2002 CHEVROLET SUBURBAN 1500 Complaints

3RD FAILURE OF THE INTERMEDITE STEERING SHAFT ON THE 2002 CHEVROLET 1/2 TON SUBURBAN. *AK

KNOWN PROBLEMS WITH A/C COMPRESSOR ON 2002 SUBURBAN/TAHOE WITH REAR A/C. DEFECTIVE SYSTEM CAUSES LOUD CHATTER IN BELT TENSIONER DUE TO SLUGS OF LIQUID REFRIGERANT BEING PUSHED INTO THE COMPRESSOR. PROBLEMS FREQUENT ENOUGH FOR GM TO HAVE ISSUED TSB #01139B BUT GM REFUSES TO ISSUE A RECALL ON THIS OBVIOUS DEFECT. LITERALLY THOUSANDS OF COMPLAINTS ABOUT THIS DEFECT ARE DOCUMENTED ON THE INTERNET. *TR

I PURCHASED A NEW 2002 SUBURBAN. MY INTERMEDIATE STEERING SHAFT HAS BEEN REPLACED/REPAIRED AT LEAST 5 TIMES SINCE I DROVE IT OFF THE SHOWROOM FLOOR. THE INTERMEDIATE STEERING SHAFT HAS BEGUN TO MAKE NOISES AGAIN, INDICATING IT IS TIME FOR YET ANOTHER SERVICE TRIP. *NM

I WAS UNABLE TO HAVE MY 2002 SUBURBAN INSPECTED. THE PARKING BRAKE BAND ON THE DRIVERS SIDE HAD TO BE REPLACED AS WELL AS THE BRAKE DRUM THIS DECEMBER. MY VEHICLE ONLY HAS 92K MILES. MY FATHER-IN-LAW HAS THE SAME YEAR/MAKE VEHICLE AND HE HAD TO HAVE HIS PARKING BRAKE REPLACED, BUT ON THE PASSENGER SIDE. HIS VEHICLE ONLY HAS 76K MILES. CHEVROLET HAS A SERVICE BULLETIN OUT THAT THIS MODEL VEHICLE IS PRONE TO THIS PROBLEM, YET WILL NOT TAKE RESPONSIBILITY FOR REPAIRS OR REPLACEMENT. *NM

ON MULTIPLE OCCASIONS MY 2002 CHEVROLET SUBURBAN STALLED WHILE DRIVING ON THE FREEWAY. AFTER SEVERAL MINUTES THE TRUCK WOULD RESTART. THE CHEVY DEALER SAID THERE WAS NOTHING THEY COULD DO SINCE THEY WOULD NOT BE ABLE TO DUPLICATE THE CONDITION. IT DOES NOT TRIGGER A CHECK ENGINE SIGNAL. IT USUALLY HAPPENS AFTER LONG PERIODS OF FREEWAY DRIVING WITH NO WARNING. THIS IS NOT A LOW FUEL ISSUE. I SUSPECT IT IS A CRANK POSITION SENSOR FAILING AFTER RESEARCHING THE ISSUE ON THE INTERNET. *JB

TL* - THE CONTACT STATES THAT WHILE DRIVING AT NIGHT BOTH SIDE VIEW MIRRORS CREATE A DOUBLE-VISION. PER THE CONTACT THIS CAUSES HER NOT TO BE ABLE TO USE HER SIDE VIEW MIRRORS. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP AND THEY TOLD HER THAT THERE HAVE BEEN COMPLAINTS IN THE PASS REGARDING THE SAME ISSUE.

THIS IN REFERENCE TO A CLOSED NHTSA ACTION # DP05009. AFTER A PARKING BRAKE FAILURE THAT OCCURRED ON THIS 2002 CHEVY SUBURBAN WITH 54,000 MILES ON IT, IN NOVEMBER, I LOOKED INTO SIMILAR SITUATIONS WITH OTHER SUBURBAN OWNERS AND OF THE 3 I FOUND, 2 IN SOUTH CAROLINA, AND ONE IN INDIANA, ALL HAD SIMILAR PARKING BRAKE PROBLEMS. WHEN I BROUGHT MY VEHICLE TO THE DEALER FOR REPAIR, I WAS TOLD THERE WERE NO RECALLS OR SAFETY NOTICES REGARDING THIS PROBLEM. AFTER REVIEWING YOUR NHTSA SITE, I SEE THAT THIS PROBLEM WAS ADDRESSED AND CLOSED BUT ONLY APPLIED TO VEHICLE WITH MANUAL TRANSMISSIONS, EVEN THOUGH THE PROBLEM WAS IN AUTOMATIC MODELS TOO, WHICH WAS APPARENTLY GLOSSED OVER BECAUSE OF THE PERCENTAGE OF ROLL AWAY INCIDENTS. THIS PROBLEM IS STILL OUT THERE, AND CHEVY DENIES IT. CHEVY NEEDS TO ACKNOWLEDGE THIS AS A SERIES WIDE PROBLEM AND FIX IT ON A RECALL BASIS. THE INSULTING THING ABOUT THIS IS THE DEALERSHIP ACTS LIKE IT IS SOMETHING NEW, AND PERHAPS I WAS LEAVING THE PARKING BRAKE ON ALL THE TIME. IT IS NOT NEW, AND I HAVE NEVER DRIVEN AWAY WITH THE PARKING BRAKE ON IN MY LIFE. AND WE WONDER WHY THE AMERICAN AUTO INDUSTRY IS FAILING TO ATTRACT CUSTOMERS. *JB

WHILE DRIVING ON THE HOUSTON TOLLWAY AT 65 MPH, MY 2002 SUBURBAN SUDDENLY AND WITHOUT WARNING LOST POWER AND THE ENGINE SHUTDOWN. I MANAGED TO GET THE VEHICLE ONTO THE SHOULDER WITHOUT INCIDENT AFTER ATTEMPTING TO RESTART THE ENGINE WHILE TRYING TO STEER CLEAR OF TRAFFIC. THE VEHICLE WOULD NOT START AND WAS TOWED TO LONE STAR CHEVROLET IN HOUSTON, TEXAS. THE BILL WAS 1045.10. THEY REPLACED THE FUEL MODULE AND THE FUEL FILTER AND TOLD ME THAT THERE HAD BEEN SOME PROBLEMS WITH GM VEHICLES DATING BACK TO 1999 MODELS ON THE SAME PROBLEM. MINE HAD ONLY 70158 MI. I THINK GM SHOULD REIMBURSE ME FOR THE COST OF REPAIR. I TALKED TO A CUSTOMER WHO HAD A SIMILAR PROBLEM ON HIS 1999 GMC SUBURBAN AND THEY FILED A COMPLAINT WITH GM AND WAS REIMBURSED FOR THE REPAIR. FAIR IS FAIR AND I EXPECT NOTHING LESS FROM THEM. *JB

GOOD YEAR TIRE FAILURE. BUBBLING OCCURRING ON INTERIOR SIDE WALLS. CUPPING ALSO OCCURRING. I HAVE HAD 9 GOOD YEAR TIRES IN FOUR YEARS ON MY 2002 CHEVROLET SUBURBAN. *JB

WAS PULLING A TRAVEL TRAILER WHEN THE STOCK HITCH RECEIVER BROKE OFF CAUSING ME TO LOSE CONTROL OF MY VEHICLE, CAUSING A DEATH, AND MULTIPLE INJURIES TO THE WHOLE FAMILY. VEHICLE WAS TOTALED. *JB