1999 CHEVROLET SUBURBAN Complaints

EXHAUST MANIFOLD BOLTS BREAKING LEAVING STUDS IN THE HEADS, HEATING UP ENGINE COMPARTMENTS, RELEASES CARBON MONOXIDE, AFFECTS O2 SENSOR AND CATALYTIC CONVERTER. WILL NOT PASS EMISSIONS IN SOME STATES. GM NOT STANDING BEHIND THIS 1999-2008 ISSUE. IT IS A SAFETY ISSUE AND IS EXPENSIVE TO FIX. GM MECHANICS DENYING ANY SUCH ISSUES. PLEASE CHECK- IN TO THIS. OUR WHOLE FLEET AND OUR PERSONAL TRUCKS AFFECTED BY THIS. *TR

I WAS DRIVING MY SUBURBAN AND THE PEDAL WENT TO THE FLOOR. THE BRAKE WARNING LIGHT CAME ON. I TOOK IT INTO AN INDEPENDENT MECHANIC AND HE SAID ALL OF THE BRAKE LINES WERE CORRODED AND THAT ONE OF THEM HAD BURST. *TR

BRAKE LINE RUNNING FROM FRONT OF VEHICLE TO REAR ON DRIVER SIDE COMPLETELY RUSTED THROUGH. FUEL LINE FITTINGS ARE JUST AS BAD. FITTINGS ON REAR A/C WENT UP OVER THREE YEARS AGO, HAVEN'T HAD AC. *TR

AT 45 MPH FIRESTONE P235/75R15 MODEL FR380 TIRE BLEW OUT ON THE PASSENGER FRONT. *TT

TL* THE CONTACT OWNS A 1999 CHEVROLET SUBURBAN. THE CONTACT WAS DRIVING 10 MPH WHEN THE BRAKE PEDAL WAS DEPRESSED INTO THE FLOORBOARD ABNORMALLY AS THE ENGINE STARTED TO SMOKE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 146,774. UPDATED 06/29/12 *BF THE CONSUMER STATED THE SMOKE WAS A RESULT OF BRAKE FLUID SPRAYING FROM THE BRAKE LINE. UPDATED 07/09/12

TL- THE CONTACT OWNS A 1999 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE FUEL PUMP WIRE FAILED AND THE VEHICLE WOULD NOT START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE VEHICLE WAS REPAIRED UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 05V155000 (FUEL SYSTEM: GASOLINE: DELIVERY: FUEL PUMP). THE DEALER ADVISED THE CONTACT THAT THE FUEL PUMP WIRE WAS AN UPDATED VERSION. THE FAILURE MILEAGE WAS NOT AVAILABLE. KMJ UPDATED 01/25//12 *BF UPDATED 01/27/12

TL* THE CONTACT OWNS A 1999 CHEVROLET SUBURBAN K1500. THE CONTACT STATED THAT THE REAR BRAKE LINES WERE CORRODED, CAUSING HIM TO LOSE FLUID TO THE REAR BRAKES. AFTER INSPECTION, HE ALSO NOTICED THAT THE FRONT BRAKE LINES WERE WEARING PREMATURELY. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT DIAGNOSED THE VEHICLE AND PERFORMED THE REPAIRS. THE CURRENT AND THE FAILURE MILEAGES WERE 121,000. UPDATED 12/29/11 *BF THE CONSUMER STATED HE EXPERIENCED LOW SPEED ANTI-LOCK BRAKE FAILURE AS DESCRIBED IN THE RECALL. UPDATED 02/29/12

I STARTED UP MY 1999 CHEVY SUBURBAN IN MY DRIVEWAY THIS AFTERNOON AND THE BRAKE PEDAL WENT TO THE FLOOR. I OPENED THE HOOD AND NOTICED BRAKE FLUID SPLATTERED ALL OVER THE AREA BELOW THE MASTER CYLINDER AND ALL OVER THE GROUND. I DISCOVERED THAT THE LINE TO THE LEFT FRONT WHEEL RUSTED TO THE POINT OF FAILURE. I CHECKED THE OTHER BRAKE LINES AND THEY ARE BADLY CORRODED. THIS TRUCK HAS NEVER LEFT ME STRANDED IN 13 YEARS. I DO NOT WANT TO SEE IT GO, BUT THIS MAY BE THE END. ALSO, A LITTLE OVER 1 YEAR AGO, I SOLD MY 2005 TAHOE TO A MAN WHO TOLD ME HE HAD A 1999 TAHOE. HE WAS BUYING MY TAHOE BECAUSE THE BRAKES LINES ON HIS HAD CORRODED AND RUPTURED. HE WAS CAREFUL TO CLIMB ALL AROUND AND UNDER MY TAHOE TO CHECK FOR BRAKE LINE CORROSION BEFORE BUYING. I JUST RESEARCHED THIS PROBLEM, AND IT APPEARS TO BE COMMON. MANY OF THESE TRUCKS ARE STILL ON THE ROAD. HOW MANY WILL HAVE TO BE KILLED BEFORE ANYTHING IS DONE ABOUT IT? *TT

TL* THE CONTACT OWNS A 1999 CHEVROLET SUBURBAN. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START WHENEVER THE ANTI-THEFT SECURITY SYSTEM FAILED. THE DEALER REPLACED THE PASS LOCK MODULE, BUT THE FAILURE CONTINUED. THE CONTACT STATED THAT WHENEVER THE SECURITY LIGHT ILLUMINATED, THE VEHICLE WOULD NOT START FOR APPROXIMATELY THREE HOURS. THE FAILURE OCCURRED INTERMITTENTLY. THE FAILURE MILEAGE WAS 107,000 AND THE CURRENT MILEAGE WAS 126,000. THE VIN WAS NOT AVAILABLE.

WHEN PUTTING MY FOOT ON THE BRAKE PEDAL AFTER STARTING THE CAR AND BEFORE SHIFTING INTO REVERSE, THE PEDAL WENT TO THE FLOOR SUDDENLY. I PUMPED THE BRAKES AND NO IMPROVEMENT WAS FELT, I THEN CHECKED UNDER THE HOOD AND FOUND THAT THE STEEL BRAKE LINE BETWEEN THE LEFT FRONT RUBBER BRAKE LINE AND THE ABS UNIT HAD RUSTED OUT AND WAS SQUIRTING BRAKE FLUID WHEN THE PEDAL WAS DEPRESSED. *TT