2002 CHEVROLET SILVERADO 1500 Complaints

EXCESSIVE CORROSION ON BRAKE AND FUEL LINES. HAD A METAL LINE BLOW OUT NEAR REAR DRIVER SIDE WHEEL CAUSING DRIVER TO HAVE TO USE TRANSMISSION AND HOLDING PARKING BRAKE RELEASE HANDLE WHILE USING E-BRAKE WHILE STEERING WITH ONE HAND. UPON SPLICING IN A SECTION OF REPLACEMENT TUBING, I NOTICED THE FUEL RETURN LINE FROM THE ENGINE TO THE TANK IS CORRODED SEVERELY TOO. I HAD A SECTION OF FUEL LINE FALL APART UPON REPLACING A FUEL FILTER AND SPLICED IN A RUBBER FUEL HOSE WITH CLAMPS TO GET A FUEL FILTER REPLACED. WHEN THE FUEL LINES RUPTURE, THERE IS A CHANCE OF FIRE FROM THE EXHAUST OR HOT BRAKE DRUMS. WAS ADVISED BY MECHANIC THAT I NEED TO SELL TRUCK AS IT HAS 18-24 MONTHS LEFT WITHOUT PROPER AND EXPENSIVE REPAIRS BEING MADE. RARELY GETS UNDERBODY WASH AS A QUALITY WASH IS FAR AWAY AND WAS ADVISED THAT THE RUST IS PROBABLY HOLDING IT TOGETHER AND ADVISED NOT TO KNOCK OFF ANY MORE RUST AS IT WOULD ACCELERATE FURTHER CORROSION. WAS ADVISED A WASTE OF TIME TO USE RUST REFORMER OR UNDERCOATING. I NOTICED THIS STATIONARY AS THE VEVICLE WAS MAKING SQUEAKING SOUNDS FROM THE REAR AXLE HUB ON DRIVER SIDE (SAME LINE THAT BLEW) AND FIGURED HANGING CALIPER SO I DID A FULL BRAKE PEDAL PRESS AND FELT THE PEDAL GET SPONGY AND DROP ANOTHER 1" TOWARD FLOOR. I OPENED DOOR, HUNG OUT LOOKING UNDER TRUCK AND PRESSED PEDAL AGAIN TO SEE FLUID POURING FROM REAR AXLE AREA. DROVE IT 30 MILES WITH NO SERVICE BRAKES TO GET TO THE GARAGE USING ONLY E-BRAKE AND 3,2,1 AND NEUTRAL RANGE OF TRANSMISSION TO BE ABLE TO STOP IF NEEDED. ALSO WAS ADVISED ABOUT FUEL TANK STRAP AND THAT I WOULD NEED A FLAME CUTTER TO CHANGE THE FUEL PUMP AS TRUCK BED BOLTS LOOKED HORRIBLE OR WOULD NEED TO CUT TANK STRAPS DEPENDING ON HOW MUCH FUEL IS IN THE TANK. THE "ANNUAL UNDERBODY WASH" MOST OWNERS MANUALS RECOMMEND IS INSUFFICIENT TO PREVENT THIS PROBLEM.

CORROSION AND FAILURE OF METAL BRAKE LINE DIRECTLY BELOW LEFT FRONT DOOR. VERY POOR DESIGN AS TUBES ARE BEHIND A DOUBLE LOOP OF CHASSIS WIRING CAUSING BUILDUP OF DIRT AND MOISTURE RESULTING IN PREMATURE FAILURE. FAILED WHEN BACKING OUT OF THE DRIVEWAY AND THANK GOD I WAS NOT ON THE ROAD

WHILE APPROACHING A STOP SIGN I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. NO WARNING OF ANY KIND. LUCKY FOR ME NO TRAFFIC WAS COMING.

BRAKE LINES RUSTD OUT. MAKING MY TRUCK LOOSE BRAKE FLUID AND HAD TO BE REPLACE,. SERIOUS PROBLEM, LUCKY I DID NO HAVE AN ACCIDENT. RUST ETC, ALL OVER THE REST OF THE BRAKE SYSTEM, VERY COSTLY, $$$$$, I WAS DRIVING DOWN A STREET SLOWLY.

CHEVY RUST. BRAKE LINES RUSTED OUT COMPLETELY AND FAILED - HAPPEN AT SLOW SPEED NO ONE INJURED. SHACKLED BROKE OFF AND HIT BOTTOM OF BED WITHOUT TOWING. FRAME IS RUSTED OUT. NEIGHBOR HAS SIMILAR VEHICLE WITH SAME PROBLEMS (PUT JACK ON FRAME AND IT WENT THROUGH THE FRAME.) MANY COMPLAINTS ONLINE ABOUT THESE VERY ISSUES.

WHILE DRIVING ON TWO LANE COUNTRY HIGHWAY AT 55MPH LOW BEAM HEAD LIGHTS WENT OFF. AFTER A FEW SCARY SECONDS I WAS ABLE TO FIND A SAFE PLACE TO STOP. I TRIED SEVERAL THINGS AND DISCOVERED THAT THE HIGH BEAMS STILL WORKED. I PROCEEDED TO MY DESTINATION DEFECTIVE MULTI FUNCTION SWITCH. INTERNET TELLS ME I AM ONE OF MANY.

