2021 CHEVROLET TAHOE Complaints

My vehicle is experiencing the same issue with the Third Row Headrests as outlined in a prior service bulletin (N202316750) for the same model year and make vehicle. My VIN number was not included in the bulletin, but I believe it should have been. The passenger side third row headrest will no longer stay up when the seat is engaged.

The contact owns a 2021 Chevrolet Tahoe. The contact stated while making a right turn, the vehicle lost automotive power. No warning light was illuminated. The contact stated that the transmission was stuck in park(P). The vehicle was towed to a local independent mechanic and was diagnosed with fuel module failure. The contact was informed that the fuel module needed to be replaced. The vehicle was taken to a local dealer where it was diagnosed at the owner’s expense. The vehicle was not repaired due to the cost. Upon further investigation, the contact related the failure to NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 80,000.

Approximately 4/14/24 while I was driving home from being out of town with my child the check engine light came on with a message “Reduced acceleration drive with care.” The car was not shifting and I couldn’t go over 45 mph and the rpm’s were about 3000 at that speed. The light went off and the car seemed to be driving normally. While on the interstate traveling at approximately 70 mph the car did a hard shift and drastically slowed while the rpm’s spiked. I took it to the dealership who determined the valve body needed to be replaced. Approximately August 2024 it happened again but the light went off. December 2024 same issues with the check engine light, reduced acceleration and not shifting happened. Took the car back 12/9/24 where a wire was replaced. Picked the car up 12/12/24 and 12/18/24 while driving in the car rider line picking my child up the car had a hard shift, check engine light came on, reduced acceleration message and the car would not shift. Notified the dealership immediately and took it back 12/26/24 where they did a second valve body replacement. 1/28/25 on my way home from running errands and was stopped at a red light and the car shifted hard, check engine light came on, reduced acceleration message and engine would not shift causing me to drive slowly to get home (40 mph or less). Dealership was notified immediately and took in the following day. Dealership had a week and had me pick it up because they “couldn’t replicate the issue.” 2/15/25 after driving 2 hours we pulled in a parking lot and the car shifted hard hard, check engine light came on, reduced acceleration and would not go into reverse. The dealership picked the car up and have had it since trying to replicate it. It occurs without warning while driving and will drastically slows the car down putting us a risk of being rear ended due to the rapid and speed change. It also is a safety risk due to lack of warning that a power failure is about to occur while driving.

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while attempting to start the vehicle, the vehicle failed to start as intended. The check engine warning light was illuminated. The contact attempted to start the vehicle several times, however the vehicle failed to start. The contact stated that the vehicle was parked in an underground parking lot. The contact stated that four tow trucks attempted to tow the vehicle; however, the transmission had to be disconnected from underneath the vehicle to remove the vehicle from the underground parking garage. The vehicle was then towed to the dealer where it was diagnosed with a failed fuel pump power control module. The contact was informed that the fuel pump power control module needed to be replaced. The vehicle was repaired. The contact was informed of NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline); however, the VIN was not included in the recall. In addition, the contact stated that when the vehicle was retrieved from the dealer after the repair, the failure reoccurred. The contact stated the vehicle was started, and the vehicle was driven to the residence without the failure reoccurring. The manufacturer was made aware of the failure and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 49,064.

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while his wife was driving 45 MPH, the vehicle hesitated. In addition, while attempting to shift the into drive, the gear shifter failed to respond as needed. The check engine warning light was illuminated. The contact stated that the dealer was contacted. The vehicle was towed to a dealer where it was diagnosed and determined that the valve body assembly needed to be replaced. The vehicle was not repaired. The VIN was not included in NHTSA Campaign Number: 24V797000 (POWER TRAIN). The manufacturer was notified of the failure but offered no assistance. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 68,000.

Valve body for 10 speed transmission suddenly malfunctioned while driving on I-95 at 60mph causing rear wheels to lock up for couple of seconds. Then, Engine rpm went to 5000. Error message displayed"reduced acceleration, drive with care" and "Unable to shift soon, service transmission soon". Upon taking to dealer, service advisor mentioned that it could be valve body issue. which is very common for these vehicles. After diagnosis from dealer, there were two codes: P0770 and P0776. Upon some research it was found that these issues are indeed very common for 10speed GM transmission. But, GM hasn't done much to address it. GM acknowledged the issue in their Oct, 2023 bulletin. This is a safety issue especially at highway speeds.

Vehicle just lost propulsion and would not move. Engine was running but just came out of gear and went into neutral at 70mph. Pulled off highway and vehicle would not go back into drive. Would not go into any gear except park. After a while it went into drive and would not go over 30mph. Limped into a nearby dealership and dropped it off. It took GM 47 days to figure out the issue yet the new part was installed immediately. Some sort of computer calibration glitch and GM didn't know the answer till I threatened a lawsuit. Still not confident it was repaired correctly. Dealership was fine and informative but GM blew me off.

Fuel module failure while driving, engine stalled and would not restart.., while at highway speed. Very dangerous situation!!!!! Tahoe was towed to dealership kept for. 1day. Chevy dealer replaced fuel module. We have owned 6 different Tahoes starting with the year 2015 to 2024. The fuel module failed on the 2021, 2022 and now the 2023!!!!!!! Makes us question if we should purchase a new Tahoe every other year? Seriously considering other car brands such as Ford, BMW or other more reliable brands!!!!

Engine failed while driving down the road. There was not prior warning signs to this issue. Vehicle was unable to accelerate. The safety of myself and husband were put a risk as we were traveling on an Interstate 12 in Baton Rouge, LA. The vehicle was inspected by Pine Belt Chevy and the cause identified as Camshaft and lifters failed in the engine causing a sudden deacceleration.

On a few occasions the emergency / parking brake auto releases when parked on a slight incline while the engine is running and transmission is in park.