2016 CHEVROLET SILVERADO 3500 Complaints

There is excessive play in the steering causing the vehicle to wander. Problem is amplified at freeway speeds or while towing 5th-wheel. On some roads truck will pull one direction till change in road slop cause truck to swerve in opposite direction. Like many others have stated this is a dangerous situation. Problem has not been confirmed by service center on this truck, but manufacturer has issued TSB PIT5501E. There are no warnings messages.

Rear passenger side, brakes, locking up keeping the truck from rolling. Replaced the brake fluid line and also both calipers. The brakes are still locking up.

Plugs for brake/running/turn signal lights have moisture and road salt inside and corrode causing brake/running/turn signal light to not operate. I have cleaned the corrosion out multiple times, now the contacts inside the plug have corroded away with the only resolution being to replace the wire harness. Parts are available for inspection. My safety and the safety of others is at risk due to failure of lights to operate. I have not contacted a dealer or service center. I have diagnosed the problem myself and will repair myself when i receive the new wire harness. I have several other individuals who have experienced the same failure as described.

Friday October 8th 2021, my truck shut off in the middle of Chesnee SC within 1/4 mile after filling up with diesel fuel at the Hot Spot in Chesnee. I had it towed to Burns Chevrolet in Gaffney SC for analysis. They determine it was the result of contamination in the fuel and that is not a warranty issue. I would agree that is not the responsibility of Chevrolet and I authorized them to make the repairs. They did what you would normally expect with the exception of one thing. They came back and said they had to replace the fuel transfer line between the fuel tanks. Said it was kinked. I questioned how water in the fuel could cause that to happen but they said the contamination was the root cause and I had to pay to fix that as well. I requested a sample of the contamination and all parts replaced. That charge was included on the invoice and I paid it. There are other issues with the quality of the service which included returning the next day because the water contamination light came on again. They had to bleed the newly installed fuel filter there in the parking lot and the light went off. When I got home and inspected the replaced parts, I found that the fuel transfer line not only was kinked, but also ruptured. I just retired from an OEM as a quality specialist, and many of my parts were safety critical. I would be willing to bet that the Tier 1 supplier does not have a ruptured fuel line ranked very high on their FEMA plan due to the probability of water causing a kink little on a rupture, but according to the Chevrolet technician that was the root cause, so they own it. I called Chevrolet corporate and informed them of my plan to report this incident. They opened an incident report, but failed to take any action to address my concerns. You will find when you check the dealers repairs to this vehicle, it has had several issues related to fuel problems. Due to space limitations on this page, I cannot tell you the whole story. Contact me and I can explain furthe

During snow removal the night of December 10, 2021 into the morning of December 11, 2021, vehicle was in reverse traveling approximately 10-20 mph (actual speed at impact is unknown). Upon impact with a tree in the rear of the truck, the airbag system in the vehicle was engaged. The seatbelts locked up, and the airbag chemicals in the steering wheel and front passenger airbag compartment were activated, however, none of the airbags physically deployed. Attached phots will show the source of impact. The frame is likely twisted. Additional photos attached show that the seat belts locked up and that the airbag system was engaged without deployment of bags. Currently working with Mankato Motors Co, 1815 Madison Ave, Mankato, MN 56001, with a phone number of 507-625-5641. Vehicle has not been inspected yet to provide full report of findings and damage assessment. Vehicle was drivable to move from incident location to my residents and current location of the vehicle is 638 Clay Ct., Mankato, MN 56001. Vehicle has been washed to show all damage and provide for ease of investigation and inspection.

Driving my truck, without a trailer, the "Service Trailer Brakes Soon" fault came on my truck. This is a known problem that GM is aware of with their ITBC system for YEARS & have done selective recalls for. This a hazard to the motoring public. There is no warning when this fault happens while pulling a trailer & when it does pop up, you lose all trailer brakes. I had the same problem with my 2010 Silverado, after numerous visits to the dealership & thousands of dollars & filed complaints with GM & NHTSA, nothing was done. When taken to the dealership, if the fault isn't on the screen, they claim they can't find or fix the problem. I pull a 10,000 pound 5th wheel, I need trailer brakes when I apply them.

SERPENTINE BELT BROKE . I HAVE IT AVAILABLE. RECOMMENDED SERVICE IS 150K MILES OR 10 YEARS . IT BROKE AT 55K AND 5 YEARS. LOST BRAKE AND STEERING ASSIST. ALMOST IMPOSSIBLE TO STOP OR TURN VEHICLE. IT IS A DIESEL AND USES HYDRAULIC ASSIST. DEALER REPLACED BELT COULD NOT DETERMINE CAUSE OF PROBLEM. HAS NOT BEEN INSPECTED. NO WARNING.

BRAKES ARE NOT EFFICIENT. THEY NEED ENORMOUS AMOUNT OF PRESSURE TO STOP. OR BRAKE PEDALS MUST BE APPLIED(PUMPED) SEVERAL TIMES TO STOP BETTER WITH LESS PRESSURE.

DRIVERS DOOR LATCH SCREWS HAVE LOOSENED- 1 OF 3 SCREWS MISSING. IF THE OTHER 2 BREAK OR FALL OUT, THE DRIVERS DOOR COULD OPEN UNEXPECTEDLY. THE TRUCK HAS LESS THAN 52,000MILES ON IT.

I BOUGHT THIS TRUCK IN OCTOBER 2019. WHILE OUT ON THE TEST DRIVE, I NOTICED 2 TO 3 INCHES OF FREE PLAY IN THE STEERING WHEEL. I ASKED THEM TO LOOK INTO IT AND THEY FOUND A BOLT IN THE STEERING BOX HAD BACKED OUT ABOUT A HALF INCH ON IT'S OWN. THEY FOUND A TSB FROM GM SAYING TO USE LOCTITE ON THE BOLT. THEY FIXED IT AND EVERYTHING HAS BEEN GOOD FOR TWO MONTHS. I AM NOW STARTING TO FEEL FREE PLAY AGAIN AND THE STEERING ITSELF FEELS VERY LOOSE/ NO STIFFNESS AT ALL WHEN DRIVING AT ANY SPEED. I'VE SEEN MANY OWNERS IN MANY DIFFERENT FORUMS COMPLAIN ABOUT THE SAME ISSUE AND I FEAR FOR MY FAMILIES SAFETY WHEN TOWING OUR HEAVY CAMPER NEXT YEAR ON VACATION. GM NEEDS TO RECALL THIS ISSUE BEFORE SOMEONE IS SERIOUSLY INJURED.