2002 CHEVROLET SILVERADO 1500 Complaints

ON THE EVENING OF DECEMBER 23, 2013, WHILE TRAVELLING ON A CONNECTICUT STATE ROAD, I APPLIED MY BRAKES, AS A VEHICLE WAS TURNING LEFT AHEAD OF ME. THE BRAKE PEDDLE WENT IMMEDIATELY TO THE FLOOR. I REALIZED A BRAKE LINE HAD RUPTURED. I WAS ABOUT A MILE FROM THE AUTOMOTIVE REPAIR FACILITY THAT I UTILIZE. I WAS ABLE TO NURSE THE VEHICLE THERE, WHERE IT WAS SUBSEQUENTLY REPAIRED (BRAKE LINE REPLACED). IN THE PAST, I WOULD HAVE TAKEN THE VEHICLE TO THE LOCAL DEALERSHIP WHERE IT WAS PURCHASED, BUT THAT DEALERSHIP WAS ONE OF MANY CLOSED DOWN BY GM. THE NEAREST DEALERSHIP, IN ANY DIRECTION IS ABOUT 20 MILES. FORTUNATELY I HAVE FOUND AN OUTSTANDING LOCAL INDEPENDENT AUTOMOTIVE REPAIR FACILITY. *TR

FOR SEVERAL YEARS, HAVE BEEN OUT TIME & EXPENSE OF INSTALLING NEW PARK BRAKE PADS NOT NEEDED, TURNING DRUMS, TRIED REPLACING LONG BRAKE CABLE UNDER FLOOR, PULLED REAR ROTORS SEVERAL TIMES & RE ADJUSTED PARK BRAKE... 1 WEEK LATER DON'T WORK AGAIN.. I HAVE TO PUT BLOCKS UNDER WHEELS FOR 3 YEARS TO KEEP TRUCK FROM ROLLING DOWN DRIVEWAY.. LIVE ON A HILL..CHEVY DON'T NEED THE TENSION ON LITTLE BITTY PARK GEAR IN TRANSMISSION....ALSO HAVE HAD TO FIX EVERY DEC BECAUSE SAFETY INSPECTION ENDS DEC,,,NEIGHBORS HAVE FORD & DODGE & THEIRS WILL STAY IN DRIVEWAY..HAVE NO IDEA HOW MUCH MONEY & TIME SPENT ON A GM BLUNDER... WHY HAS THEIR NOT BEEN A RECALL ? ANOTHER COVER UP BY GM EXECUTIVES ? *TR

AFTER EXITING THE OFF RAMP OF I264 IN PORTSMOUTH, VIRGINIA I SPED UP TO APPROXIMATELY 35 MPH AND APPROACHED THE NEXT STOP LIGHT. UPON APPLYING PRESSURE TO THE BRAKE PEDAL NO RESISTANCE WAS NOTED AND THE SLOWING OF THE VEHICLE WAS FOUND NEGLIGIBLE. I REAR ENDED A VEHICLE IN FRONT OF ME AT APPROXIMATELY 25 MPH. BOTH CARS INVOLVED IN THE ACCIDENT WERE PULLED INTO THE MEDIAN OUT OF TRAFFIC. AS I EXITED THE VEHICLE I NOTICED FLUID DRIPPING FROM THE TRUCK FRAME AT THE FORWARD HINGE OF THE DRIVER SIDE DOOR. THE DRIPPING FLUID WAS BRAKE FLUID. I SUSPECT A RUPTURED BRAKE FLUID LINE OR TUBE HAD RUPTURED WHICH CAUSED THE LOSS OF BRAKING POWER. THERE WAS NO WARNING GIVEN BY THE VEHICLE'S COMPUTER TO WARN OF LOW BRAKE FLUID BECAUSE THE RESERVOIR WAS STILL AT THE NORMAL LEVEL. I BELIEVE CORROSION OF THE BRAKE LINES WAS ACCELERATED DUE TO THE USE OF SALT TREATMENTS ON THE ROADS DURING THE WINTER SNOW STORMS THAT HAVE FALLEN IN THE PAST THREE YEARS. LUCKILY NOBODY WAS SERIOUSLY HURT AND LUCKILY THIS DID NOT HAPPEN WHEN I WAS EXITING THE INTERSTATE AT A MUCH HIGHER RATE OF SPEED. ALSO THE AIR BAG DID NOT DEPLOY UPON IMPACT. THESE ARE TWO SERIOUS SAFETY ISSUES INCURRED IN ONCE INCIDENT TO A TRUCK WHICH HAS LESS THAN 70K MILES AND 12 YEARS OLD. *TR

BRAKE PROBLEM WITH ABS. VEHICLE DID NOT STOP CORRECTLY ALMOST CAUSING ACCIDENT. AFTER RESEARCHING FOUND RECALL FOR ABS WHEEL ISSUE FOR OTHER STATES BUT NOT TEXAS. VEHICLE WAS MANUFACTURED IN CANADA. *TR