BRAKES PULSATING AT LOW SPEED TRYING TO STOP ALMOST HIT ANOTHER CAR IN FRONT OF ME.

RECALL 05V379000 RELATED TO LOW SPEED ACTIVATION OF THE ABS BRAKING SYSTEM WHILE MY VEHICLE IS OPERATED WAS PERFORMED IN 2006 ON MY VEHICLE. THIS HAS NOT FIXED THE ISSUE AS LOW SPEED ACTIVATION OF THE ABS SYSTEM IS OCCURING NOW. I HAVE CONTACTED CHEVROLET CORPORATION (GMC) AND ASKED TO HAVE THE RECALL PROTOCOL PERFORMED AGAIN. THEY REFUSE. I SPOKE WITH KIMBERELY FROM NHTSA AND SHE ADVISED ME TO FILE A COMPLAINT IF GMC REFUSED TO TAKE RESPONSIBILITY FOR THIS DEFECT. PHONE CONFIRMATION # 868194

2002 CHEV. 1500 SILV. PURCH. 2001 TX.ABS BRAKE SYSTEM FAILED ON ST UNDER 5MPH,BROUGHT TO MECHANIC.,BRAKE PADS, AND TIRES.SOUTHEAST TEXAS HOT AND VERY HUMID, LAWS OF NATURE, AIRBAGS ARE NO GOOD IN EITHER VEHICLE.(SHE HAS A SON AGE 14, AND 3YR OLD GRL).AXIL IS RUSTY WORRIED THAT IT MIGHT BREAK.GOD IS WITH ALL OF US ,HIS INTENTIONS ARE ALWAYS GOOD. GOD PROTECTED HER AND HER CHIILDREN IN THIS VEHICLE THUS SO FAR..\& WE DESIRE TO PROTECT THIER CHILDREN AND YOU KNOW THIS, BUT SOMETIMES PEOPLE GO THROUGH UNFORTUNATE TRAGEDYS SUCH AS DIVORCE, HEALTH, ETC.A SINGLE, NO MONEY THAT WANTS SAFETY FOR THER CHILDREN AND WORK .CHEVY SILVERADO BROUGHT NEW PAID OFF LESS THAN 3YR. HER 1994 FORD MUSTANG (WAS INSURED FARMERS)PURCHASED IN 1997.ABS BRAKES FAILED, TRANSMISION PROB.& ENGINE REPLACED. TRUCK( GEICO INS) UNDRIVABLE BECAUSE OFELECTRICAL SYSTEM AND ABS,RUSTY BRAKE LINES, RUSTY AXILS,LEAK IN THE LINE,NO HORN, DOORS DO NOT SEAL WATER LEAK, PAINT FADED,EVEN TOOLS CAN NOT FIX THESE PROBLEMS.SHE HAS A COLLEGE DEGREE AND LIVING IN A HOME SHE BOUGHT (BEFORE THE TRAGEDY )WHEN SHE WORKED.(HELPING OTHERS AT HERMAN MEMORIAL BAPTIST HOSPITAL BEAUMONT BEHAVIOR CENTER OF SOUTHEAST TEXAS, MEHAFFY WEBER LAW FIRM, CHRISTUS ST.MARYS HOSPITAL OUTPATIENT CENTER, PORT ARTHUR ANIMAL CLINIC,PORT ARTHUR NEWS PAPER, PNG ISD AS A SUB-TEACHER,SPINDLETOP MHMR AND FAMILY SERVICES WOMANS AND CHILDRENS SHELTER. SHE HAS VOLUNTEERED AT 3 RIVERS COUNCIL FOR BOYSCOUTS OF AMERICA AND EVEN GRADULATED WITH THE WO HE LO MEDALION IN BOYS AND GIRLS CAMPFIRE SCOUTS WHEN SHE WAS 15.)SHE HAS REACHED OUT FOR HELP, AND NO ONE LISTENS....LIKE SHE DOES. EVEN THOUGH SHE IS DOWN FOR THE SEASON, SHE CONTINUES TO HELPS OTHERS BY SHOWING OTHERS THAT GOD IS GOOD HE IS REAL & ALIVE.WE R ALL GODS CHILDREN.PLEASE NHTSA, WHAT CAN BE DONE? -K

I PULLED INTO DRIVEWAY AND PUT CAR IN PARK, LEFT ENGINE RUNNING. WENT TO DOOR OF RESIDENCE TO GET MY KIDS. KIDS WENT OUT TO THE CAR AND WERE YELLING FIRE! I SEEN THE INSIDE UP IN SMOKE. I REACHED INSIDE TO TURN ENGINE OFF. WE THEN STARTED POURING BUCKETS OF WATER INTO SEAT AND ON FLOOR AROUND THE SEAT TO TRY TO PREVENT SPREAD OF THE FIRE. I LUCKILY PUT THE FIRE OUT. FIRE DEPT UNHOOKED BATTERY AND REMOVED MELTED PLASTIC AROUND SEAT. IT SEEMS A WIRE SOMEHOW SHORTED OUT BENEATH SEAT AND CAUGHT THE SEAT AND FLOOR ON FIRE.