2021 CHEVROLET SILVERADO 1500 Complaints

On August 10th 2025 I was driving down the 5 freeway to the airports All of a sudden I notice my check engine light is on. It was Sunday Chevrolet is closed so I got off the exit to go to auto zone in XXX. I stop at a red light my engine shuts off. I tried to turn it back on twice and it starts to smoke where the battery is. I have it towed to Chevrolet Fairfield. Where they figure out my ground wire came loose and shorted out. I paid for that to get fixed upon returning to get my vehicle on August 31, 2025 I drive not even 10 miles down the road and I hear a boom and then really loud clanking. I blew my engine. It was diagnosed with the same problems as other 6.2 gm motors. I have it towed back to Fairfield Chevrolet. It sat in Fairfield for a couple months due to me working out of town for work and the manager from Fairfield Chevrolet started giving me problems harassing me saying that if I didn’t get it off of his lot he was going to start charging me. So I had it towed from Chevrolet Fairfield to my house in [XXX] where it has sat since. I have been going back and forth with Chevy because I know of the recall however my vin is not in that recall yet it is the same problems as all the ones with the recall. I am really wanting to fix my vehicle as it has been almost 9 months. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The rear wheels suddenly locked up while driving. It did it twice then the check engine light came on and then the transmission would not shift into gear until I turned off the truck and turned it back on. This happened 3 days in a row all while driving. Exactly the same. No prior symptoms or warnings before the incidents happened. The vehicle is currently at the dealership being inspected. There is a recall (N242454440) that addresses this issue but I'm being told that my truck is not covered under that recall because my VIN is not part of it.

Random catastrophic engine failure Randomly made a clunk noise and oil pressure dropped to 0. Engine needs replaced

The contact owns a 2021 Chevrolet Silverado 1500. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling), and the vehicle was taken to the dealer, where the contact was informed that the vehicle had passed the recall inspection, and no repair was needed. The contact stated that while driving at 50 MPH, five months later, the engine seized in the middle of the roadway. The contact was unable to pull over to the side of the road. The vehicle was shifted to neutral(N) and pushed over to the side of the road with assistance. The vehicle was impounded by the local Police Department. The vehicle was then towed to an independent mechanic, where it was diagnosed, and it was determined that the engine had seized. The vehicle was not repaired. The contact stated that the recall remedy had failed to correct the issue. The contact related the failure to NHTSA Action Number: RQ26001 (Engine). The dealer and the manufacturer were not contacted. The failure mileage was approximately 125,700.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 20 MPH, the vehicle lunged forward while the accelerator pedal was depressed after the brake pedal was depressed. While the contact’s husband was driving approximately 78 MPH and attempting to accelerate, the transmission light drive(D) started flashing, and the transmission unexpectedly shifted to neutral(N). The driver was able to coast to the side of the road, depress the brake pedal, and wait for a while before continuing to drive. The vehicle was taken to the dealer to be diagnosed; however, there was no cause for the transmission failure found. The vehicle was repaired. The manufacturer was informed of the failure, and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 63,000.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 65 MPH, the message "Service DEF System" was displayed and the check engine warning was illuminated. The message speed would reduce by increments of 10 to 15 MPH until the vehicle could not accelerate 5 MPH after driving 75 miles. The contact stated that a handheld scanner was used to retrieve DTC: P20B9. The contact stated that the failure was a recurring failure. The vehicle was taken to a local dealer where it was diagnosed and determined that the DEF tank heater module needed to be replaced. The contact stated that the dealer was aware of TSB: 21-NA-002 and 22-NA-150; however, the vehicle had a Salvage Title and was not eligible for the repairs. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 53,400.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that on several occasions while driving at various speeds, the tailgate inadvertently opened. The tailgate was closed, but the tailgate reopened unexpectedly within several seconds. The contact stated that while the vehicle was parked, the tailgate opened unexpectedly. After closing the tailgate, the tailgate reopened within several seconds. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was not available.

My vehicle has been at the dealership since February 4 due to a transmission failure involving the valve body, which is currently on national back order along with the converter. These parts are required to complete the repair, and the vehicle is not drivable. This issue occurred after previous major repairs, including engine lifter replacement and a CV axle repair. It has now been 71 days without a repair. The dealer has confirmed the failures, but the manufacturer has not provided a repair timeline or a definitive solution. I have not received consistent updates since March 19, and the vehicle remains out of service with no estimated completion date..

The electronics freeze up and sometimes the stereo turns off and won't come back on. The transmission perks and then revs up then hits gear and kicks real hard. The transmission feels like it's going to vibrate out from under the truck going down the road at certain speeds!

On February 12th, the check engine light came on in my 2021 Chevy Silverado 1500 with the L87 6.2 L engine. The following morning, I took it to the shop and had it checked. It was diagnosed with crank shaft bearing coming apart. I contacted the dealership and they told me that my VIN was not associated with the L87 recall, but that they would see if GM would be willing to help with the costst associated with replacing the engine. They agreed to pay for about 30% of the repair. I pointed out to them that my engine was manufactured in the Tonowanda, NY plant which is the site where many of the recalled engines were manufactured. They still refuse to cover the cost of the new engine. I feel that they should cover my costs since the engine was manufactured in the plant and broke down for the exact reason for the recall. My costs are over $10,000 due to their defective engine. Please add my VIN to the recall.