2021 CHEVROLET SILVERADO 1500 Complaints

The contact owned a 2021 Chevrolet Silverado 1500. The contact stated that approximately 35 minutes after parking and turning the vehicle off he was notified that the vehicle had caught on fire. The fire department was called to the scene and extinguished the flames. Upon inspection, it was determined that the fire originated in the engine compartment. A police and fire report was taken at the scene and the vehicle was towed away. During the incident, the vehicle was destroyed. The manufacturer and local dealer were notified of the incident. The failure mileage was 12,000.

I was driving and noticed several loud clunking noises coming from the Engine bay. The truck began to cut out, shake, and misfire. My dash began to flash and state I had a parking brake failure. I had no choice but to be towed. I have just shy of 17,000 miles. The dealership stated I had two lifter and 1 rod failure. They replaced the rod and all lifters on one side of the engine. I took the truck home for one night and it broke down again. The dealership stated it was fixed for a second time. When I picked it up again, I made it 1 mile down the road before the truck had the exact same symptoms with shuddering and misfiring. It is at the dealership for a third time. I was surprised to fin several class action lawsuits now filed against gm concerning the lifter issue. YouTube is full of lifter issue videos. This should be fully investigated and obviously warrants a recall for lifters, rods, and the camshaft.

When I start my Chevy Silverado 1500, three warning lights come on that are telling me that I have brake system failure 43 MPH top speed, Service ESC and Service Trailer Brake system. When I drive, the brakes are very mushy and the truck is very difficult to brake. 20 minutes later after stopping and getting ready to take the truck to the dealer, the brakes worked fine. The dealer couldn't replicate the problem at first, but finally had the issue when they were putting it on the rack to perform improve my tire alignment, so they said they updated the software. The truck brakes worked fine when I left the dealership. The next day (Saturday) I went to start the truck and the same issue happened. I can't take it in as Service is not available on Saturdays so I started looking online. Apparently there are several other owners dealing with this same issue and have been for years. I have read that it might be a variety of things causing this issue, but someone needs to get this resolved ASAP as I have read about some getting into accidents regarding this. My truck is only 16 months old and only has 14,000 miles on it.

My 2021 Chevrolet Silverado started on fire and blew up in my driveway. I had just returned from the store, parked it and went inside. No more than 3 minutes later, my neighbor came running over to tell me my truck was on fire. There were no issues at all while I was driving the vehicle. The township fire department said this is the 4th 2021 Chevrolet Silverado that has burst into flames in the last 6 weeks. They said they all had the 2.7L Turbo engine, as well. The truck is a complete loss. I have contacted the dealership and Chevrolet about the issue and have not heard back yet. The fire started in the engine compartment and quickly raged out of control. The hood and engine disintegrated from the heat. The vehicle was towed away and the insurance adjuster has yet to go out and look at it. If I would've been stuck in traffic on the way home, I would have been in the vehicle and may not be here typing this report right now. It went up that fast. This is a major safety issue that needs to be thoroughly investigated before somebody loses their life. It nearly caught my house on fire, but thankfully there was only minor damage to some garage trim and the driveway is ruined. Please investigate this issue immediately. This was a pretty traumatic experience, to say the least.

On April 29, 2022 between 4:45 - 5:00 pm Eastern, I was dropping off my son at work when I suddenly experienced a variety of Truck Diagnostic Error messages on the front driver display window. In addition my OnStar advanced diagnostic alert system informed me with the following system issues: Engine and Transmission; StabiliTrak stability control; Antilock Brake; and Emissions. At that moment the truck experience a cut in power and slowed down with a knocking sound coming from what seemed under the truck. I slowly proceeded to drop off my son and drove back home and parked the truck. Truck was towed to local Chevy dealer on Friday of that day. A preliminary diagnosis was done Saturday, April 30 suggesting an Engine Lifter issue. On Monday, May 2, 2022, a final diagnosis determined engine lifter failure on one side of engine bank. Vehicle is still under Warranty with 17,400 miles on it.

