2002 CHEVROLET SILVERADO 1500 Complaints

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 8 MPH, SHE APPLIED THE BRAKES BUT THE VEHICLE DID NOT STOP UNTIL CRASHING IN HER FRONT YARD. THE CRASH WAS MINOR AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT SOME OF THE BRAKING SENSORS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 78,300. THE VIN WAS NOT AVAILABLE.

BRAKE LINES AND FUEL LINES MUST BE REPLACED DUE TO EXCESSIVE RUSTING. BLEW A BRAKE LINE AND HAD NO BRAKES AT ALL. ADDITIONALLY, THE FRAME HAS RUSTED THROUGH AND HAD TO BE WELDED. LOOKING AT REPAIR COSTS BETWEEN $1500 - $3000 DEPENDING UPON HOW THIS GOES. *TR

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V379000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK). THE CONTACT STATED THE ANTI LOCK BRAKING SYSTEM WOULD ENGAGE WHILE BRAKING AT LOW SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP, WHERE THE CONTACT WAS ADVISED TO DISCONNECT THE ANTI LOCK BRAKING MODULE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 78,000. THE VIN WAS UNAVAILABLE.

AFTER SECURING 10 PALLETS IN THE BED OF THE TRUCK AND BEGINNING THE DRIVE HOME FROM THE LOCAL LUMBER YARD, I DEPRESSED THE BREAKS TO STOP AT THE FIRST LIGHT. THE BRAKE PEDAL WENT TO THE FLOOR, SO I DOWNSHIFTED AND BEGAN TO DEPRESS THE EMERGENCY BRAKE TO STOP. AT THIS POINT I HAD MY WIFE PICK UP THE CHILDREN SO THEY WOULD NOT BE IN THE VEHICLE WITH ME. I PROCEEDED HOME (LESS THAT 1.5 MILES) AT A REDUCED SPEED OF APPROXIMATELY 10 MILES AN HOUR. DEPRESSING THE BRAKE PROVIDED MARGINAL STOPPING CAPABILITY. IT WAS SUFFICIENT STOPPING POWER FOR A VEHICLE TRAVELING ABOUT 10 MILES PER HOUR AT 100 FEET. UNDER THE VEHICLE AFTER THE ANTILOCK BRAKING BOX, THE ONE LINE WAS SPRAYING BRAKE FLUID WHEN THE PEDAL WAS DEPRESSED. THE RUST WAS SO SEVERE, WHEN GOING TO CUT THE LINE, THE LINE ACTUALLY CRUSHED INWARDS WITH NO APPARENT GOOD METAL. IN SPLICING THE LINE I WAS UNABLE TO FIND THE PROPER CLEARANCE TO RECONNECT THE LINE TO THE ANTILOCK BRAKING BOX, SO MY MECHANIC WILL BE WORKING THIS SHORTLY. THE OTHER LINES LOOK EQUALLY BAD SO I WILL HAVE THOSE REPLACED AS WELL. I HAVE NEVER SEEN RUST THIS BAD ON MY VEHICLES EVEN OLDER THAN THIS ONE. PICTURES AND OR PIECES OF THE BRAKE LINE CAN BE SUPPLIED UPON REQUEST. *TR

NHTSA INVESTIGATION NUMBER: EA11001 - BRAKE LINE FAILURE, STEEL BRAKE LINE UNDER LEFT SIDE OF CAB RUPTURED DUE TO RUST AND BRAKE FLUID LEAKED OUT OF BRAKE SYSTEM. UPON FURTHER INSPECTION, FOUND ALL 4 STEEL BRAKE LINES ARE RUSTED VERY BADLY UNDER LEFT SIDE OF CAB, ADDITIONAL BRAKE LINE RUST FOUND ON ALL STEEL BRAKE LINES, UNDER HOOD IN ENGINE COMPARTMENT, ALONG FRAME, UNDER CAB, AND UNDER TRUCK BED. ONE OF THESE STEEL BRAKE LINES RUPTURED RESULTING IN COMPLETE BRAKE SYSTEM FAILURE DUE TO LOSS OF BRAKE FLUID WHILE DRIVING! VERY DANGEROUS. DEALERSHIP REPAIRED ONE FAILED STEEL BRAKE LINE, BUT WOULD NOT REPLACE ALL RUSTED BRAKE LINES. THIS FAILURE OCCURRED WHILE TRAVELING 45 MPH AND APPROACHING A RED LIGHT AT BUSY INTERSECTION. BRAKE PEDDLE WENT TO FLOOR, NO BRAKES, DOWN SHIFT AUTOMATIC TRANSMISSION TO 2ND GEAR AND USED EMERGENCY BRAKE. I HAD TO SWERVE AND CHANGED LANES THREE TIMES TO AVOID ACCIDENT. THERE WAS NO WARNING TO THIS FAILURE. ALSO VEHICLE IS METICULOUSLY MAINTAINED. PLEASE HELP. *TR

