2021 CHEVROLET SUBURBAN Complaints

The contact owns a 2021 Chevrolet Suburban. The contact stated that while in reverse (R), the vehicle failed to reverse as intended. The contact’s wife continued driving at approximately 55 MPH, and an unknown message was displayed, and the vehicle failed to exceed 55 MPH. Additionally, the transmission was stuck in gear and failed to upshift into the next gear as designed. The vehicle was pulled over to the side of the road, and the battery was disconnected and reconnected, but the message remained displayed. The vehicle was towed to an independent mechanic, where it was determined that the transmission control valve needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 81,600.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while driving at various speeds, an abnormal oil consumption was noticed. No warning light was illuminated. In addition, the vehicle was previously taken to a local dealer, where an oil consumption test was performed; however, the contact was advised to bring the vehicle back for further investigation. An appointment with the same local dealer was scheduled to inspect the vehicle. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 60,000.

My vehicle is having an oil consumption problem. 2 quarts were missing from my oils consumption test. The dealer is now doing a secondary oil consumption test and I’ve read up and learned that there have been a lot of recalls with the engine and oils changes.

There is an electronic problem that continues to trip the warning for the Air Ride suspension system to fail leaving the vehicle stuck at its current ride height or it drops eithee the front or rear suspension to the ground while simultaneously raising the front or rear to its highest setting. It also causes the vehicle speed to drop immediately to 56 mph. Issue has been scanned by several dealers to determine air leaks, pinched wires, failing compressor and all were found to be in normal operation. This is a huge safety concern as well as a huge financial concern for the consumer.

My 2021 Chevrolet Suburban stalled while driving in late September 2025 and had to be towed to a dealership. The vehicle is subject to an active fuel pump power control module safety recall that has been in effect since 2021. The vehicle was brought in specifically for repair of this issue. The work was processed under warranty, and I was charged a deductible. After learning the repair was directly related to an active safety recall, I requested reimbursement of the deductible, as recall repairs should be completed at no cost. That reimbursement request was denied. I have since been informed that the recall repair was never “completed,” and the recall still shows open in the manufacturer’s system. I am now experiencing shuddering and symptoms consistent with a potential stall recurrence. The original stall occurred while I was transporting my children, including special needs children who require regular transportation to school and therapies. The vehicle failure left us stranded at night in an unsafe area. Due to the prior stall, the unresolved recall status, and the recurrence of symptoms, I do not feel the vehicle is safe to operate. Thank you for your attention to this matter, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The front of the fuel tank is hanging down and nearly dragging on the ground. This was with normal driving on a highway. No hitting bumps or aggressive off-road anything. We noticed when we heard a scraping noise going slowly over a slight incline in a driveway that it was hanging down.

After purchasing the car, the engine oil low light came on after driving about 2,000 miles on a fresh oil change. We took the car to the Chevrolet dealer where they said the engine was over 2 quarts low on oil and recommended a fresh oil change. After another 2,000 miles of driving the low engine oil light came on again. We took it back to the same dealership and started the oil consumption test. After several months of oil checks, it was determined that the engine failed the test and service was recommended and would be covered under warranty. Extensive repairs were performed on the engine including piston replacement. After receiving the car back from repair, we continue to have the engine oil low life light appear after a few thousand miles of driving and have to add 2 quarts of oil to the engine. We contacted the Chevrolet dealership that performed the repairs and they said that prior warranty work would not be covered since we were now out of factory warranty. We were informed that we would have to go through the oil consumption test again and pay for any needed repairs. We're concerned that with investigation EA25007, our engine could experience the bearing failure and cause serious injury.

On January 13, 2026, the engine in my Suburban failed suddenly and completely, rendering the vehicle inoperable without warning. The failure left me stranded with my children, creating a serious safety concern and requiring immediate towing. Prior to that day, the vehicle exhibited no ongoing symptoms, warning lights, or performance issues, aside from a ticking noise that appeared only on the day of failure. The vehicle was towed to an authorized Chevrolet dealership, where it was determined that the engine was damaged beyond repair and required full replacement. I was informed a new engine would need to be ordered, at an estimated cost of approximately $14,000—an extraordinary and unreasonable expense for a vehicle of this age and price point.

Engine is running low on oil all the time. took it to dealer they said, there is sludge build up. Found oil fouling on CYL 3 and and found Spark plugs with excessive oil no external leaks found recommend new engine

The car was driving at 60 MPH on a regular commute to work and the car was stalling and shaking and soon after the check engine light came on with multiple issues.