2002 CHEVROLET SILVERADO 1500 Complaints

FAULTY AND INFERIOR DESIGN ON POWER WINDOWS MECHANISM. CABLE BROKE ON DRIVERS WINDOW IN OCT. 2004, CABLE BROKE ON PASSENGER SIDE MAY 6,2004. BOTH TIMES THE WINDOW REMAINED IN THE OPEN POSITION. COST OF $600.00 TO REPAIR. GM WOULD NOT COVER COST BECAUSE OF MILEAGE. *NM

I PURCHASED A 2002 Z71 CHEVROLET CREWCAB 4 W/D PICKUP TRUCK FROM HENDRICK CHEVROLET IN SEPTEMBER OF 2004, AND HAVE HAD MY TRANSMISSION (1ST, 3RD AND REVERSE) GO OUT TWICE IN LESS THAN A YEAR. I CONTACTED GM, BUT THERE WAS NO RECALL AT THAT TIME, BUT THERE WERE A LOT OF COMPLAINTS ON THE NHTSA SITE ABOUT THIS SAME PROBLEM ON MY MODEL TRUCK. THE FIRST TIME IT WENT OUT OF MAY OF 2005, IT HAPPENED AGAIN FEBRUARY OF THIS YEAR. I HAD TO PAY $1,400 TO HAVE IT FIXED IN MAY 2005, BUT THE PLACE OF BUSINESS WHO FIXED IT, FIXED IT AGAIN AT NO COST, AS HE SAID HE GUARANTEES HIS WORK FOR A YEAR, AND SINCE IT HAD NOT BEEN A FULL YEAR, HE DIDN'T CHARGE ME...YOU MIGHT SAY I WAS UNLUCKY AND LUCKY AT THE SAME TIME. I BELIEVE THERE IS A SERIOUS PROBLEM WITH THAT PARTICULAR MODEL PICKUP. *NM

SPONGY BRAKES, NO BRAKES AT TIMES. LAST INCIDENT FEB. 1, 2006 WHILE BACKING IN DRIVE. PUSHED ON BRAKE AND PEDAL WENT TO FLOOR. A LOUD RATTLING, HAMMERING NOISE CAME FROM VEHICLE AND NO BRAKING FELT. I HAVE COMPLAINED ABOUT THIS SINCE I BOUGHT THE TRUCK IN 2003 AT 22586 MILES. THE MASTER CYLINDER WAS REBUILT ABOUT APRIL 23, 2004 AND IT DIDN'T HELP; IN FACT WE ABOUT LOST ALL BRAKING GOING HOME FROM DEALER. I PHONED THE DEALER AND HE ORDERED A NEW MASTER CYLINDER. IT WAS REPLACED MAY 3, 2004 BUT THE PEDAL WAS STILL SPONGY AND BRAKING VERY POOR. WHEN STOPPED AND ENGINE RUNNING YOU CAN PUSH THE BRAKE PEDAL CLEAR TO THE FLOOR. I HAVE BEEN TOLD THIS IS NORMAL. WELL, NORMAL ALMOST CAUSED A WRECK ON A DOWN HILL T ROAD WITH MY WIFE WITH ME. I PHONED CHEVROLET CUSTOMER ASSISTANCE CENTER (FILE 1-212176923) FOR HELP. A WASTE OF TIME. I PHONED CHEVROLET MOTOR DIVISION (1800-222-1020) AND ALL THEY SUGGESTED WAS TO TAKE THE TRUCK BACK TO THE DEALER, A 30 MILE DRIVE ONE WAY. THEY DIDN'T HELP IN FOUR OTHER VISITS . I DID TAKE IT BACK ON JAN. 6, 2006 FOR A BRAKE RECALL ON WHEEL DETECTORS BUT IT DIDN'T HELP THE BRAKING A BIT. THANKS. *NM

THIS VEHICLE HAD A DEFECTIVE DISTRIBUTOR CAP. WHILE ATTEMPTING TO START IT THE ENGINE JERKED SEVERAL TIMES CAUSING THE ENGINE BLOCK TO CRACK WHERE THE STARTER IS MOUNTED. THE DEALER FIRST REPLACED THE ORIGINAL CAP WITH ANOTHER DEFECTIVE CAP. WHEN THEY REPLACED IT THE SECOND TIME, I WAS INFORMED THAT THE BLOCK WAS CRACKED AND THEY COULD NOT FIX IT. *NM

