2021 CHEVROLET SILVERADO 1500 Complaints

I completed the N252494003 recall inspection on my 2021 Chevy Silverado 1500 6.2L at Carl Black Buick/Chevy/GMC in Roswell, GA. They said my crankshaft was not one of the vehicles affected and sent me on my way with my free oil change as a remedy to the issue. I subsequently used that information, thinking the “bottom assembly” of my motor was good and not impaired, and proceeded to have the DOD/DFM deleted from the motor because it was a known fail point and this work cost me $7,000. Maybe 6 months after my inspection for the recall, I begin to hear a noise and I take it to the same dealership for service and they tell me the crankshaft is faulty. Nothing about the DOD/DFM delete and subsequent ECM tune had any impact on the crankshaft and yet, the dealership is denying fault when it was there service department hid the truth of the engine during the inspection. The warranty for the crankshaft is no longer applicable because of the modifications I did, but had they been honest about the faulty crankshaft, I would’ve never done that work to it in the first place. The engine should’ve been flagged during inspection and replaced.

While towing at night with horses, trailer lights started blinking on and off, eventually for longer periods, then stopped working all together. Research shows this is a common problem in GM vehicles related to the wiring and trailer light module. This is especially dangerous when pulling horses at night and all of the sudden lights go out. GM issued a technical service bulletin. This should be a recall...

For the second time in my 2021 Chevrolet Silverado with a 5.3-liter engine, I've had GM lifter failure. It's directly related to the Active Fuel Management System (AFM), and was confirmed by my Chevrolet dealer's mechanic and service writer, Burdick Chevrolet in Cicero, New York, on both occasions. They've had to perform a multi-thousand-dollar lifter replacement service job. They've told me that GM is aware of the safety issues, but won't do anything about them. It also happened to me with my 2014 Chevrolet Silverado, but I was lucky that time. It was fixed with new spark plugs and wires. It's cost me thousands of dollars for repairs each time. But that's not why I'm reporting this to NHTSA. The issue is safety. When the lifters fail, you get no warning. The truck rattles and rumbles. It becomes unstable on the road, and sometimes wobbles as if it's about to go out of control. The problem causes the loss of electronic stability control (ESC) and renders the electronic parking brake useless. Lifter failure can also cause the engine to stall while driving, especially at a stoplight. This happened to me. I had to press the gas pedal gently to keep the engine running at a stop light just to get off the road. On the highway, when the lifters fail, the truck slows to a point where it cannot keep up with traffic. That presents a dangerous situation. It's not safe. GM knows about it, but as far as I understand, the company has done nothing to fix the safety problem. Internet forums are full of comments about the problem, the safety issues, and the enormous cost of repairs. Surely your agency can compel GM to fix the lifter failure problem before someone suffers a major accident due to an uncontrollable vehicle. I'll never buy another vehicle with AFM. Many people are unaware of the dangers involved with this system. GM should get rid of it. [XXX] Skaneateles, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Truck is equipped with a 6.2 engine. It is a 2021 with less than 100k miles on it. Dealership is stating engine failed for no reason. Dealership confirmed engine failure this past week of April 2026. This is a known issue and my vehicle is not under the recall. Truck stalled out of no where. There was no warning before it did it.

right bank collapsed lifter. this is the 3rd time in 5 years this has happened same side same lifter. loss of power engine shakes the whole truck. Also electronic emergency brake won't release automatically and engages when driving. This has happened when I first bought the truck in Mar 2021, again in nov 2024 and currently at antelope valley Chevrolet on Mar 20 2026 for the same thing.

When taking off it will sometime have hard shifts, shuddering, and acceleration hesitation. While driving, it will do static jolts. Dealer couldn’t pin point problem and advised for a new transmission or we could drive it until it dies. Dealer didn’t recommend to change transmission oil in fear of creating more damage.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that additional engine oil was needed a month or two after an oil change. The contact stated that one quart of oil was added every 1,500 miles driven. The vehicle was taken to a local dealer, and it was informed that it was normal operation for vehicles with the 6.2L engine. The vehicle was not repaired. The manufacturer was informed of the failure and opened a case for the contact and referred the contact to the NHTSA Hotline to report the failure. The contact researched online and related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The failure mileage was approximately 22,000.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that the vehicle had experienced several electrical failures, including the door locks erroneously unlocking and locking while driving, and occasionally, the ignition key could not immediately be removed from the ignition switch after turning off the vehicle, causing the battery to drain. Recently, the vehicle failed to immediately start after inserting and turning the key inside the ignition switch. The cause of the failures was not yet determined. The manufacturer was notified of the failures, but no assistance was offered. The local dealer was not contacted. The failure mileage was approximately 60,000.

I am writing because I have a truck with the 6.2L L87 engine and it has been burning oil at every start up and acceleration from stop signs or stop lights, it blows out a blue cloud of smoke. I have asked Jeff Belzers in Lakeville , Mn to look and they did not as my vin did not show up in the recall. I took it to Maur Chevrolet in Inver grove heights, Mn and they told me that my miles were too high and they did not do an oil consumption test. I am burning 2 1/2-3 quarts of oil every 3,000 miles. I called the GM customer service line and they said there is nothing they can do except note it, so if I do get it repaired and pay for it, I could possibly get reimbursed in the future. If there is a known issue with this engine and there being 3 different engine builders, than why is it that my engine doesn't fall under that recall. It has all the symptoms of the engine failure that is specified in the recall? And it started about 6 months ago. Thank you Sincerely, [XXX] P.S. I have 136,000 miles and the special coverage warranty runs out at 10 years or 150,000 miles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The coolant control valve failed and the repair resulted in an engine oil leak which persisted for 8 weeks and still has not been repaired. The service manager at the dealership and General Motors Company are trying to figure out how to fix it but are not able to yet. They may have to replace the engine is one thing the service manager said to us this week.