2002 CHEVROLET SILVERADO 1500 Complaints

WHILE DRIVING ON US RT 202 THE LIGHT AHEAD OF ME TURNED RED SO I ATTEMPTED TO SLOW DOWN AND MY BRAKE PEDAL WENT STRAIGHT TO THE FLOOR AND DID NOT STOP OR SLOW DOWN. I HAD LOST BRAKE PRESSURE. RAN THE RED LIGHT WHERE I ALMOST T-BONED ANOTHER CAR, RIGHT IN FRONT OF A POLICE OFFICE. AFTER AVOIDING THE CRASH I PARKED ON THE SIDE GOT OUT AND SAW BRAKE FLUID POURING OUT OF THE DRIVERS SIDE UNDER THE DRIVERS DOOR AREA. THE BRAKE LINES HAD FAILED DUE TO RUST. I AND OTHER MOTORISTS COULD HAVE BEEN SERIOUSLY INJURED FOR AN ISSUE THAT BOTH GM AND THE NHTSA KNOW ABOUT. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE DRIVER SIDE SEAT BELT WOULD SUDDENLY RETRACT AND PREVENT THE CONTACT FROM MOVING. ALSO, THE CONTACT INDICATED THAT THE IGNITION KEY BECAME LODGED IN THE IGNITION SWITCH AND COULD NOT BE REMOVED. IN ADDITION, THE ABS SENSOR LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ABS PUMP MOTOR WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 168,000.

WHILE TRAVELING AT 25MPH AND COMING TO A SLIGHT ABRUPT STOP, THE BRAKE PEDAL FELL TO THE FLOOR WHILE DEPRESSING THE PEDAL TO STOP. THE VEHICLE CAME SLOWLY TO A STOP WITH STEAM RISING FROM UNDER THE VEHICLE. UPON PULLING THE VEHICLE TO A SAFE LOCATION AND UPON INSPECTION, IT APPEARS AS IF ONE OF THE METALLIC (ASSUMING STEEL) BRAKE LINES FEEDING FROM THE MASTER CYLINDER TO THE ABS BLOCK HAD BURST. NO INDICATION LIGHTS ON THE DASH OF A BRAKING SYSTEM FAILURE OR LOW PRESSURE ALERT FOR THE SYSTEM. IT APPEARS THAT THE BRAKE LINES WERE CORRODED/RUSTED. UPON DISCUSSING WITH A REPUTABLE AUTO SHOP, THEY INDICATED THAT THIS IS A COMMON ISSUE ON THIS MODEL YEAR VEHICLE AND THAT A REPAIR TO REPLACE THE LINES MAY BE REQUIRED. THIS IS A SAFETY ISSUE IN MY OPINION AND IF THE MATERIALS USED TO MAKE THIS SAFETY SYSTEM WERE NON-CORROSIVE; THIS WOULD HAVE NOT HAPPENED. *TR

THE ABS SYSTEM ACTIVATES OR DOES NOT ALLOW YOU TO STOP. IT SEEMS LIKE THE TRUCK CONTINUES TO ACCELERATE. PUMPING THE BRAKES DOES NOT WORK. PUTTING IT IN NEUTRAL OR RAMMING IT IN PARK IS THE ONLY WAY TO STOP IT. I ALMOST RAN SOMEONE OVER TODAY. THIS IS A VERY SERIOUS ISSUE. I CAN NOT DRIVE THIS TRUCK IN THIS CONDITION. LOOKING AT THE FORUMS OUT THERE THIS IS A WELL REPORTED PROBLEM YET I HAVE NOT BEEN MADE AWARE OF THE RECALL. I HAVE NOT CHANGED MY ADDRESS AND HAVE OWNED THIS FOR MORE THAN A YEAR AND A HALF. *TR

BEGAN TO SMELL GAS AND COULD VISUAL SEE FUEL LEAKING FROM IN THE AREA OF THE FUEL TANK. MECHANIC CONFIRMED FUEL WERE LEAKING DUE TO CORROSION. *TR

