2020 CHEVROLET TAHOE Complaints

Lifter failed on my Chevy Tahoe 6.2L engine at ~75K miles in September 2025. One lifter bank was replaced. No reason for lifter failure was given. Less than 5 months later the other lifter bank has failed and damaged the cam shaft. Again, no reason for failure was provided. Failed lifters can cause catastrophic engine failure, which is incredibly dangerous when the vehicle is in motion. No check engine lights or and warnings occur with the lifter failure, it is only identified by the driver through the tapping noise from the engine. Even a cursory review of forums and complaints reveals that lifter failure is widespread on this engine and that manufacturing defects have caused issues with this power train dating back to 2019, not just the recalled 2021-2024 models.

I sent this to GM Corporate on 2/12/2025: I'm writing regarding the recall on certain 2020 Chevy Tahoe transmissions. My husband is meticulous with his vehicles including all regular service updates and recommended appointments. It literally looks like it came off the showroom floor 5 years after buying it. Unfortunately, when returning on a trip our vehicle suddenly increased rpm's and wouldn't respond while going 65 miles per hour. Thankfully, it reengaged, and we were okay but imagine what could have happened! We managed to get it home, but while attempting to back up it wouldn't shift. We had to have it towed and have been told our transmission is SHOT! It will cost us over $7000 to replace?!! We attempted to call the GM customer service number to Complain and see if they could provide some help. They put us in touch with a service manager in our area whose voicemail was full and took a week to connect with. She basically said there is nothing she can do as it is within the 5 years but over on miles. So, here we sit with a vehicle we have babied for 4.9 years that needs a new transmission. I am asking for you to listen. Asking for you to expand the investigation/recall to include ALL 2020 (or related) vehicles. Something isn't adding up, and you are leaving customers who have paid off their $60,000 vehicle stuck with more $$ to pay because of an about defect. This could have killed us. It literally froze while we were driving, and now we are without a vehicle waiting for a new transmission. We have never had issues with the transmission before. How does a transmission just go? Definite defect!

We have the L86 6.2L EcoTech 3 Engine. at 85,000 miles we noticed the oil pan is leaking and rear main seal is leaking. Both are common issues with the L87 engine as well.

On multiple occasions, my car has locked my keys on the INSIDE of the vehicle. I have put things inside my vehicle before leaving and closed all the doors, upon returning, even just a few minutes later, my doors are locked and I am locked out of my vehicle. Additionally, my car is not detecting my remote. I cannot unlock my car with the buttons on the door and need to have my keys in hand for my car to detect the fob. Additionally, if someone opens the door while the car is running but in park, and then closes the door, the Car will beep as if there is no longer a remote detected. This has happened on multiple occasions. I have changed the batteries in the fobs multiple times, switched out my fobs so I was using a different fob and it has happened with both of my fobs.

The contact's brother owned a 2020 Chevrolet Tahoe. The contact stated that while his brother was driving at an undisclosed speed, the vehicle crashed; however, the contact was unsure what the vehicle had crashed into. The contact stated that the crash was a single vehicle crash and there was severe damage to the front of the vehicle. The contact stated that the air bags should have deployed but failed to deploy. The contact stated that medical attention was needed, and his brother was currently in the Trauma ICU after recently having back surgery. The contact stated that a Police Report was filed but was not yet finalized. The contact was waiting to speak with the Police Officer who filed the report. No further information was available. The failure mileage was unknown.

I was starting to accelerate to a higher level of speed onto the highway; 55 mph going up a hill. I was unable to accelerate much as I pushed on the gas, however the RPM's would get higher. while I was at 45 mpg the RPM's were at 3.5. All of sudden my service engine light came on. I knew something was wrong. Turned around took my car back home very slowly, had my husband come look at my car, who has mechanical experience. Transmission fluid is dark and gritty; when its suppose to be a red in color and smooth. I am now needing to replace a transmission in a vehicle that is 5 years old. How is this possible? I have owned the car for 2 years. Why has these not been recalled yet? Why has these not been looked into further? We are paying a lot of money for these vehicles to turn around and put a new transmission, which isn't cheap into a vehicle that is 5 years old. Any assistance to look into these complaints would be very helpful. I am just glad no one was hurt and I was able to get my vehicle home safely. I keep up with all of the routine maintenance of this vehicle on a regular basis.

I was driving in traffic with 8 kids from my football team on a busy street and my truck start jerking and wouldn’t accelerate much. I was going 35 mph and the truck just slows down in the middle of driving. Then as I pulled over thick white smoke comes from the tail pipe. Thank god it was a Sunday and the busy street wasn’t as busy and I was able to pull over safely because this happen while I was driving. I got the truck to autozone and they gave me a misfire code in cylinder 1. I sent my truck to dealership and spoke with them on the phone and they was able to tell me everything going on with my truck without even having to tell them all the issues happening. They looked at the truck and said I had an internal engine issue. I was advised this a well known problem with my type of truck. I reached out to Gm and asked them why haven’t it been a recall on my truck if this is a well known issue with my vehicle after talking with many mechanics. No answer was specifically provided. I’ve been trying to get them to do what’s right and repair the engine but I’m getting the run around. I’ve reached out to over 5 mechanics and a shops and have been told this is a well known problem was trying to see the cost. Once I found out this was well known it made me contact General Motors. I don’t think it’s fair this is a known issue with 5.3L engine and it hasn’t been a recall. It is unsafe to be driving and the engine just fails on you in the middle of traffic. What if I was on the freeway? My truck is at a Gm dealership right now and Gm and the dealership is refusing cost assistance on a well known engine failure problem. These vehicles need a recall on them that would of been 9 lives at risk because this problem hasn’t been addressed by the manufacturer it was scary when it happen because I was on a busy street.

While driving toward intersection, light changed to red. Applied pressure to brake pedal and pedal became extremely difficult to press. Vehicle was not slowing as expected with pedal pressure becoming very hard to press to slow vehicle. Warning on dash "Brake Assist" and Chevrolet app displays "Antilock Braking System" and text that states Schedule service now. If my wife would have been driving, this would have caused an accident. This is extremely dangerous condition that must be addressed with a corrective action taken by the manufacturer.

Driving long distance from Florida to New York and in VA, experienced a check engine light after fueling. Vehicle started, stalled and trembling excessively. It was taken to the Chevrolet dealership across from the gas station (total luck). It was diagnosed after 1 day in the shop that all 8 fuel injectors and the two fuel rails were corroded and had snapped upon inspection.( photos were sent to me). Vehicle could not be driven. If stall would have occurred while driving on the interstate at speed of 70 -75 mph, the potential for a major car accident with other fast moving vehicles was totally possible. I had to remain in a hotel for 3 days as the dealer had indicated that the parts were on back order because this was a recurring issue in the Tahoe/Suburban/Silverado L87 6.2 HP engine. I rented a vehicle to drive back to NY and got my truck back 14 days later after paying for it ($4600) as GM stated that they could not honor the 5 year/60K warranty despite my truck having 52, 182 miles and less then 5 years because they went by the build date of the vehicle which was March 14, 2020 to March 14, 2025, not the calendar year.

Creaking and groaning from rack and pinion. 60,000 miles on vehicle. no other issues. Potential steering system failure. No warning lights. Happens at all speeds.