2021 CHEVROLET SUBURBAN Complaints

While driving the Engine warning light, service ESC light, and collision light all came on and an engine knock started. I also experienced a loss of power at the same time. Car was taken to local Chevy dealership for evaluation and repair. Dealership advised that they dropped the oil and found metal shavings in the oil. After further investigation, we were advised that it was a crankshaft connecting rod failure. We have an extended warranty and were waiting to hear back on repair coverage. GM denied the repair as this vehicle is not part of the active recall. Our warranty company also denied the repair stating we did not have adequate records of oil changes. Receipts for oil and filters were provided.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 35 MPH on the highway, the vehicle stalled. The contact pulled over to the side of the road. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired out-of-pocket. The contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that the VIN was not under recall. The failure mileage was approximately 92,000.

Rear Axle is grinding. Took vehicle into dealer and it is the well documented rear axle issue but this vehicle is not included in a recall. The differential fluid was replaced and figure 8s were done but there is still grinding. The rear axle also drags at times when in auto 4wd. The dealer said the next step would be to replace the axle. This is the issue: Differential Noise/Failure: Reports indicate a rubbing noise while turning, often attributed to the rear differential. In some cases, the entire rear differential has required replacement.

In April of 2022 with 26k miles my vehicle had its first engine failure, Chevrolet dealership had to replace engine lifters due to a known engineering defect with the 2021 6.2 L87 engine. Now in late February 2026 with 80k miles my engine has locked up and requires a brand new engine replacement. For some reason, even though this is a L87 6.2L 2021 engine it is not part of the broader recall for this exact same engine failure for the same engine year and model.

While driving, the engine malfunctioned. There were no warning lamps, messages, or other symptoms prior to the malfunction. The vehicle has been inspected and repaired by a Chevrolet dealership.

The check engine and traction control light came on in my car. This was accompanied by a clanking sound, shaking. The panel said “ SERVICE ESC” “ service traction control” and “ forward collision system unavailable” The Chevrolet light logo on the back of my car will also not turn off occasionally whenever the car is turned off.

My [XXX] Daughter lost the ability to put the vehicle in reverse while running errands on a Saturday. We had to push the truck out of the parking spot "backwards" in neutral in order to get the vehicle in a position to put it in "drive". She had been going in and out of shopping centers (forwards and backwards) earlier when the reverse suddenly stopped. I dropped the vehicle at a nearby auto shop in a fit of desperation (maybe 1/2 mile away). They told me they thought the transmission was shot, so I picked it up and took it to Andean Chevrolet (Dealer) in Cumming, GA. While driving it to Andean on Tuesday (2/17), the transmission went into low acceleration mode where I couldn't go into upper gears and topped-out at 3,500 rpm's max for the 13+ miles (30 min) drive. Andean confirmed on Friday (2/19) that the entire transmission is shot with metal all inside of the fluid, gears being broken, and the valve body being broken. The truck is 5.5 years old with 93K mile on it and we were just shocked. The repair for GM Reman transmission was quoted at ~$9.2K and we just finalized a call directly with GM Customer Service to see if GM would offer any discounts to the Dealer on the repairs. We are still waiting on that result while the repairs are being made. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving 45 MPH, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended, and the vehicle decelerated unintendedly. Additionally, the vehicle failed to exceed 42 MPH. Later in the day, the gear shifter was shifted to reverse; however, the vehicle failed to reverse as intended. The vehicle was taken to the dealer, where it was diagnosed with transmission valve body failure. The contact was informed that the transmission valve body needed to be replaced. The vehicle was repaired. The contact stated that the vehicle was at the dealer from December 2024 until June 2025. The vehicle was picked up from the dealer. The contact stated that while driving at an undisclosed speed, the engine seized and failed to restart. The vehicle was towed back to the dealer, where the contact was informed that the fuel pump had failed, and the battery was drained. The contact was informed that the battery and the fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 35,000.

Engine failure at 86,000 miles with documented regular oil change and recommended services

My vehicle was taken in to shop due to recall recommendation I received in GM app for fuel pump control module . After repair was done my engine begin ticking the same day and failed a week later . I documented the whole thing and filed a claim with GM however the dealership that did the repair are not responding to GM . The dealership is alm Chevorlet south in Jonesboro ,GA this vehicle stalled out while I was on the highway . Please help me this vehicle belongs to my limo fleet and this is detrimental to my business . After multiple attempts to get it diagnosed they kept telling me I had to wait in line for weeks out to get it checked out although the problem arose after the new part installation . Then when I brung it back with failed engine soon after they told me that I had to sign a liability release waiver for them to check out the vehicle stating that the vehicle was high mileage and not their fault . The service manager literally instructed me not to leave my vehicle when I wanted to because it would not speed up the process for it to be seen I brung it back when instructed but it was to late because the engine had already failed . They literally forced me to sign a waiver stating that they wouldn’t diagnose it if i didn’t sign the waiver . These people are committing a fraudulent scam and their are unsafe vehicles on the road that arent being treated properly due to these practices . Please contact the dealership and or GM to take this matter more seriously .