GM USES/USED SUBSTANDARD ENGINE COMPONENTS i.e. LIFTERS. GM KNOWS THSES ARE PRONE TO FAIL, YET ONLY REPAIRS THE VEHICLES THAT ARE AT AN AUTHORIZED DEALER PRIOR TO SALE. ALL THE VEHICLES THAT WERE ALREADY SOLD WILL NOT BE REAPIRED UNLESS ITS BROUGHT IN FOR SEVICE, GM WILL NOT NOTIFY CUSTOMERS OF THIS ISSUE. ALSO GM FAILS TO STOCK THESE PARTS EVEN THOUGH BY THERE OWN SERVICE BULLETINS SUBSTANDARD PARTS WERE USED TO BUILD THESE VEHICLES. GM WILL NOT SUPPLY LOANER VEHICLES TO PATRONS WHO DO HAVE THIS SERVICE DONE NOR WILL THEY TELL CUSTOMERS THAT THE PATRON COULD RENT A VEHICLE AND GET REIMBURSED FOR SAID RENTAL.

A squirrel chewed into the fuel line [Hose - GM (84871298), see: https://www.gmpartsdirect.com/oem-parts/gm-hose-84871298). This caused a fuel leak that could be directly observed only while the vehicle was running. On one occasion, however, a small pool of fuel appeared under the vehicle immediately after shut off. This part failure poses a fire and explosion risk. In addition, the wasted gasoline pollutes the atmosphere. The line was replaced at Lynn Layton Chevrolet of Decatur Alabama (invoice 608119). The part was inspected by Lynn Layton Chevrolet as part of that service ticket in order to determine the cause of the leak. To my knowledge, further inspection has not occurred. No warning lamps indicated the failure. The problem was detected by observing the trail of fuel when parking.

Concern: Various check engine lights occurred and vehicle making noise from the motor. Park collision assistance codes, emergency brake engaged code, when it was not on and could not move vehicle. Safety concerns about vehicle completely quitting or braking causing an accident, along with engine issue with only 5,161 miles on the motor of a 2021 Chevrolet Silverado. Cause: Scanned data indicated p0300 stored miss fire #4 cylinder on right side of engine, lifter noisy, push rod #4 intake bent. Correction: Removed intake, exhaust manifold, value cover, cylinder head, right side replaced all lifters, one push rod, related gaskets, reassembled engine.

While driving East on I-24 with my granddaughter. I felt a thump much like hitting a big dog or something in the road. I looked at my 10 year old granddaughter, she was looking at me, she said what was that? I said I don't know, but it happened again in about 1/4 mile down the road. We traveled about another 1/4 mile when the truck started sounding like a machine gun being fired!! My granddaughter started crying as she was scared, I pulled over into the emergency pull off to check my truck. It was running good now and NO ENGINE LIGHT was on. So I continued driving toward Clarksville, TN. although I considered turning back and heading home. I thought maybe it was water in the gas or something. After arriving in Clarksville to pick up my two grandsons we started home. As soon as I got on I-24 west the truck started the same thing again. Felt like we hit a big dog and then started sounding like a machine gun being fired. This time the ENGINE LIGHT DID come on. I was afraid the truck was going to quit running and there I was with 3 grandkids on a very busy I-24!! I contacted Patroit Chevrolet where I purchased the truck at. They told me it would be 6 weeks before they could look at my truck!!!! I hung up but called back as I was afraid that I couldn't make it home, the truck was running bad!! They found that it had dropped a lifter, it had only about 6,300 miles on it!!! They had it for about 3 weeks. Now, I find out that GM has had a lot of problems with these motors, "A LOT of PROBLEMS"!! I,m sure the problem WILL happen again, I am hoping no one gets killed when it does. THIS IS A DANGEROUS PROBLEM!!! GM needs to replace these motors or buy them back or something!!!

There is a massive shudder that sounds like the whole dash could come loose. feels and sounds like rumble strips and off road driving mixed all together. It happens at all speeds and when rpms are steady around 1200-1400.