2002 CHEVROLET SUBURBAN Complaints

ANTI LOCK BRAKES ARE ACTIVATING ON THERE OWN WHEN TRYING TO STOP AND HAS ALMOST CAUSED ME TO CRASH 4 TIMES. I FINALLY PULLED THE ABS FUSE OUT THIS STOPPED IT BUT NOW I HAVE NO ABS IAM IN SOAP LAKE WASHINGTON IT SHOWS A RECALL BUT ONLY FOR A FEW STATES I BOUGHT MY SUBURBAN NEW IN BOISE IDAHO AND NOW RESIDE IN WASHINGTON STATE MY VEHACLE IS EFFECTED EXTREMELY BAD WITH THIS PROBLEM

PASSENGER FRONT BRAKE IS LOCKING UP WHILE VEHICLE IS IN MOTION. HAS CAUSED NUMEROUS BRAKE PAD REPLACEMENTS AND CALIPER AND ROTOR REPLACEMENT. HAS CAUSE SMALL FIRE.

CHRYSLER CANNOT FIND THE FUEL RAIL IN US OR CANADA. I CANT WALK AND HAD I NOT GOTTEN DISABLED AND HAD TO GO TO CANADA, AT FAMILIES DUE TO CHILD AND I BEING ASSAULTED AND INJURED. HAVE GOVERNMENT DOCUMENTS SHOWING WE ENTERED COUNTRY DUE TO STATEMENT ABOVE. CAR NOT USED, GARAGED FOR SEVERAL YEARS BUT TURNED ON PERIODICALLY SO CAR WOULD NOT DIE AND FLUIDS CHANGED. WOULD HAVE FILED THE LEMON LAW BACK THEN! I AM LOOKING INTO ARBITRATION ,FTC OR MEDIA. I HAVE CONTACTED MECHANICS FOR RECEIPTS AND TESTIMONY. DUE TO ENGINE LIGHT NEVER GOING OFF , AIR BAG LIGHT,AND GEARS WOULD SWITCH THEMSELVES AND ALL DIALS WOULD GO CRAZY ALL THIS WORK HAS BEEN DONE: NEW COMPUTER STARTER CATALYTIC CONVERTER EVAP LEAKS, CHANGED PARTS NO BREAKS WHILE DRIVING, BREAKLINE BROKE GAS CAP, SENSORS MUFFLER TIRES 4 NEW BATTERY PLUS, PLUS, PLUS NOW NO PART, FUEL RAIL DISCONTINUED. CAR CAN GO ON FIRE IF DRIVEN. CAR ONLY HAS 65,000 ORIGINAL MILED CHRYSLER CUST. SVC, TOLD ME TO SELL IT TO SOMEONE ELSE. FUEL RAIL DISCONTINUED , SO THEY WILL GO ON FIRE?? OR SELL FOR SCRAP? CARS ARE SUPPOSED TO LAST MORE THAN 65,000.THIS IS NEGLIGENCE AND U HAVE ENDANGERED MY FAMILY MORE THAN ONCE. MECHANIC SAID LUCKY , CANT DRIVE AT ALL. IN PKG LOT. CANT WALK, NEED CAR. TRADE IT FOR ONE OF SIMILAR VALUE AND MILEAGE. SPENT NEARLY 7,000. FIXING. NOW DISABLED AND DONT HAVE MONEY. ALSO EXPECT REFUND FOR RADIO RECALL.

NO WARNING LIGHTS ON THE DASH, BUT UPON BREAKING AT SLOW SPEED THE PEDAL EITHER PUSHES BACK OR THE BRAKES SLOW THE VEHICLE AT A FRIGHTENINGLY SLOW PACE, ALL WHILE THE ABS SYSTEM IS ON AS IF SLIDING ON ICE, BUT IT WAS AND IS DRY PAVEMENT. THIS HAPPENS 95 -100% OF EVERY BRAKING ATTEMPT. I HAVE TAKEN IT TO A LOCAL MECHANIC HE COULDN'T FIGURE OUT WHAT TO FIX SINCE THE COMPUTER CODES WERE BOUNCING ALL OVER THE PLACE. I SEE THIS IS A PROBLEM AFTER I HAVE DONE RESEARCH ON THE WEB. I PULLED THE MAIN ABS 60 FUSE UNDER THE HOOD TO TURN OFF THE SYSTEM. THIS CAUSES THE BREAK WARNING FAILURE LIGHT TO COME ON BUT I CAN AT LEAST STOP THE VEHICLE. THIS IS A FAILURE ON A SAFETY SYSTEM (ABS) THAT ACTUALLY CAUSES A SERIOUS SAFETY ISSUE...AS EACH STOP IS A POTENTIAL CRASH.

