2020 CHEVROLET SILVERADO 2500 Complaints

THREE WEEKS I NOTICED THE HEADLINER ABOVE THE REAR WINDOW WAS WET. THE REAR WINDOW HAS SOME CRACKS ON THE TOP PLASTIC MOLDING THAT HOLDS THE WINDOW TO THE CAB OF THE TRUCK. THIS MOLDING IS IN BETWEEN THE HEADLINER AND THE REAR GLASS.

The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving approximately 45 MPH, the check engine warning light illuminated. The vehicle was taken to the residence. The vehicle was then taken to a dealer, and DTC: P133X (Cylinder X Glow Plug Failure) was retrieved. The contact was informed that the Glow Plug needed to be replaced and reprogrammed. The vehicle was repaired, but the failure reoccurred with a different Glow Plug five months later. The vehicle was taken to a dealer to be diagnosed, and it was determinedthat Glow Plug #3 had failed, and DTC: P0673, P0607, and P133A were retrieved. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 50,616.

Pulling out onto road, heard a bang, no forward or backward, unable to move vehicle, brought to repair shop, says output shaft is sheared off, 68000 miles on it, looked on line, apparently common defect, my son in laws friend just had his happen getting off ramp exit, 80000 miles, I’ve read where low as 20000 miles, as well as 59000, 33000 ridiculous crap made in USA…. Please help! No repair as of yet.

The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at 50 MPH, the vehicle went into LIMP Mode. The check engine warning light illuminated, and the messages "Service Emission System”, “See Owner's Manual", and "65 MPH Max Speed" were displayed on the instrument panel. The vehicle was taken to the dealer, where it was diagnosed, and determined that the diesel exhaust fluid gas tank connector terminal had overheated, and the gas tank and the wiring harness needed to be replaced. The vehicle was not repaired due to the cost. The vehicle remained at the dealer. The contact associated the failure to the Global Warranty Management: N212342980. The manufacturer was not notified of the failure. The failure mileage was 173,794.

On approximately January 24, 2026 my 2020 Chevrolet Silverado 2500HD equipped with the 6.6 Duramax Diesel displayed an error code (P20B9). This error code was found to be related to the diesel exhaust fluid system specifically relating to "Reductant Heater A Control Circuit/Open." On January 27, 2026, the vehicle was diagnosed at Chevrolet dealership and the following was reported "Diesel Emissions Fluid Tank Remove and Replace - P20B9 SET FOR REDUCTANT HEATER CIRCUIT...COMMANDED ON AND ZERO AMPS..CIRCUITFAILURE... DISCONNECT PUMP MODULE AND BURNED/OVERHEATED TERMINALS..PUMP MODULE AND HARNESS PART OF TANK ASSEMBLY... LABOR TIME ADDED TO PERFORM MALFUNCTION/TAMPER TEST TO CLEAR EMISSIONS MESSAGE...." I found the "burned/overheated terminals" comment to be alarming. I looked into this matter further and found a GM Service Bulletin (21-NA-006) from October 2022. This bulletin identified this issue which contained an image showing burned/overheated terminals. The identified cause within the bulletin states "This condition may be caused by a poor connection at the Emission Reduction Fluid Tank electrical connector." I believe this should upgraded to a safety recall due the the potential of this terminal connection catching fire which could be detrimental for the operator, passengers, property, and the public.