I OWN A 2002 CHEVROLET SILVERADO. THE METAL BRAKE LINE WHICH RUNS ALONG THE FRAME, AT THE POINT WHERE IT CONNECTS TO A FLEXIBLE HOSE THAT SERVICES THE REAR BRAKES HAS RUSTED THROUGH AND AS A CONSEQUENCE ALL OF THE BRAKE FLUID HAS LEAKED OUT OF THE MASTER CYLINDER RESERVOIR. *TT

HAS OCCURRED ON MULTIPLE OCCASIONS. WHILE DRIVING- DEPRESSED BRAKE PEDAL, WHICH WENT TO FLOORBOARD AND INSUFFICIENTLY PROVIDED BRAKING TO STOP VEHICLE. NO WARNING PROVIDED. WAS ABLE TO PULL TO SIDE OF ROAD BEFORE STRIKING VEHICLE IN FRONT OF ME. MECHANIC INDICATED IT IS CORRODED BREAK LINES. HAD EXPERIENCED SIMILAR PROBLEM(POOR BRAKING APPROX. 4000 MILES AGO DUE TO CORRODED SENSOR. HAVE NOT YET REPAIRED VEHICLE. UNUSABLE. *TT

TL* THE CONTACT OWNS A 2002 CHEVROLET 1500. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, HE ATTEMPTED TO ENGAGE THE BRAKES, BUT THE PEDAL DEPRESSED ALL THE WAY TO THE FLOOR. THE CONTACT INSPECTED THE VEHICLE AND REALIZED THAT THE BRAKE LINES UNDERNEATH THE DRIVERS SIDE DOOR BROKE AS A RESULT OF CORROSION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 62,000....UPDATED 12/03/12 *BF THE DEALER REPLACED THE BRAKE LINES AND ONE CALIPER. UPDATED 01/05/12

TL* THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 1500. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH APPROACHING A TRAFFIC STOP SIGN, PRESSURE WAS APPLIED TO THE BRAKE PEDAL, SUDDENLY THE ANTI-LOCK BRAKE SYSTEM ENGAGED AND THE VEHICLE ROLLED FORWARD. IN 2005, THE VEHICLE WAS REPAIRED UNDER A MANUFACTURER VOLUNTARY RECALL PERTAINING TO THE ANTI-LOCK BRAKE SYSTEM. THE IDENTICAL FAILURE RECURRED IN JANUARY OF 2011 AND WAS REPAIRED BY THE DEALER. MOST RECENTLY, THE BRAKES COMPLETELY FAILED TO RESPOND UPON ENGAGING AND THE VEHICLE WAS TOWED TO THE DEALER. THE CONTACT WAS WAITING UPON A RESPONSE FROM THE DEALER IN REGARDS TO THE CAUSE OF FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

I WAS DRIVING HOME AND AS I PULLED INTO THE DRIVEWAY, THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR AS I BRAKED. I LOOKED UNDER THE TRUCK AND IT WAS LEAKING BRAKE FLUID AROUND THE DRIVER SIDE FRAME RAIL OVER THE GAS TANK. THE BRAKE LINE SEEMS TO HAVE RUSTED THROUGH AND BURST UNDER LIGHT BRAKING PRESSURE.