2015 CHEVROLET SPARK Complaints

SEATS - THE DRIVER SEAT BECOMES LOOSE RESULTING IN MOVING FORWARD WHILE PUTTING ON BREAKS OR BEGINNING TO ACCELERATE. SPEED CONTROL - THE VEHICLE TAKES A WHILE TO ACCELERATE AFTER BEING AT REST.

WHILE DRIVING NORMALLY, THE "SERVICE STABILITRAC" WARNING APPEARS FOLLOWED IMMEDIATELY BY A "SERVICE BRAKE ASSIST" WARNING. THEN THE BRAKE PEDAL REQUIRES EXTREME EFFORT TO SLOW OR STOP THE CAR. THE REGENERATIVE BRAKING IS ALSO DISABLED. AFTER STOPPING THE CAR, THE CAR CAN BE TURNED OFF AND THEN BACK ON WHEREUPON THE BRAKES WILL BE WORKING NORMALLY. THE WARNINGS AND LOSS OF BRAKING ASSIST MAY STAY AWAY FOR A PERIOD OF 1 MINUTE OR UP TO 1 WEEK OR MORE. IT APPEARS TO BE VERY RANDOM. FORTUNATELY, NONE OF THE OCCURRENCES HAVE RESULTED IN A CRASH, BUT THERE HAVE BEEN SCARED DRIVERS AND PASSENGERS. THIS IS THE SECOND TIME THIS PART (THE DEALER BLAMES THE BPMV AND IS NOW PUTTING THE FOURTH ONE ON MY CAR) HAS BEEN AT THE DEALER. THE SECOND ONE WAS APPARENTLY LEAKING WHEN INSTALLED. THIS WORK WAS PERFORMED AT MOMENTUM CHEVROLET IN SAN JOSE, CA. THE PROBLEM OCCURS WHEN THE CAR IS IN MOTION, TYPICALLY AT 20-50 MPH, AS THAT IS WHAT MOST OF MY DRIVING CONSISTS OF. THERE IS A FORUM THREAD ON THIS SUBJECT AT CHEVY SPARK EV FORUM. OTHER DRIVERS HAVE DESCRIBED MULTIPLE EVENTS IDENTICAL TO MINE. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*CC

THE TRACTION CONTROL LIGHT, STABILITY LIGHT AND CHECK ENGINE LIGHT CAME ON WHILE DRIVING ON A CITY STREET. ACCORDING TO THE DEALERSHIP IT IS HAVING RANDOM MISFIRES. THE DEALERSHIP IS WANTING ME TO PAY AROUND $350 TO HAVE THE CARBON CLEANED OUT BUT THEY CAN'T GUARANTEE THAT WILL FIX IT. THEY SAID MY WARRANTY DOESN'T COVER IT. THEN I ASKED IF I GO THAT ROUTE AND IT DOESN'T FIX IT, WHAT THE NEXT STEP IS. THEY SAID TO TAKE THE ENGINE OUT AND CLEAN IT BY HAND, ROUGHLY $1000, AND THE WARRANTY DOESN'T COVER THAT EITHER. I AM NOT SATISFIED WITH THEIR RESPONSE AND AFTER READING PAGES AND PAGES OF THE SAME ISSUE IN FORUMS AND NO ONE MENTIONING THEY HAD TO GO THROUGH THESE STEPS HAS LEAD ME TO BELIEVE IT IS ONLY PUTTING A BANDAID ON THE ISSUE. I DIDN'T BUY THE EXTENDED WARRANTY JUST TO HAVE TO DOLE OUT HUNDREDS IF NOT THOUSANDS.

COMPLETE BRAKE FAILURE WITH MY 17 YEAR OLD DAUGHTER DRIVING. SHE NEEDED TO SWERVE INTO A CURVE TO SLOW DOWN BEFORE APPROACHING BUSY INTERSECTION. WE KNOW OF AT LEAST 4 OTHER IDENTICAL ISSUES WITH BRAKE FAILURE AT OUR DEALERSHIP ALONE WITH ONE OWNER HAVING BRAKE FAILURE 3 SEPARATE TIMES ON THE SAME 2015 CHEVY SPARK. THEY REPLACED HER 2015 WITH A 2016 AND HAD THE SAME BRAKE FAILURE IN HER NEW CAR. *TR

TWO WARNINGS FLASHED: "SERVICE STABILITRAC" FOLLOWED BY "SERVICE BRAKE ASSIST." IMMEDIATELY AFTERWARDS THERE WAS A COMPLETE BRAKE FAILURE WHILE IN MOTION ON A CITY STREET. LUCKILY WE WERE ON A SLIGHT INCLINE AND THERE WASN'T MUCH TRAFFIC SO WE WERE ABLE TO SAFELY NAVIGATE THE CAR INTO A PARKING LOT AND STOP BY HITTING A CURB. OTHERWISE, I DON'T WANT TO SPECULATE ON WHAT MIGHT HAVE HAPPENED.

THERE WAS A "SERVICE STABILTRAC" WARNING FOLLOWED IMMEDIATELY BY A "SERVICE BRAKE ASSIST" WARNING MESSAGE. IMMEDIATELY AFTERWARDS THERE WAS A TOTAL BRAKE FAILURE WHILE IN MOTION ON A HIGHWAY (APPROX. 50-60 MPH).

THERE WAS A "SERVICE BRAKE ASSIST" WARNING THAT FLASHED AND IMMEDIATELY AFTERWARDS THERE WAS A BRAKE FAILURE WHILE IN MOTION. THE BRAKE PEDAL WENT DOWN TO THE FLOOR AND WE WERE UNABLE TO STOP ON A CITY STREET.

ENGINE LOSES SAFE ACCELERATION WITH AIR CONDITIONING ON, REACHES UNSAFE STALL CONDITIONS.

AIR CONDITIONING NOT IN COMPLIANCE AND RUNS UP TO 20 DEGREES HOTTER THAN OTHER CARS AND COULD CAUSE HEALTH ISSUES TO DRIVERS IN HOT CLIMATE. DOES NOT COOL CAR EVEN IN OPTIMUM HIGHWAY DRIVING. ENGINE LOSES SAFE ACCELERATION WITH AIR CONDITIONING ON, REACHES UNSAFE STALL CONDITIONS. *TR

THE BLACK PLASTIC TRIM ON THE DOORS APPEARS TO BE "MELTING" OFF THE CAR. THE TRIM FROM THE TOP OF THE DOOR IS ACTUALLY DROOPING IN A MELTING APPEARANCE. CONTACTED MY DEALERSHIP AND THEY SAID THEY HAVE SEEN THIS WITH ALMOST EVERY SPARK THAT COMES IN FOR SERVICE; HOWEVER IT IS NO LONGER UNDER WARRANTY. THE CAR IS PARKED IN A GARAGE AND IS NOT EXPOSED TO EXTREME HEAT, ONLY NORMAL WEATHER CONDITIONS DURING THE DAY.