AT 37720 MILES ON 2002 CHEVROLET 4X4 PICKUP. TOOK VEHICLE TO DEALER FOR SAFETY INSPECTION AND SERVICE TO GM DEALERSHIP. WAS INFORMED THAT VEHICLE WOULD NOT PASS INSPECTION DUE TO BRAKE ROTORS AND PADS BEING RUSTED AND WORN OUT. THIS WAS IN MARCH 2005. IN OCTOBER 2005 RECEIVED RECALL NOTICE RELATING TO SEVERE CORROSION BETWEEN FRONT HUB/BEARING AND SPEED SENSOR. FILLED FOR A CLAIM REIMBURSEMENT DUE TO THE FACT THAT ALL PARTS WERE INTER RELATED. ALSO EVEN THE REPAIR INVOICE STATED WORN OUT/RUSTED. WAS INFORMED THAT NO REIMBURSEMENT WOULD BE PAID.*AK

ON 2002 CHEVY SILVERADO 1500 W/ONLY 25,500 MILES, NOTICED A NOISE IN REAR BRAKES. WHEN ROTATING TIRES, DISCOVERED BOTH ROTORS WERE RUSTED AND CORRODED, BUT WITH PLENTY OF BRAKE PAD AND THEREBY CAUSING ABNORMAL WEAR ON BRAKE PADS. TOOK VEHICLE TO LOCAL GM DEALER FOR INSPECTION BY SERVICE PERSONNEL, WHO DETERMINED SAME PROBLEM, BUT WOULD NOT PROVIDE GOOD WILL REPAIR. FOR OBVIOUS SAFETY REASONS, PURCHASED REPLACEMENT ROTORS AND BRAKE PADS AND COMPLETED REPAIRS ON OUR OWN. WE HAVE CONTACTED GM TO TRY TO OBTAIN REFUND OF OUR COSTS, BUT NOT YET RESOLVED THE ISSUE. RESEARCH INDICATES THAT GM IS AWARE OF THIS PROBLEM WITH BRAKE ROTORS. ADDITIONALLY THE VEHICLE STILL EXPERIENCES PROBLEM W/ABS SPEED SENSOR REQUIRING ADDITIONAL BRAKING DISTANCE AT SLOW SPEEDS, BUT WAS NOT INCLUDED IN THE FIRST RECALL BY GM. PREVIOUSLY REPORTED THIS COMPLAINT. *JB

DT: THE CONTACT RECEIVED A RECALL LETTER FOR THE ABS SENSORS HE HAD THE WORK PERFORMED, BUT THE ABS PUMP HAS GONE BAD. HE CONTACTED GENERAL MOTORS, AND THEY STATED THAT BECAUSE MAINTENANCE ON VEHICLE WAS NOT PERFORMED AT A GM DEALERSHIP THEY WOULD NOT ASSIST HIM WITH THE REPAIRS. *AK UPDATED 11/29/2005 - *NM

OUR SILVERADO HAS THE EXACT PROBLEM DESCRIBED IN RECALL #05V37900 FOR THE ANTI-LOCK BRAKES. BECAUSE WE ARE NOT CONSIDERED A "SALT BELT" STATE G.M. WILL NOT RECALL OUR TRUCK.*JB

ABS BRAKE SYSTEM HAS BEEN RECALLED FOR 2002 SILVERODO TRUCKS IN SEVERAL STATES WEST VA. BEING ONE OF THEM I LIVE WITHIN 10 MIN OF WEST, VA. WE ARE A STATE THAT GETS A LOT OF ROAD SALT. MY BRAKE SENSOR SYSTEM HAS GONE OUT . THE CHAMPAIGN NUMBER IS 05VB379000. VIRGINIA NEEDS TO BE ADDED TO THIS RECALL LIST I HAVE JUST HAD ONE SIDE REPAIRED AT A COST OF $333.00 NOW THE OTHER SIDE IS BAD. THIS RECALL STARTED IN AUGUST BUT WILL NOT BE ISSUED UNTILL NOV. 2005 THERE COULD BE SEVERAL ACCIDENTS AND MAYBE INJURIES OR FATALITIES BEFORE NOV.PLEASE HELP TO HAVE VIRGINIA INCLUDED IN THIS RECALL AT LEAST THE MOUNTIANS OF SOUTH WEST VIRGINIA THANK YOU FOR YOR ASSISTANCE. *NM

DT: THERE WAS A PROBLEM WITH THE ENGINE DYING. ONE OCCURRENCE WAS ON 2-15-05. THE ISSUE WAS COVERED IN RECALL NUMBER 05500. THE CONSUMER HAD TAKEN THE VEHICLE IN TO BE REPAIRED ON 5-05. ON 8-29-05 THE PROBLEM OCCURRED AGAIN. THE CONSUMER TOOK THE VEHICLE TO THE DEALER AND THEY REPAIRED THE VEHICLE AGAIN. *JB