2005 CHEVROLET SILVERADO 1500 Complaints

TL* THE CONTACT OWNS A 2005 CHEVROLET SILVERADO 1500 HD. THE CONTACT STATED THAT WHILE MERGING ONTO THE HIGHWAY AT 10 MPH, THE VEHICLE LOST POWER WITHOUT WARNING. THE CONTACT MANAGED TO PUSH THE VEHICLE TO THE SHOULDER AND THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE HYBRID COMPONENTS FAILED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES BUT NO SUCCESSFUL REMEDY WAS DISCOVERED. IN ADDITION, THE VEHICLE WOULD SEIZE WHEN IN REVERSE AND THE CHECK POWER FLUID AND THE POWER STEERING WARNING LIGHTS WERE ILLUMINATED. THE CONTACT WAS ALSO EXPERIENCING THE FUEL GAUGE INDICATOR PROVIDING INACCURATE READINGS AND THE AIR CONDITIONER WAS ALSO FUNCTIONING ERRATICALLY. THE MANUFACTURER WAS NOTIFIED OF THE ISSUES BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 64,000 AND THE CURRENT MILEAGE WAS 65,000. ..UPDATED 01/16/2013 *BF THE CONSUMER STATED THE VEHICLE HAS BEEN AT THE DEALERSHIP FOR 10 MONTHS, WHERE THEY ARE UNABLE TO REPAIR IT. UPDATED 1/28/2013 *JS

I WAS DRIVING WHEN THE BRAKE PEDAL WENT SOFT. I CONTINUED AND THE SERVICE BRAKES WARNING LIGHT CAME ON. AS I WAS LESS THAN 1 MILE FROM HOME I CONTINUED CAREFULLY. WHEN I GOT HOME I FOUND THE BRAKE RESERVOIR ALMOST EMPTY. I DISCOVERED THE BRAKE HARD LINE TO THE REAR BRAKES WAS CORRODED. THIS IS THE LINE THAT RUNS ABOVE THE GAS TANK. IT WAS CORRODED THERE AND LEAKING FLUID. LUCKY I WASN'T KILLED OR STRANDED FAR FROM HOME ! *JS

THERE IS A BAD SEAL WHERE THE RIGHT FRONT AXLE CONNECTS TO THE SHAFT FROM THE TRANSFER CASE. THIS IS A COMMON PART THAT HAPPENS TO LARGE NUMBER OF VEHICLES.

DRIVING DOWN THE ROAD AND THE CAB FILLED UP WITH SMOKE. IT SMELLED LIKE BURNING RUBBER. I HAD TO EVACUATE MY YOUNGEST SON AND FOUND THAT THE WIRES ON THE BLOWER/RESISTOR WHERE ON FIRE. THERE SEEMS TO BE A KNOWN ISSUE WITH THIS AND I AM SURPRISED THAT NOBODY HAD BEEN KILLED SO FAR. LOOKS LIKE THE RECALL WAS DONE IN CANADA? HTTP://WWW.ARFC.ORG/COMPLAINTS/2005/CHEVROLET/SILVERADO/ELECTRICAL_SYSTEM/PROBLEM.ASPX. *TR

THE FRONT END INTERMITTENTLY BEGINS TO "SHIMMY" AT ABOUT 50MPH. I HAVE REPLACED TIRES, INNER AND OUTER TIE RODS, AND BRAKES CALIPERS BUT THE PROBLEMS HAVE NOT RESOLVED. THE VEHICLE HAS ALWAYS HAD PROBLEMS WITH A "CLUNKING" FROM THE STEERING COLUMN. SEVERAL OWNERS REPORT THE SAME PROBLEM. *TR

WHILE BRAKING ON ALL PAVEMENT CONDITIONS, AS VEHICLE SLOWS, BRAKES GO INTO ABS MODE AND VEHICLE SURGES FORWARD, REQUIRING ADDITIONAL PEDAL FORCE TO STOP. OCCURS AT 5 MPH OR LESS EVEN ON DRY PAVEMENT. OCCURS WITH ALL PEDAL PRESSURES. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF IN TO THE HEAD THIS IS CAUSING EXHAUST LEAKS IN THE ENGINE COMPARTMENT, NOISE, CARBON MONOXIDE IN THE ENGINE AND CAB AREAS, ADDED HEAT IN THE ENGINE COMPARTMENT, AND WILL NOT MEET THE EMISSION STANDARDS OF SOME STATES. VERY EXPENSIVE TO REPAIR AND GM IS NOT STANDING BEHIND THIS ISSUE IN THE TRUCK WITH V-8 ENGINES YEARS 1999-2008. ALMOST ALL HAVE THIS ISSUE. SAFETY HAZARD. PLEASE LOOK AT THIS. ALSO, CAUSING PROBLEMS WITH THE CATALYTIC CONVERTER AND O2 SENSOR. MAKE THEM STEP UP TO THE PLATE. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS THIS IS VERY COMMON PROBLEM. HEATING UP ENGINE COMPARTMENT, RELEASES CARBON MONOXIDE,MESSES UP THE O2 SENSOR AND CATALYTIC CONVERTER. CANNOT PASS EMISSION STANDARDS IF NEED BE.THIS IS IN GM TRUCKS 1999-2008. PLEASE CHECK THIS OUT FOR SAFETY PURPOSES. VERY EXPENSIVE TO REPAIR AND GM IS NOT STANDING BEHIND THE ISSUE. TOO MANY TRUCKS THIS WAY TO BE CO-INCIDENTAL. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS THIS IS CAUSING AN EXHAUST LEAK, NOISE, CARBON MONOXIDE, ADDED HEAT IN THE ENGINE COMPARTMENT, AND WILL NOT MEET EMISSION STANDARDS. VERY EXPENSIVE TO REPAIR. GM NOT STANDING BEHIND THIS ISSUE TRUCKS 1999-2008 MODELS ALL HAVE THIS ISSUE. SAFETY HAZARD. PLEASE LOOK AT THIS. THIS IS UNACCEPTABLE. ALSO, CAUSING PROBLEMS WITH THE CATALYTIC CONVERTER AND O2 SENSOR. *TR

EXHAUST MANIFOLD BOLTS BREAKING OFF LEAVING STUDS IN THE HEADS THIS IS VERY COMMON PROBLEM. GM NOT STANDING BEHIND IT. HEATS UP THE ENGINE COMPARTMENT AND RELEASES CARBON MONOXIDE INTO THE DRIVER. POTENTIALLY A SAFETY HAZARD. IT ALSO AFFECTS THE O2 SENSOR AND THE CATALYTIC CONVERTER. SOME STATES YOU CANNOT PASS EMISSIONS BECAUSE OF THIS TRAGEDY. PLEASE CHECK ALL VEHICLES FROM 1999-2008 FOR THIS SAFETY ISSUE. *TR