2021 CHEVROLET SILVERADO 1500 Complaints

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed or while stopping the vehicle, the contact heard an abnormal sound coming from the top of the engine where the lifters were located. The contact stated that the spring in the engine had collapsed, causing the check engine message to be displayed. The contact stated that the dealer was contacted. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the lifters on the top of the engine were causing the DEF sensor to engage. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 90,000.

I brought in vehicle for check engine light is on for p0300 / p0308 had misfire tech removed engine valve cover and determine no movement in valve train components tech determine valve train failure lifters possible camshaft we would need to remove the cylinder head and replace valve train lifters.

At 4K miles, the lifters of the engine went bad. It was determined a rod was bent and had to be replaced. At 26K miles, another cylinder went bad and had to be replaced. At 40Kmiles, serpentine belt had to be replaced. At 41K miles, another cylinder went bad and had to be replaced. Now, at 55K miles, I am getting the same issues with loss of power, engines stuttering and misfiring and will be taking the truck to the dealer on 1/28/25.

My 2021 Silverado with only 80,655 miles had to have the engine replaced. On 11/20/24, my vehicle indicated a P0303 code for miss-fire in cylinder 3. I took my vehicle to for repair to a local Chevy Dealership and was informed of the following: 1) Needed programming changes to the fuel injection based on service bulletin N242450631. This repair was completed by the dealer. 2) Needed a “tear down” for further diagnostic. It was determined that the specific code could not be repaired and the entire engine needed to be replaced which was done at my cost. The details on service bulletin N242450631 are limited and do not describe issues that could be caused by the fuel injector problem. Relative to service bulletin N242450631 fuel injector issue, based on my experience with my vehicle, I believe this fuel injector programming bulletin issue caused the engine malfunction and subsequent need to replacement. Before the bulletin repair was completed, I know that my vehicle engine surged often. Looking back now, this constant surging had to be hard on the engine and likely caused the failure. Regardless, if it wasn’t the service bulletin that caused the issue, a vehicle engine should last more than 80,000 miles. I believe GM needs to take responsibility for the engine failure which I believe was caused by faulty workmanship, design, computer engine programming, or some combination of these issues.

Driving down the road and the vehicle shut off and said to restart. Wouldn't start back up. Check and found a 400 amp fuse was blown. Tested starter and was fine. Restarted the vehicle and it made a loud rattling noise and shut back off. Sent it to the dealer and they found that number 1 and 2 rods overheated and locked up the motor.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 50-55 MPH, the vehicle went into LIMP Mode. The vehicle decelerated to 35-40 MPH. The contact stated that the vehicle was consuming an excessive amount of oil. The contact stated that the vehicle was consuming a quart of oil per month. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed with a failed lifter. The vehicle was repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 92,000.

At start up check engine light, service esc, service parking brake. Code reader shows code P0304 misfire cylinder number 4.

Lifter failure at 8629 miles. All warning lights went on at time of incident, truck would barely drive home and I had it towed into the dealership where they replaced the entire bank of lifters. This is on my repair order- "Checked and found dead mis on cylinder 4 and ticking noise from engine//performed compression test and found no compression on cylinder 4//removed passenger side cylinder head and found lifter bad causing push rod to bend//replaced all lifters on right bank and 1 pushrod//changed oil and filter//filled coolant and test drove and found all ok. I called Chevy at time of incident (1/21/22) and opened case# 9-7252876703 stating I wanted both banks of lifters replaced because I pull a 30' camper with my family and didn't want the other side to fail while I'm pulling 7000+ pounds. They declined to replace the other bank stating that since the vehicle had more than 5000 miles it did not qualify for both sides to be replaced and it was for only vehicles after 11/21 and mine was built 2/21. I still would like to get the other bank of lifters replaced under warranty.

I have just been made aware that there is a lot going on right now with the l87 6.2 motor. I purchased my truck last September so I e had it almost a year 1/2. I recently started having what seems like a misfire issue as of 1/20/2025. I have it scheduled to be checked out Friday 1/24/2025. I’m just reporting this to cover my back if any recall or anything comes about. In addition I’ve had regular oil changes and maintenance on the truck. It’s currently inspected and insured.

The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving approximately 70 MPH and attempting to overtake a semi, the vehicle lost automotive power and stalled. The vehicle was later towed to the local dealer who diagnosed that the engine had seized and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 100,000.