2021 CHEVROLET SUBURBAN Complaints

On 7/26/2025 approximately 8:30pm (PDT), driving south on CA I-880 in third lane from right traveling at approximately 50mph when vehicle engine died and went into neutral gear. Dashboard alert indicated to press start engine button, but would not start. Managed to maneuver vehicle to right shoulder amid rush hour traffic. Fortunately, a CA Highway Patrol officer saw us and was able to render assistance. Vehicle would not restart or go into neutral after several attempts to restart engine. Special tow vehicle was called to give us a tow home. This incident happened after we received a Chevrolet recall notice back in May or June about the engine and did take the vehicle in for service on 6/10/2025. The dealership service recommended using higher weight oil and it would help mitigate any potential issue. Obviously, this was not the case. We were very fortunate to avoid any serious injury or damage on the highway due to engine failure.

The contact owns a 2021 Chevrolet Suburban. The contact stated that the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, where the map sensor was replaced; however, the failure persisted. Additionally, the vehicle failed to start. The vehicle was towed to another mechanic, where it was diagnosed and determined that the fuel pump sensor module had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in a recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 62,000.

My wife was driving the vehicle and was pulling into a parking lot. The brakes failed and would not stop the vehicle. She pressed on the brakes very hard, multiple times, for several seconds, before the vehicle finally came to stop. She then proceeded into a parking spot where the brakes again failed to stop the vehicle promptly. Several lights illuminated and a “System Brake Failure 43 MPH Top Speed” message appeared, alternating with several other messages appearing. The vehicle is in for service at Classic Chevrolet in Granbury, Texas. They are telling me that they reset the codes and that the codes are not returning. I am extremely concerned that if I pick up the vehicle at this point, the brakes could fail again and cause an accident with serious injury.

There is an issue with the transmission when i accelerate at a slow pace. The car shakes and vibrates. Theres a possibility of an issue with the transfer case 4x4. When i turn the steering wheel and drive, it feels like it locks. It feels like 4x4 is on and theres a odd sound as well. I took my car to Hamilton Chevrolet and paid for inspection. They told me that there was no issue, but the issues i mentioned earlier in this message was mentioned to them. Those issues are still occurring. This is a recall issue but when i put my VIN number in, my car shows that there is no recall on it. There was many people who mentioned this problem.

Vehicle lost power, debris in cylinder from internal damage, crank case leaking air, oil leaking into cylinder, P0300, P0308, and P050D

What component or system failed or malfunctioned, and is it available for inspection upon request? Fuel pump How was your safety or the safety of others put at risk? Yes, vehicle stopped unexpectedly and and wasn’t accelerating Has the problem been reproduced or confirmed by a dealer or independent service center?no Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?no

The vehicle started rumbling/vibrating/shaking when getting up to speed and at a consistent speed. Brought to an independent service center and was old that the torque converter is failing. No warning lamps or other problems prior to rumbling/vibrating that started on 5/22/25.

The contact owns a 2021 Chevrolet Suburban. The contact stated that the vehicle was listed under the application TURO. The contact stated that a person rented the vehicle and informed him there was an abnormal sound coming from the engine. The contact test drove the vehicle, and while driving 30 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The check engine warning light illuminated, and the contact heard an abnormal sound coming from the engine. The vehicle was towed to an independent mechanic, who diagnosed the vehicle and determined that the lifters, push rods, and two valves, and cylinder 6 had failed and needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the independent mechanic; however, no cause for the failure was found. The independent mechanic stated that the vehicle was consuming an excessive amount of oil and in cylinder #1, the lifters had failed. The vehicle was repaired; however, the failure persisted. The vehicle was taken back to the independent mechanic and was diagnosed with oil intrusion into the bank covers and piston damages. The vehicle was repaired for the most recent failure. The manufacturer was not contacted. The failure mileage was approximately 107,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? -My engine started to make a loud ticking and knocking noise. I brought it into Good Chevrolet in Renton WA 6/3/25 where they told me there is an “internal engine failure due to failure of the lifters.” When I asked the dealership for the repair estimate so I could possibly have a second opinion, they said they were “not comfortable giving their information and the problem in writing.” They refuse to give us any documentation but were insistent that even though NHTSA has issued a mass recall for this exact same issue on the larger engine in my same year of vehicle, “it’s unrelated.” How was your safety or the safety of others put at risk? -The engine is failing and had we not brought it in for diagnosis, I could have had full engine failure while driving with my children and been in a catastrophic crash. Has the problem been reproduced or confirmed by a dealer or independent service center? -Yes the problem can be reproduced and has been confirmed by Good Chevrolet. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -Good Chevrolet inspected the engine but refuse to give us documentation though they had us file a claim with GM (I will attach the claim email) Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? -I noticed a small noise after I had fans replaced in September but the noise gradually increased so it was brought in for diagnostics. There were no warning lamps or messages.

The contact owns a 2021 Chevrolet Suburban. The contact stated that while his wife was driving at undisclosed speeds, there was an abnormally loud banging sound coming from the engine compartment. The contact stated that the failure was related to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). There were no warning lights illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the rods were bent, and the lifters needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The contact called the warranty company, who confirmed there was no repair coverage on the vehicle for the failure. The failure mileage was approximately 109,069.