2021 CHEVROLET SILVERADO 1500 Complaints

While driving my 2021 Chevrolet Silverado 1500 Trail Boss, multiple warning lights and messages suddenly appeared related to the ABS and brake system. The brake pedal became extremely difficult to press and the truck became unsafe to drive. The issue happened unexpectedly while the vehicle was in operation, creating a serious safety hazard and risk of accident or injury. After the incident, the truck was inspected by a mechanic who advised that the brake booster had essentially fallen apart and that I effectively had little to no braking capability. I was also informed that the condition and quality of the braking components were not acceptable for a vehicle of this age. This vehicle is only five years old and has been regularly maintained. For approximately the last three years, routine maintenance including oil changes, tire rotations, and inspections were performed at a Chevrolet dealership. At no time was I warned of any brake-related issue or safety concern. A major brake system failure should not occur suddenly on a properly maintained vehicle, especially without warning. This incident was extremely dangerous and could have resulted in a serious crash. I am submitting this complaint because I am concerned there may be a defect involving the brake system, brake booster, ABS system, or related components on this vehicle.

The engine was burning oil, so did a consumption test. The dealer took apart the engine and found the rings for the pistons were leaking and scaring was resulting. This caused me to buy part of a new engine because it was 6days past warranty with only 44,000mi on it. Also, at 18,000mi, a lifter bent and needed that replaced. There are numerous reports for this engine. It should be recalled! I shouldn't have to pay out of pocket for the defaulted error proned engine.

The contact owns a 2021 Chevrolet Silverado. The contact stated that while driving at various speeds, a flashing check engine warning light appeared on the instrument panel. The vehicle was taken to a dealer where the received fault code PO300 which was a general code for a misfire in the engine. The contact brought the vehicle back to the dealer multiple times due to various fault codes; however, the contact was given the same information. The contact then received a "Low Oil, Check Oil", the contact checked the oil and discovered no oil on the engine's dipstick. Due to the failure, the vehicle was towed back to the dealer where they began an oil consumption test. The valves collapsed and the dealer replaced the valve in cylinders 1,3,5, and 7 as well as the spark plugs. Despite the repair, the contact stated that the failure returned almost two months later. The contact continued the oil consumption test and stated that the vehicle was losing 3 quarts of oil each oil change. The manufacturer had been notified of the failure on multiple occasions and had made multiple vehicle buyback requested; the manufacturer denied each buyback request. After his latest phone call with the manufacturer, he was referred to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was 12,000.

My 2021 Chevrolet Silverado 1500 with the 3.0 diesel is experiencing constant high running engine fan, engine power reduced notification on the dash, fluctuating temperature and is showing a P1098 code indicating the coolant control valve needs replaced. GM has issued a special coverage on this part, which my truck is well withing the parameters for. However, GM tells me the VIN isn't associated with the special coverage. I have spoken with other owners who have the same year / engine vehicle as I do, and GM replaced their part for free under the special coverage. I have not been giving any explanation as to why my vehicle isn't covered even though the bulletin N25250834 clearly states my vehicle and year. I escalated to the GM executive level and have failed to get my coolant control valve replaced. The vehicle reducing engine power is a major safety concern in traffic as well as the obvious over heating issue. GM is blatantly mishandling the situation.

The contact owns a 2021 Chevrolet Silverado LD Crew. The contact stated that while reversing the vehicle, the rear end locked up. Also, when accelerated, the vehicle jerked forward and stalled. When the vehicle is shutdown and restarted the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage. 64,900.

47,000 miles and the transmission coolant lines are weeping and need to be replaced.

Once I disengaged the auto stop on my vehicle, I would accelerate from a stop and I would loose my brakes. This happened several times. I took it to the shop and was told it was fine. Finally, one day I was descending on an overpass, disengaged my auto stop and my brakes were complete failure, even my emergency brakes, my check engine light engaged (the code read emissions issue). Was able to stop in a field, get it back to the dealership to find out I lost the master break cylinder but no indication on prior visits. The truck, check engine light will spontaneously start blinking but hold no codes. I have had it routinely serviced and it will overheat and oil will run hot but mechanics find no issues

I am submitting a formal safety complaint regarding an electrical system failure on my 2021 Chevrolet Silverado with approximately 61,000 miles. I brought the vehicle to Taylor Grubaugh Chevrolet of Waynesville after the check engine light illuminated. The dealership diagnosed a premature wiring harness failure caused by chafing. They also stated that this issue is known to affect multiple GM vehicles and is documented in Technical Service Bulletin 21 NA 149. Wiring harness failure presents a significant safety concern. A compromised harness can lead to erratic electrical behavior, reduced engine performance, stalling, or sudden loss of power while driving. With that the concern a possible vehicle malfunction or losing power in traffic came to light. The dealerships service department confirmed the problem, verified the wiring harness failure, & referenced the applicable GM technical bulletin. The vehicle was inspected by the authorized Chevrolet dealership. GM declined to cover the repair. No police, insurance, or other third party inspections have been conducted. Despite acknowledging that this is a documented & recurring issue across GM models, the GM informed me that the repair would not be covered under warranty or recall. At only 61,000 miles, a wiring harness failure due to chafing is not consistent with normal wear & tear & instead suggests a premature defect. Given that this is a known and documented defect, I believe it should be recalled. After further research, I discovered that this issue is far from isolated. There are more than 1,500 complaints filed with the Better Business Bureau and approximately 800 complaints submitted to NHTSA reporting the same or similar wiring harness failures across GM vehicles. The volume of complaints strongly suggests a widespread defect that may pose ongoing safety risks to consumers.

The contact owns a 2021 Chevrolet Silverado1500. The contact stated while driving the vehicle he felt shuttering and noticed his automatic start does not start. The contact also experienced engine reduced power issues, preceded by a warning sign on the dashboard stating "Engine Power is Reduced" while driving. Additionally, the contact noticed a significant loss of mileage per gallon and a loss of oil. The contact noticed a check engine light on, which had codes that had a crankshaft and cam shaft sensors that are not operating properly, which the vehicle cannot be inspected due to the failure. The vehicle was taken to a dealer where it was diagnosed to need a new timing chain to control on the cams and crankshaft. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 110,000.

While driving on the freeway, the truck suddenly displayed a flashing check engine light along with multiple warning/error messages. I was able to limp the vehicle to the nearest mechanic, where they inspected it and confirmed catastrophic internal engine failure. Upon removing the oil pan, they found large copper-colored metal chunks and metallic glitter throughout the engine oil, indicating severe internal bearing/component failure. The vehicle is no longer safe to operate and now requires major engine repair or replacement.