WAS APPROACHING A RED LIGHT AT APPROX 30 MILES PER HOUR WHEN THE BRAKE PEDAL SIMPLY "POPPED" AND WENT ALL THE WAY TO FLOOR. I WAS ABLE TO MUSCLE IT TO A STOP BETWEEN THE VERY LITTLE BRAKING LEFT, DOWNSHIFTING AND THE EMERGENCY BRAKE. MECHANIC DETERMINED ALL BRAKE LINES RUSTED AND LEAKING. *TR

MY TOWING HITCH/RECEIVER BROKE WHILE TOWING A TRAILER AND TURNING A CORNER AT 10 MPH, 2 BLOCKS FROM MY HOUSE. THE DRIVERS SIDE OF THE HITCH WAS SO BADLY RUSTED, IT BROKE, THE PASSENGER SIDE WAS STRONG ENOUGH THAT MY TRAILER STAYED BEHIND MY 2 WD TRUCK AND NO ONE WAS INJURED. THIS INCIDENT COULD HAVE HURT SOMEONE HAD I BEEN GOING FASTER IN TRAFFIC WHEN IT BROKE. NOW, AFTER THIS HAPPENED, I LEARNED THAT THE 2002 TRUCKS HAVE HAD THIS ISSUE FOR SOME TIME! *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE ANTILOCK BRAKE SYSTEM ACTIVATED AUTOMATICALLY AND THE ANTILOCK BRAKE SYSTEM WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED, BUT WAS REPAIRED BY THE CONTACT WHO REMOVED THE ANTILOCK BRAKE SYSTEM SENSOR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

LEAVING FROM WORK AT THE GREATER CINCINNATI AIRPORT. DRIVING DOWN THE RAMP TO THE STOP SIGN AT DONALDSON RD. WHILE ATTEMPTING TO BRAKE FOR THE STOP SIGN THE BRAKE PEDAL WENT TO THE FLOOR CAUSING THE TRUCK TO GO THROUGH THE STOP SIGN ACROSS THE EAST BOUND LANES OF DONALDSON ROAD AND FINALLY STOP BEFORE ENTERING A DITCH ON THE NORTH SIDE OF THE ROAD. AT FIRST, I WAS GOING TO HAVE THE CAR TOWED. I FOUND THAT THERE WAS SOME RESIDUAL BRAKING LEFT AND I, SLOWLY, DROVE THE CAR APPROXIMATELY 12 MILES TO MY HOUSE. THE NEXT DAY I TOOK THE CAR TO THE LOCAL SHOP AND UPON INSPECTION WAS TOLD THAT ONE OF THE BRAKE LINES HAD FAILED DUE TO CORROSION. I WAS ALSO TOLD THAT "ALL" BRAKE LINES NEEDED TO BE REPLACED DUE TO CORROSION. TOTAL BILL WAS OVER 1200 DOLLARS. 2002 CHEVROLET SILVERADO EXTENDED CAR/LONG BED 1500. *TR

2002 CHEVY SILVERADO TRUCK WAS SITTING IN DRIVEWAY I WAS READY TO LEAVE PUSHED ON THE BRAKE TO PUT IT IN DRIVE AND THE PEDAL WENT TO THE FLOOR . LOOKED UNDER THE VEHICLE FLUID EVERWHERE. NOT ONE LEAK OR ANY SIGN BEFORE. I KNEW WHAT IT WAS BECAUSE I KNOW AT LEAST 4 OTHER PEOPLE WITH CHEVY TRUCKS AND THIER LINES WENT, 1 HAD AN ACCIDENT RUNNING IN TO THE REAR OF A CAR. I HAVE A NEW LINE SET BUT DIDN'T GET TO IN TIME. IF THAY HADN'T FAILED IN MY DRIVEWAY THE OUTCOME WOULD HAVE BEEN INTIERLY DIDERENT WITH MY SON HIS FRIEND AND MYSELF. ONE WOULD THINK THEY WOULD USE A MATERIAL TO WITHSTAND THE ELEMENTS ON BRAKES!!!!! MY WORK TRUCK TRUCK IS A 2001 SILVERADO SO I CHECKED IT AND THERE GONE ALSO. I WOULD BE WILLING TO BET THAT MOST PEPOLE FIX THE LINES AND DON'T REPORT. TO ME THIS IS A BIG PROBLEM. *TR