The engine block heater in my truck keeps tripping the circuit breaker. Dealership says it that 'it appears that the block heater cord is shorted recommend replacing cord' estimate $500. I understand that Chevy has recalled some trucks from this year for this very problem however it and they don't include my truck. This is a fire safety hazard!!! The company admits it is a safety issue. Why isn't my truck on the list? Here is the article I found on it. 2020 silverado engine block heater cord recall +5 General Motors has issued recalls affecting 2019–2020 Chevrolet Silverado 1500 and various heavy-duty models (4500HD-6500HD) due to a fire risk from the engine block heater cord . The cord can short circuit, potentially causing a fire in the engine compartment. Owners are advised to park trucks outdoors and away from structures until the free dealer repair is completed. Key Details Regarding 2020 Silverado Recalls: Affected Vehicles: Specific 2019-2020 Chevrolet Silverado 1500, GMC Sierra 1500, and 2019-2023 4500HD, 5500HD, and 6500HD trucks. The Issue: The engine block heater cord or its terminals can short-circuit, causing a fire risk. Symptoms: Potential for smoke, a burning smell, poor heater performance, or tripped circuit breakers. Action Required: Dealers will inspect and potentially disable or replace the block heater cord. Safety Recommendation: Do not plug in the engine block heater until the recall repair has been performed. It is recommended to check the NHTSA recall website with your VIN for the most up-to-date information on your specific vehicle. GM recalls 40,000 pickups over fire risk - FOX 5 San Diego Apr 24, 2023 — This is an archived article and the information in the article may be outdated. Please look at the time stamp on the story to see when it was last updated. (WJW... [XXX] Part 573 Safety Recall Report 21V-496 - nhtsa Mar 4, 2022 — Description of Defect : ... In vehicles equipped with the Duramax dies INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

10L1000 transmission, began having problems with delays and harsh gear engagement. Flare shifting and shuddering. Finally starting having transmission overheating issues while towing. I had to make several unsafe stops with a trailer to wait for the transmission to cool down again before continuing to get it home. Saw trans temps up to 240°F on flat land with 40° outside temps. I could smell the hot transmission fluid inside the truck. When I went to check the fluid level of the transmission, the fluid was full but had a large amount of glitter like metallic flakes. The fluid was very dark brown in color and smelled terribly burnt. The last recall I took in to the dealer for was about the transmissions possibility of failing, locking up, along with the rear wheels at any speed. I have young children that ride in this truck, that in it self was unsettling and unsafe. But then to have issues with absolutely no warning light was concerning. Ive since ordered an aftermarket built transmission to avoid repeating the same issues with a factory GM replacement. My factory warranty had also ended a few months prior to having these problems with it. Leaving me to completely foot the bill for it to be replaced. I had to pull money from my retirement early to cover costs, in fact costing me much more than just the sticker price.

La transmicion viajaba aproximadamente a 70 millas cuando empeso a regresar los cambios rapidamente adta quedar parado en la carretera sin movimiento apague y volvi a encensenderla y trabajo una ves mas pero asiendo cambios bruscos Aora el dealer no quiso atender el recall disen que se tiene que remplazar la transmicion completa

I am filing a safety and health complaint regarding a known rear window water intrusion defect on my 2020 Chevrolet Silverado 2500 with approximately 56,000 miles. Despite the severity of the issue, the dealership has refused to provide a permanent repair. This defect is widely documented and has resulted in a recall in Canada, yet no recall exists in the United States—despite significantly more of these vehicles being sold here. The inconsistency in recall coverage is deeply concerning. My vehicle experiences substantial water intrusion that has saturated the rear headliner, rear seat area, and carpeting. This creates a serious health concern, particularly for rear-seat passengers, including children. Prolonged moisture intrusion creates a high likelihood of mold growth beneath interior components, which General Motors has failed to address. There is also a serious safety risk. The rear sliding window heater module is mounted directly to the rear window. It is well known that when this module is exposed to moisture from the leak, it can cause the rear window to shatter or explode. The dealership has acknowledged this risk. A rear window shattering while occupants are in the vehicle could result in serious injury. When covered under bumper-to-bumper warranty, the dealership’s only solution is a “reseal” of the rear window. This is not a permanent repair, and many owners report repeated failures after resealing. This issue is easily verified through widespread consumer complaints. These trucks are expensive vehicles, and owners should not be forced to accept temporary fixes for a defect that presents clear health and safety risks. I respectfully request that NHTSA investigate this issue and take appropriate action.

The contact owns a 2020 Chevrolet Silverado 2500. The contact stated that while driving at an undisclosed speed, the rear wheels locked up momentarily. The check engine warning light was illuminated. The vehicle was previously taken to the local dealer to be repaired under NHTSA Campaign Number: 24V797000 (Power Train). The vehicle was repaired, but the failure recurred. The manufacturer was contacted, who confirmed that the recall repair was a one-time free repair, and no further assistance was provided. The failure mileage was approximately 188,000.