I HAVE OWNED THIS TRUCK FROM NEW. IT IS USED FOR LIMITED HAULING DUTIES AROUND TOWN AND HAS VERY LOW MILEAGE. LAST SUMMER I TOOK IT TO THE CHEVROLET DEALER FOR PA STATE INSPECTION. THE MECHANIC DROVE THE CAR INTO THE SERVICE BAY AND UPON DOING SO, THE BRAKE FLUID DUMPED OUT SUDDENLY FROM BENEATH THE TRUCK CHASSIS. THIS WAS 10 MIN AFTER I DROVE THE TRUCK TO THE DEALERS USING A LOCAL EXPRESSWAY. THE TRUCK WAS THEN PUT UP ON THE LIFT AND I WAS SHOWN THE FACT THAT THE BRAKE LINES WERE SEVERELY CORRODED TO THE POINT THAT THE BRAKE FLUID WAS DUMPED ONTO THE FLOOR. I PAID $2332 FOR BRAKE REPAIRS. AS A GRADUATE MATERIALS ENGINEER I INQUIRED AS TO THE MATERIAL USED FOR THE BRAKE LINES AND WAS TOLD THEY WERE CARBON STEEL. IT OFFENDS ME GREATLY THAT THIS TRUCK HAD THIS SEVERE FAILURE WITH LESS THAN 10K MILES, AND THAT GM APPARENTLY HAS BEEN AWARE OF THE PROBLEM AND HIDDEN IT FOR MANY YEARS. THEIR FOCUS ON SAVING A BUCK COULD HAVE COST LIVES AS A RESULT. THE DEALER WAS NOT HELPFUL IN MAKING ME AWARE OF ANY MITIGATION PROGRAM BY GM. AND I AM STUCK WITH A LARGE BILL FOR THEIR NEGLIGENCE. I AM APPALLED AND AN UNHAPPY CUSTOMER!!!

AS I APPROACHED A STOP SIGN AFTER TRAVELING ABOUT 30 MPH AND SLOWING DOWN FOR THE STOP SIGN I PRESS THE BRAKES AND IT WENT TO THE FLOOR AND PRESS THEM A SECOND TIME AND POSSIBLE A THIRD BEFORE CROSSING TRAFFIC AND FAILING TO STOP. I MISS HITTING A CAR BY INCHES. THIS WAS ALL ON AN UPHILL INCLINE. I CROSS TRAFFIC AND WAS ABLE TO STOP IN A CHURCH PARKING LOT BY USING THE PARKING BRAKE. AFTER ABOUT THE FIFTH TIME APPLYING THE BRAKES THE BRAKE WARNING LIGHT COME ON. NO WARNING UNTIL THEN. AFTER INSPECTION THE BRAKE LINE NEXT TO THE DRIVERS SIDE HAD RUPTURE. THE LINE LET A TRAIL OF BRAKE FLUID FOR ABOUT 200 YARDS. THE BRAKE FLUID WAS CHECKED AT OIL CHANGE SERVICE FOUR DAYS PRIOR AND WAS FULL. NOW IT IS EMPTY. THIS IS A MAJOR FAILURE THAT SHOULD BE CORRECTED BEFORE SOMEONE IS KILLED. I THOUGH THAT THERE WAS A SECONDARY SYSTEM TO STOP IF ONE HALF OF THE SYSTEM FAILED. APPARENTLY NOT!!!!! *TR

STARTED TO LEAVE HOUSE TO GO GROCERY SHOPPING, STARTED VEHICLE APPLIED BRAKE TO OUT AUTO INTO GEAR, BRAKES PEDAL WENT TO THE FLOOR, CHECK FLUID LEVEL WAS O.K. RECHECK BRAKING, SAME RESULT, NO BRAKES. AFTER CHECKING NOTICE SIGNS OF BRAKE FLUID AT AREAS BENEATH VEHICLE AT DRIVER DOOR. CALLED FOR TOW TRUCK THE FOLLOWING MORNING. IF I HAD GOTTEN TO HYWY. US 1. AND THIS PROBLEM HAPPEN, I FEAR THERE WOULD HAVE BEEN A TERRIBLE ACCIDENT INVOLVING MYSELF, OR OTHERS. WAITING FOR WORD FROM AUTO SHOP OF WHAT THE PROBLEM COULD BE. THIS IS VERY SERIOUS SAFETY ISSUE WITH THIS AND OTHER TRUCKS. *JS

WHEN I STARTED THE ENGINE THE GAS GAUGE WENT TO FULL THEN BACK TO 0. LATER WHEN I WENT TO USE THE TOW/HAUL IT WOULD NOT WORK, IT WASN'T LONG BEFORE THE ODOMETER AND SHIFT INDICATOR STOPPED WORKING. *TR

COMING TO A STOP LIGHT AND LOST ALL BRAKES. FURTHER INSPECTION REVEALED THAT REAR BRAKE LINES ARE RUSTED THROUGH. ALL OTHER LINES ARE SEVERELY RUSTED. INCLUDING FUEL LINES. *TT

BRAKE LINE BUSTED WHILE BLEEDING AIR OUT OF SYSTEM. FOUND ALL LINES GOING TO ABS BLOCK IN CENTER OF TRUCK WERE RUSTED COMPLETELY THROUGH. THIS WAS NOT THE FIRST TIME THIS HAPPENED. HAD SAME PROBLEM ABOUT YEAR BEFORE ON FRONT BRAKE LINE. I ALMOST HIT ANOTHER VEHICLE IN REAR. I HAD TO HAVE TRUCK TOWED TO LOCAL REPAIR SHOP WERE THEY FIXED BROKE LINE. *TR