2021 CHEVROLET TAHOE Complaints

At 35,000 miles, my 2021 Chevrolet Tahoe started to misfire. When I pressed the accelerator, the truck started hesitating and the check engine light started flashing. I was able to get the truck to the dealer I purchased it at. The technician "claimed" it was a bad fuel injector. The dealer replaced the spark plug and injector. The vehicle was never test driven. I picked up the truck and drove it on the road. Within 1 mile, the truck started to misfire again with the check engine light started flashing. The dealer claimed that the lifter or lifters in one engine bank were bad. The dealer replaced the lifters on the one side of the engine.

Engine knocking while accelerating. Told by Chevy dealership that a thruster is broken. Car is only 4 years old with 60k miles. Unfortunately, not under warranty. Quoted $5,000 for fix. No errors on dash or visuals of the problem.

On 2 occasions the dash lights and gauges do not turn on when the vehicle is on. The first time this happened I was driving and was no longer able to see my speed or any other details provided by the gauges. We changed the fuse and it seemed to work for 1 day. The next day I turned the vehicle on, was able to drive but none of the dash features were functioning again. Will be taking to dealership when available scheduling to have it evaluated.

GM does not install TPMS devices in spare tires. I had a flat tire in snowy conditions 100+ miles from the nearest place for assistance. After putting on the spare tire the DIC (driver information center) displayed no air in tire. That’s because a TPMS doesn’t exist in spare tires. I started driving a my four wheel drive turned off. I turned it back on and after a very short distance it turned off again. Since the vehicle determined I didn’t have air in one of the tires (spare previously mentioned) the four wheel drive shouldn’t work to prevent damage. I needed the four wheel drive in the snow so I had to proceed at approximately 25 mph. This is a safety issue for not only my vehicle but others on the roadways. I contacted the dealer that had no idea about the problem and neither did the national GM customer support center. There is a tool that “tells” the vehicle where each tire is located so that is low tire pressure occurs the driver would know which tire needs attention. If a TPMS was installed from the factory and a flat occurred, spare installed then the four wheel drive would function. If a flat subsequently occurred the driver would still be alerted but wouldn’t know tire was involved. Visual check would find it. Either this or have GM provide an override so the trip could be continued safely. I believe that this situation applies to any four wheel drive vehicle not just GM and should be resolved if the NHTSB would initiate an investigation.

2021 Chevrolet Tahoe Engine began misfiring and check engine light and ESC warning indicators displayed as I was driving. I pulled over and shut off vehicle, read manual and restarted engine. Same problems occurred, so I drove to Chevrolet dealer which was a mile away. The advisors said I shouldn’t drive it on the expressway or any further since engine had known problems that GM was aware of and it would blow up. Scans showed P0300 & P0305 for Cylinder 5 misfire. Major Repair included replacement of all lifters and push rods on both banks and the camshaft taking 17 days. This engine should have a GM Recall due to its severity. I was told the engine usually blows up before the warranty period is over and GM would just fix it. Unfortunately for me, my engine failed after full warranty and while I was traveling out of state to a family wedding, costly me directly. GM did pay half of the cost of repair which indicates admitting fault. The major safety concern is when an engine blows up and the driver cannot control the vehicle causing accidents or fire (and being stranded). There were No previous indications or symptoms of engine failure prior to date the problem occurred. Police departments in Illinois have had the same problem with this engine and their entire Tahoe fleet needed a new / repaired engine. This is an unacceptable action by GM to just wait for the problem to occur instead of proactively recalling the engine for repair.

The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving at an undisclosed speed, the brake pedal was depressed; however, the brakes failed to function as intended. In addition, the contact noticed a grinding sound and several unknown warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed with brake master cylinder failure. The contact was informed that the brake master cylinder needed to be replaced. The vehicle was not repaired. The contact stated that the brake master cylinder had been replaced two times since October 2024 and needed to be replaced a third time. The manufacturer was made aware of the failure and a case was filed. The contact was provided a monetary discount towards the cost of the repair. The failure mileage was approximately 35,000.

This is a fairly new vehicle, so to be told we need a new engine when we’ve had the car for only 4 years is ridiculous! We were driving one day and heard a knocking sound coming from the front of the car. We made it home, but when we tried to leave the next time, we only made it halfway down our driveway when we heard a loud knocking noise from the front and the car suddenly stopped. We were dead in the water and needed to get the car towed back to our house. The gear shift was also stuck in drive and we couldn’t turn the car on. The engine had completely seized up. The tow truck driver had to get underneath the vehicle in order to disengage the gear shift and allow us to shift into neutral so that we could get it back home. When we had it towed to our mechanic, they told us that it was a bearing failure and the connecting rod had caused our engine to seize up. I’m just glad we weren’t on a major highway or busy street at the time this took place. This is supposed to be our family vehicle and it has been out of commission for more than 6 months because we haven’t been able to afford to replace the engine. We’ve tried contacting GM directly, but they said we were beyond our warranty and there was nothing they could do to help us.

GM has a known issue with engine lifters on this model engine that fail around 60,000 miles. Customer service managers even stated so themselves and GM has a TSB related to this. Repair bill is $5K-$6K if it doesn’t bend the cam shaft and upwards of $10K if cam is bent. This is a huge safety issue because vehicle fails while in motion, shakes violently, and numerous safety features the driver relies on turn off.

My wife was driving the vehicle when all of a sudden the engine started knocking and throwing a bunch of codes. The engine has a bottom end knock and it seems this is a known problem with these engines.

Vehicle has no warning of issues. Regular maintenance had been performed and had 80k miles. Driving down a 4 lane the engine locked up and lost power. We have been waiting on it to be repaired for 4 months now. The engine is back ordered from GM and no one can find used ones. We found a refurbished one but it also locked up within 30 minutes of being installed. I was warrantied so now we are having ours rebuilt but is costing us $14k.