WHETHER IT'S IDLING OR DRIVING SHUTS OFF I REPLACED THE FUEL PUMP AND THE WIRING HARNESSES THAT COME WITH THE FUEL PUMP AND STILL NO AVAIL IT'S CAUSED A LOT OF TIME OFF OF WORK AND A LOT OF HEADACHE I WORK FOR A REPUTABLE DEALERSHIP I WORKED ON VEHICLES FOR OVER 40 YEARS

WHILE REPLACING THE RUSTED BRAKE LINES ON MY SUBURBAN (SEE TRACKING NUMBER 11066863), I NOTICED THE FUEL LINES GOING TO THE FUEL FILTER WERE ALSO TERRIBLY RUSTED. IT APPEARS THE RUST EMANATES FROM THE PLASTIC CLAMP THAT SECURES THE FUEL LINE TO THE FRAME. THE TUBE NUT THAT GOES INTO THE FILTER APPEARS TO BE FROZEN WITH RUST. SALT AND DIRT ARE TRAPPED IN THE PLASTIC CLAMP AND NUT, WHICH IS IMPOSSIBLE TO WASH OUT. THE FUEL LINES ON TOP OF THE FUEL TANK ARE LIKELY TO BE RUSTED, TOO.

BRAKE LINES RUSTED AND BRAKES FAILED TWICE WHILE DRIVING VEHICLE. THERE WERE NO ACCIDENTS. FIRST INCIDENT WAS THE REAR BRAKE LINE BURST. I REPLACED THE RUSTED BRAKE LINE. FRONT BRAKE LINE BURST 6 MONTHS AFTER REAR BRAKE LINE WAS REPLACED. ALL FRONT BRAKE LINES WERE SO RUSTED, I REMOVED AND REPLACED ALL OF THEM AS A PRECAUTION. THE BRAKE LINES RUSTED IN AREAS WHERE THEY WERE CLAMPED, SO THAT SALT AND DIRT COULD NOT BE CLEANED OUT. BRAKE LINES WERE UNPAINTED BARE STEEL.

TL* THE CONTACT OWNS A 2002 CHEVROLET SUBURBAN 1500. ON SEVERAL OCCASIONS, MAKING LEFT AND RIGHT TURNS AT LOW SPEEDS, THE CONTACT EXPERIENCED UNWANTED ANTI-LOCK BRAKE SYSTEM ACTIVATION WITHOUT WARNING. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT DIAGNOSED THE VEHICLE AND STATED THAT THE WHEEL SPEED SENSOR MOUNTING SURFACE ON THE BEARING NEEDED TO BE CLEANED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 05V379000 (SERVICE BRAKES, HYDRAULIC). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

BRAKES FAILED WHILE DRIVING 60MPH ON HIGHWAY I-476 (PHILADELPHIA PA) WITH THE FAMILY IN THE VEHICLE. UPON BRAKING TO STOP FOR TRAFFIC, THE BRAKE PEDAL WENT DIRECTLY TO THE FLOOR AND PUMPING THE PEDAL SEVERAL TIMES DID NOT RESULT IN ANY BRAKING OF THE VEHICLE. AFTER MANAGING TO GET THE VEHICLE TO A STOP ON THE SIDE OF THE ROAD, AND THEN PUMPING THE BRAKE PEDAL SEVERAL MORE TIMES, BRAKE FLUID COULD BE SEEN COMING FROM UNDERNEATH THE VEHICLE AT BOTH THE AREA AROUND THE REAR AXLE AND THE AREA UNDER THE DRIVERS SIDE SEAT. LATER, INSPECTION OF THE BRAKE LINES FOUND THEM ALL TO BE SEVERELY RUSTED. AFTER READING THAT THIS IS AN EXISTING PROBLEM WITH GM VEHICLES, IT IS GREATLY DISAPPOINTING, TO SAY THE LEAST, THAT NO NOTIFICATION OR RECALL WAS GIVEN. SUCH A SEVERE AND SCARY SAFETY PROBLEM SHOULD REQUIRE AT LEAST NOTIFICATION OF CUSTOMERS AND BETTER QUALITY DESIGN/CONTROL OF BRAKING COMPONENTS.

TL* THE CONTACT OWNS A 2002 CHEVROLET SUBURBAN. WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKE PEDAL PULSATED WITHOUT WARNING. THE CONTACT DEPRESSED THE BRAKE PEDAL TO THE FLOOR TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE FAILURE DID NOT RECUR. THE FAILURE MILEAGE WAS APPROXIMATELY 220,000.