2021 CHEVROLET SILVERADO 1500 Complaints

May 3, 2025 while driving home truck starting making noise and all the dash lights started blinking including the 'check engine' light. Felt not safe to drive, afraid I would lose control of truck. Immediately pulled over and called dealership who advised to have truck towed in. Truck is still in shop and apparently needs a new engine, problem seems to be the same as the recalls for engines made in 2021-2024. The engine on my truck was manufactured in 2020 and not part of the current recall. This is the 2ND time engine has failed. June 7, 2021 at 4,600 miles again driving and engine started making noise, all dash lights flashing. Again didn't feel truck was safe to drive. Towed to dealership. Cause was a 'failure of lifters on cylinder 5 and a bent push rod.

Engine started making clicking noise when accelerating. Followed by a large screeching noise. Dash read "shift to neutral and start again" pulled to stop and tried to start. Does not crank at all.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving approximately 65-70 MPH, the vehicle stalled. The contact stated that several unknown warning lights were illuminated. The message “Reduced Power” was displayed. The vehicle was taken to a local dealer where it was diagnosed and determined that the lifters and push rods needed to be replaced. The vehicle was repaired but the failure recurred. The contact stated that the vehicle started to smoke while driving. The vehicle was taken back to the local dealer but was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 7,000.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, several unknown messages were displayed before the vehicle shifted to SAFE Mode. Additionally, the contact disconnected and reconnected the battery and restarted the vehicle. The vehicle was taken to a local dealer, where it was diagnosed with a particulate filter failure. The vehicle was repaired; however, the check engine warning light illuminated. The vehicle was taken to another local dealer, Prince Chevrolet Service (4550 N Valdosta Rd, Valdosta, GA 31602); where it was diagnosed, and the contact was informed that the exhaust pressure sensor pipe and exhaust gas recirculation cooler needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was later taken to another local dealer, Nash Chevrolet (630 Scenic Hwy S, Lawrenceville, GA 30046) for a third opinion and was diagnosed with a clogged catalytic converter. The contact was informed that the NOS sensor, EGR Cooler, and DEF fluid injector needed to be replaced. The vehicle was repaired; however, the check engine warning light was illuminated. In addition, the message "LIMP Mode" was displayed on the instrument panel. The manufacturer was made aware of the failure. The failure mileage was approximately 395.

At 2000 miles my truck developed a new “fluttering”, “ticking sound” once all cylinders reactivated as apart of the dynamic fuel management system. After bringing the truck to dealership, they proceeded to replace the lifters, the exhaust system twice, and performed a computer reflash. The truck was at the dealership for over 45 days within the first 6 months of ownership. After all the repairs, the sound is still audible and getting worse. In addition to this sound, at around 30,000 miles the transmission has now developed an audible clunking sound that can be felt once on release the gas peddle under slower operating speeds. After trying to engage with GM on simply understanding what the problem is and why there is the need for so much repair on a brand new vehicle, I am candidly fed up and let down as long term GM customer.

Pulling out to an intersection my 2021 chevy Trailboss stopped going forward. All I had was reverse. Fortunately cars stopped and no one was injured. The truck was towed to a chevy dealership and was inspected and said that the transmission went out on it. The service manager told me that the "transmissions that were put in these trucks were not good" No warning lights ever came on prior to this incident. There was a recall for transmission problems for other chevy models however I have been told that my truck does not qualify for the recall.

At 38,000 miles: While driving, the engine began knocking, vibrating and shut off. The check engine light came on and the vehicle could not be restarted. It was towed to the dealer who diagnosed it with lifter failure. It was still under the powertrain warranty at this time. Several lifters were replaced as well as other engine parts and I was given the truck back after a few weeks. A week later, truck would not start. After looking under the hood I noticed most of the hoses and wires were not clipped off, causing them to just rattle and move around. Upon further investigation, I found that the wire to the starter was loose and had to be wiggled to get the truck to start. This wire should have been secured to the vehicle with the provided clips, but it was not and came loose because of it. I also found a random loose bolt lying in a void space under the hood near the windshield. I took the truck back to the dealership that replaced the lifters and explained my frustration with the condition my truck was put back together after tearing into the engine. I also showed them the random bolt I found. Their manager assured me that they would go through the engine compartment and make sure that the wires and cables were properly secured to the side like it should have been after the initial engine work. I never received an explanation of where the random bolt came from. After this engine work, my truck never seemed to drive the same. It began use more oil and the fuel MPG decreased. I reported to the dealer on the oil consumption and they had me start an oil consumption test. 600 miles after the oil change my engine light came on, truck began to run rough and make a loud engine rattle noise. I took it back to the dealer for a diagnosis. They called back and said that there was a lot of metal in my oil when they drained it. They contacted GM and are scheduled to open the engine up to find out if it can be fixed or needs a new engine. Currently at 52000 miles

The truck, while driving at highway speeds on the interstate, experienced catastrophic engine failure, seizing the motor while in driving. Luckily, I was able to pull the truck to the side of the road safely, without a crash occurring. Losing engine/braking power could have been a major concern but thankfully, traffic was light enough I had space to pull to the side of the road. The truck had to be towed to the nearest dealer, where it was discovered the motor had seized. 2021 Chevrolet Silverado Trail Boss 6.2L motor with 47k miles on the factory warranty/no modifications. Since taking the truck to the dealer, they warranty-swapped a remanufactured crate motor in the truck. Hearing of the major increase in issues with this truck, I traded it in on a different manufacturer and now have a different vehicle. Aside from this huge inconvenience and safety issue, GM's customer support line failed to cover the full cost for a rental truck while my vehicle was down for a new motor (late November 2024 until mid January 2025) and I still have yet to receive a refund for my tow bill. This experience that has now lasted almost 6 months (still with no resolution) has been horrible. I hope General Motors is held liable for this major issue.

I have a 2021 Chevrolet Silverado 1500 with a 6.2 L engine. There seems to be a recall on this model and particular motor but my VIN does not show up. My engine has failed as described in the recall. I have a bearing failure on the crank according to my mechanics shop. Please add my VIN to the recall so I can get this problem repaired. I have been without my vehicle now for over a month and would appreciate assistance on this problem.

Engine knocking brought to dealership and they found codes P0300 and P0304 #4 cylinder with 15,000 then remove head and so order new engine from General Motors