Shifting into Drive causes a loud clunk and forward lurch. Cold starts cause bucking and sudden stopping. I’ve replaced the tires, Bilstein 5100 rear shocks, and front suspension parts, but the problem persists. I signed on to a class action lawsuit against GM over the 8L90 transmission, but my claim was denied. This issue is well-documented and matches reports from many other owners. It affects drivability, safety, and long-term reliability. GM and its dealers have failed to properly address this known transmission defect. I urge NHTSA to investigate further. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

on or about [XXX] while driving through Olathe Kansas, the torque converter and subsequently the transmission on my 2018 Chevy Silverado 1500 failed while driving in heavy traffic. While navigating to a safe place outside the high-speed traffic corridor, the truck would run at approximately 3000 RPM at a speed of 40MPH. By sheer luck, we were not involved in a traffic accident. Replacement cost of the transmission unit was $7907.88 and $800 for a rental truck while the dealer replaced the transmission. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

transmission temprature excessively high, there is a TSB#21-NA-199 Document[XXX] on Thermo bypass vlave on 2018 trucks 6 speed transmissions. 200 degree transmission temp is too high. Service advisor originally said thats normal, after high temp issue a 5th time. I referenced the TSB #21-NA-199 to the dealership service advisor, Advisor said bring it in. Dealer replaced the original Thermo 198 degree transmission bypass valve with Gm's recommended 158 degree trans bypass vlave. Delaer proceeded to charged me $200 diagnostic fee and $167 for part and $258 for labor Total cost was $658 from Holz Morots Hales Corners Wisconsin. My truck was purchased in 2020 and I recieved the full 6 year warranty vehicle currently has 57,000 miles. Im within 60,000 drive train warranty. Dealer claims TSB is not part of the drive train warranty therefor not covered. How's that possible, a drive train is damaged by excessive heat and the thermo bypass valve of 198, creates excessive heat in the transmission destroying countless chevrolet transmissions. My position is: if the Thermo Bypass transmission vlave is not part of the drive train, then what is it doing in my transmission which moves the vehicle? I want to file a complaint, I want Chevrolet to stand behind the product they built and sold . Dodging responsibility on technicality is how Chevrolet will lose buyers. I'm very unhappy with the way I was treated with zero responsibility for the GM product. The dealership would not provide any type of discount .. too add insult to injury the dealer charged me a diagnostic fee after lengthy conversation on the problem which is absurd and offensive to any consumer. I paid and I said to myself, Chevrolet just lost a great customer because of a lousy policy claiming the thermo by pass valve is not part of the drive train ... Bleed the consumer for a repair on the failures created by the manufacturer. Its under warranty on top of it all.. Best Regards [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)

Bad torque converter cause transmission to totally fail. Had chevy do transmission flush,2 yrs ago. Back in Aug 2024, transmission started to slip,while driving,then totally failed,no forward or reverse gears,nothing, had truck towed into chevy dealer, almost $7000.00 later,transmission had to be replaced.