2002 CHEVROLET SILVERADO 1500 Complaints

BRAKE LINES BLEW OUT FROM CORROSION. THIS HAS HAPPENED 3 TIMES SINCE APRIL 2013. I WAS UNABLE TO STOP ON TWO SEPARATE RED LIGHT OCCASIONS. ALSO HAVING ABS PROBLEMS. THE ABS SYSTEM BREAKS LOOSE JUST ABOUT WHEN THE VEHICLE COMES TO A COMPLETE STOP FORCING ME TO LET GO AND REAPPLY BRAKE QUICKLY. MY TRUCK IS UNDERCOATED ALSO MAKING THIS DEADLY PROBLEM MORE CONCERNING. NHTSA SHOULD DO ITS JOB AND STOP THESE DEATH TRAPS. *TR

STARTED TRUCK TO HOOK UP TO A TRAILER AT HOME. BACKING UP, AND DEPRESSED BRAKES WHILE BACKING, SUDDENLY LOST ALL BRAKE CONTROL. I HAD NO CONTROL TO STOP VEHICLE. VEHICLE ROLLED TO A STOP WHILE I PRESSED AND PUMPED BRAKES WITH NO AFFECT. *TR ROLLED TO STOP. I THEN PLACED VEHICLE IN PARK AND EXITED TO FIND BRAKE FLUID ON GROUND. I THEN TRIED TO SLOWLY MOVE VEHICLE INTO GARAGE SO AS TO RAISE JACK UP- FOR A FURTHER EXAMINATION, BUT I HAD ZERO CONTROL OVER BRAKING. IN ORDER TO GET VEHICLE ONTO CONCRETE SURFACE/GARAGE I HAD TO SHIFT BACK AND FORTH BETWEEN NEUTRAL AND DRIVE UNTIL I LIMP THE TRUCK INTO GARAGE BUT DO SO WITHOUT RAMMING THROUGH THE BACK WALL AS I HAD NO CONTROL OVER BRAKES. ONCE IN, I JACKED UP TRUCK AND I FOUND ONE LEAK IN ONE RUSTED METAL BRAKE LINE AT A BEND CLOSEST TO LEFT REAR WHEEL. SUDDEN AND TOTAL AND COMPLETE LOSS OF BRAKES. *TR

WITHOUT WARNING TOTAL BRAKE FAILURE. LUCKILY MORE ROAD TO GO DOWN. BRAKE LINE RUSTED THROUGH. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO1500 HD. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ABS ENGAGED INDEPENDENTLY AND PREVENTED THE CONTACT FROM STOPPING THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFUSED TO PROVIDE ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000 AND THE CURRENT MILEAGE WAS 145,000. UPDATED 08/19/14*LJ

STEPPED ON BRAKE PEDDLE AT IDLE AND PEDAL WENT TO THE FLOOR. UPON TAKING IT TO THE REPAIR SHOP, FOUND THAT THE BRAKE LINES WERE COMPLETELY RUSTED OUT AND THE CALIPER BLEEDERS WERE RUSTED OFF. ALL LINES, CALIPERS, AND TWO ROTORS HAD TO BE REPLACED - COST $2,091. *TR

STEPPED ON BRAKES TO STOP WHEN BLOWING SNOW REDUCED MY VISIBILITY, AND THE BRAKE PEDAL WENT TO THE FLOOR. THE BRAKE LINES WERE SEVERELY CORRODED AND ONE OF THEM SUDDENLY FAILED. TURNS OUT THAT IT'S AN EPIDEMIC WITH THESE GM TRUCKS. *TR

GM BULLETIN # 06-06-01-019B INDICATES A FAULTY CASTECH HEAD. NO RECALLS, COST TO REPAIR IS OVER $1,000.00 THIS IS A KNOWN FAULTY PART THAT GM WILL NOT HONOR REPLACEMENT. *TR

AT APPROXIMATELY 50 MPH COOLANT LOSS FROM A CRACKED CYLINDER HEAD SENT A SIGNAL TO THE ECM TO SHUT DOWN THE ENGINE WHICH CAUSED THE LOSS OF POWER STEERING AND CONTROL. WEATHER CONDITIONS WERE SNOW AND WIND AND I WAS FOLLOWING TWO DRY TRACKS IN THE ROAD, UPON LOSS OF POWER THE TRUCK DRIFTED ONTO AN AREA OF ROAD COVERED IN SNOW WHICH NEARLY CARRIED ME OFF INTO A DITCH. ON A DRY DAY IF THIS HAD OCCURRED INERTIA WOULD HAVE TAKEN ME ON TO A SOFT SHOULDER SO IN THIS INSTANCE THE COLD WEATHER AND SNOW ACTUALLY HELPED THE TRUCK FROM DRIFTING TOO FAR OFF THE ROAD. ONCE DISABLED ALONG SIDE THE ROAD THE WEATHER BEGAN TO DETERIORATE TO NEAR WHITE OUT CONDITIONS, THANKFULLY ANOTHER DRIVER PULLED UP BEHIND ME ABOUT 50 YARDS BACK AND USED HIS FLASHERS TO WARN ON COMING DRIVERS. AFTER THE TRUCK COOLED A BIT IT RE-STARTED AND I TOOK FOR SERVICE. A MECHANIC NOTICED A CRACKED CYLINDER HEAD AS THE CULPRIT. I HAVE COME TO LEARN THIS IS A COMMON PROBLEM WITH THESE VEHICLES. MY WIFE WILL OCCASIONALLY DRIVE THIS TRUCK AND IT COULD HAVE BEEN A DIFFERENT SITUATION IF SHE COULD NOT HAVE MUSCLED THE UNASSISTED STEERING TO THE SIDE OF THE ROAD. IT IS MY BELIEF THAT ANY CONDITION THAT WILL SHUT DOWN AN ENGINE UNDER FULL POWER SHOULD BE THE RESPONSIBILITY OF THE MANUFACTURER TO FIX. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THE ENGINE MODEL 4.8 IS DEFECTIVE AND AS A RESULT WILL CONSTANTLY LOSE COOLANT DUE TO THE CRACKED MOTOR HEAD. THE CONTACT TOOK THE VEHICLE TO A INDEPENDENT MECHANIC WHERE THEY REPAIRED THE HEAD GASKET OF THE VEHICLE. THE MANUFACTURE WAS MADE AWARE OF THE FAILURE BUT UNWILLING TO REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. THE VEHICLE WAS NOT REPAIRED.

STATE INSPECTION MY TRUCK FAILED DUE TO GASOLINE RUSTED AND LEAKING GAS,REAR SHACKLES RUSTED THRU, PARKING BREAK WON'T HOLD CORROSION. I HAVE NEVER HAD SO MANY RUSTED OUT PARTS ON MY TRUCK BEFORE, THE GAS LINE SHOULD NOT RUST THRU THIS IS A SAFETY ISSUE. SHACKLES RUSTED THRU WHAT GIVES MY OLD 88 NEVER HAD ANY OF THESE PROBLEM PLEASE DO A RECALL. *TR