2021 CHEVROLET SILVERADO 1500 Complaints

I have 112,000 miles on my truck and my 6.2l motor is going out or knocking. I am very unhappy that my truck is not covered under the recall and I would like to understand why it is not since this is the issue of the recall. I would like to clarification on this and what options I have since it is going to cost me 14k to replace the motor. Case #101943027

Lights on the panel reads service parking break, engine, transmission, abs, traffic control and esc service. All these lights are on. Idling rough, white smoke with rich smell. Had a diagnostic read cam/crank and lifters bad… estimated cost 15,000. Total new engine install.

I bought a 2021 Chevy Silverado 1500 Badlander edition in February of 2025. I love the truck and drive it everywhere. I have brought it in for every oil change when needed. I got my first oil change April of 2025 and had no issues. Then I got my second oil change June of 2025 and both of these were done at the dealership that I purchased the truck from. At the June oil change I asked Jeff Belzers to do an oil consumption test and they said they would not because my vin did not show up in the recall. On July 31 of 2025 I got an engine oil low light on my dash, which I took a picture of. At that time I had to add two quarts of oil. Then in August of 2025 I went in for my oil change at Jeff Belzers again and I told them about adding the two quarts of oil and asked again at that time if they could do an oil consumption test and they told me no again because my vin was not on the recall list. I then got another low engine oil light on September 29, 2025 and at that time I added 2 quarts of oil. In October of 2025 I brought my truck to Maur Chevrolet for an oil change and asked them to check my vin for a recall and they said there were no recalls. Then I brought my truck to Maur Chevrolet in November of 2025 for an oil change and I asked if the vin recall had changed and they said no. At this time I was just checking my oil and adding as needed. I took my truck in for an oil change in January of 2026 and asked about the recall again and no changes. Then after that oil change, I was adding a quart of oil every 600 miles. So when I went in for an oil change in April, I asked for an oil consumption test to be done and the service advisor said yes. This was the first positive step I had in this entire ordeal. At the end of the consumption test, which was on June 12, 2026 it was verified that the engine was burning 3 1/2 quarts of oil every 3,000 miles. At that time I had another oil change done and they told me that they would discuss what would happen on Monday June 15, 2026

The truck started backfiring and shuddering. Took it to the mechanic and with only 112000 miles I am being told it needs a new engine. It is the 6.2l motor.

Loud ticking noise and power loss. Transmission shift slips from 2nd to 3rd . Called factory and dealership for check up. Said no problem… Told to Change oil. Did this, NO CHANGE.

On June 3, 2026, my 2021 Chevrolet Silverado 1500 LT Trail Boss, which has a 6.2L L87 V8 engine, stalled and shut off unexpectedly while I was stopped at a traffic light on a public highway. The engine died without warning, leaving me stranded in traffic and creating a serious safety risk for me and other drivers because of the chance of a collision. I had to call the police to come and sit behind me to keep myself safe from a collision while I waited for a tow truck. A dealer diagnosed the vehicle with DTC P0016, indicating a crankshaft/camshaft position correlation fault. This points to either an engine timing problem or an internal engine failure. The dealer confirmed the issue and gave me a repair estimate of about $11,000. Both the vehicle and repair records can be inspected if needed. Before the failure, the vehicle showed signs of an engine timing or internal issue and eventually triggered the check engine light with code P0016. After researching, I discovered many reports from other owners with the same 6.2L L87 engine who faced similar problems, including P0016 faults, engine stalling, internal engine damage, and complete engine replacement. While some vehicles with this engine have been part of recalls or special coverage programs, my vehicle is not included, even though it shows the same failure pattern. At the time of the failure, the vehicle has about 140,336 miles. I believe my vehicle has the same defect affecting other 6.2L L87 engines. I ask that NHTSA look into whether more vehicles should be added to any current or future recalls or defect investigations. Thank you for your attention to this matter.

When i first purchased the vehicle off the lot a few years back (its a 21, so probably in 22?) Brand new off the lot minimal miles. Within the first few months we started having issues with the power wanting to shift down. We took it in, the dealership found nothing wrong with it and cleared the codes. This happened a few more times. The last 2 times I took it in. They mentioned that there were recalls on it and could possibly be causing the issue. Took care of that (last august- have docs. to prove it as along with what they did and what we stated). Fast forward now 2 months ago (April of 25) and it starts acting up again and wants to downshift, shifting hard, stuttering and not wanting to drive, the same things we have been complaining about since beginning with lights on etc. However, this time we tried to shut it off and give some down time to get back home. After about 10 mins, we went to start the truck to get it home, and it would not start. We had it towed to the dealership. Once they got it, after 2 weeks of waiting we were finally presented with, the starter went out and the wiring box needed to be replaced (this has to be done before they can look into the original problem again) (because without those 2 things fixed, they wont be able to do) it is now June. I took the vehicle home, due to not having funds to fix right away. After doing some research and some digging, it would appear that the issues that we are having with the truck are issues that are already being recalled on this specific truck and model. However, for mine it is not, because I have the 2.7 l turbo and not the 6.8. THere have been numerous complaints about the known issue.(which i found out is the other wiring by the engine that is being chafed which is causing the wires to break and causing the other box and alternator to go and be replaced). If you replace it fries all again. Why is the 2.6 engine problem thats reported not recalled but rest is and it is known. I also see this online

Loud ticking noise and power loss. Transmission shift slips from 2ed to 3rd .Recall to factory for check up. Said no problem? Changed oil. They say it was good. It is not.

After putting our Silverado in park it will not turn to the off position or release the key from the ignition immediately. We have to wait 1-3 minutes without attempting to turn it in the off position and then the key will release from ignition. No warning lamps. No error codes on reader. Repeatable by auto technician who suggested a battery change- our current battery was fine and did not fix the issue. If you forget and try to remove the key in under a minute after parking you have to restart the truck, go back to park and then start the 1-3 minute countdown all over before it will release the key. The truck is in park, the parking brake is engaged (although we tried without using the brake and still won’t release key) This means the trucks battery has to run until it will release the key. Or chance leaving the key in the ignition (still draining battery) since it won’t turn to the off position.

Was on way to trade truck in onb6/6/26 and got a cylinder #7 misfire. Replaced spark plug and wire and moved coil packs around to trace and stayed on #7. Just had recall completed on 9/25/25 and stated that I've heard a rattling noise in engine area. They performed recall and changed to new oil suggested by GM. Dealership said noise was transmission. I told them that was replaced already within last 50k miles under warranty. Drive it for a few days and rattling noise still there. Took back to dealer on 9/30/25 at cost of $200 diagnositc and stated there is a grinding noise under light acceleration like it's metal on metal. Dealer stated that it was the rear seat rattling. There were NO noises in the cab, only coming from outside at driverside motor area. Called GM 10/1/25 to let them know the denial of motor replacement and we wanted 2nd opinion but we would have to pay out of pocket again. On 6/4/26 had to have truck towed to new dealer. New dealer won't make deal on new truck because of this and we have 2 trips already booked and paid for and 1 at end of June. New dealer is putting in service on 6/8/26 to verify cause. I have called GM after making repairs and they said it was between me and the dealer, there is nothing they can do. This is unacceptable! Im fine if they would offset cost and buy a new Chevy truck and we are going to fight to get it made right. This does make us want to change brands even though we've bought 5 Chevys in the last 10 years.