2021 CHEVROLET TAHOE Complaints

The contact owns a . The contact stated that while driving in reverse a loud popping noise had occurred coming from the engine compartment. Later, while driving up a hill was warning message "Accelerator, Reduced Speed" had displayed and the vehicle was slowly driven home. The contact later discovered that the vehicle also did not operate in reverse. The vehicle was taken to the local mechanic who diagnosed that the transmission valve body was faulty and needed to be replaced. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure but no assistance was offered.. The failure mileage was 85,000.

Check engine light illuminated on my 2021 Chevrolet Tahoe. Upon diagnostic scan, the following emissions-related fault codes were present: P11D5 (NOx sensor), P14D9 (NOx sensor), P2383 (EGR pressure sensor), and P2C7A (NOx catalytic converter efficiency). All components are available for inspection upon request. The vehicle was taken to an authorized Chevrolet dealership for diagnosis. The dealer acknowledged the emissions codes but stated that unrelated components would need to be repaired at owner expense before the emissions system would be addressed, despite these codes falling within the federally mandated 8-year/80,000-mile emissions warranty. The fault codes were confirmed by the dealership. No safety incident has occurred to date, however degraded NOx and EGR function can result in increased harmful emissions output and potential engine performance issues. Warning lamps appeared without prior incident or symptom. The manufacturer has not offered to cover the emissions components under the federal emissions warranty without the owner first paying for additional repairs that may or may not be causally related to the emissions system failure. When the dealer was directly asked, "Are you saying the emissions system itself is functioning correctly, and something else caused these codes to appear?" — the dealer did not provide an answer. This question was asked in order to clarify whether the emissions components themselves are degraded or failed, which would confirm warranty coverage eligibility. The dealer's failure to answer this question directly is noted as part of this complaint.

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving 65 MPH, there was an abnormal vibration coming from the engine compartment and felt in the steering wheel. The check oil warning light illuminated. The vehicle was taken to the residence and then to the dealer, where it was determined that the vehicle was functioning properly, and there was no oil leak; however, the oil level was low even though an oil change was not yet due. The dealer added oil to the vehicle, and an oil consumption test was ordered. The manufacturer was notified of the failure and a complaint was filed. The vehicle was not repaired. The failure mileage was approximately 48,000.

Urgent: Engine Failure Following Recent Service – 2021 Chevrolet Tahoe To Whom It May Concern, I am writing to formally request assistance and an investigation regarding a serious engine failure involving my 2021 Chevrolet Tahoe. In July 2025, I paid out of pocket to have the lifters and camshaft replaced on this vehicle. More recently, while traveling, the vehicle broke down and was taken to Uebelhor Chevrolet, where the valve body in the transmission was replaced. After picking the vehicle up from Uebelhor Chevrolet, the vehicle broke down again approximately one hour later while in Henderson, Kentucky. At that time, the engine began smoking, running rough, and misfiring. I checked the oil level during the incident and found it to be extremely low on the dipstick (I have photographic evidence of this condition). The vehicle had to be towed to Kate Faupel Chevrolet for further inspection. I was then informed that the engine has a dropped lifter on cylinder #8 and possible camshaft damage. Given the following factors: Recent out-of-pocket lifter and camshaft replacement (July 2025) Immediate failure shortly after leaving a Chevrolet dealership Extremely low oil level observed at the time of breakdown (with photo documentation) Diagnosis consistent with potential oil starvation and internal engine damage I am requesting that General Motors conduct a full review of this situation to determine responsibility. This raises serious concerns about a potential defect, improper prior repair, or a service-related issue that resulted in catastrophic engine damage. At this time, I am not authorizing repairs until liability is determined. I am requesting: A formal case review and investigation Assistance with repair or full engine replacement Guidance on how this situation will be resolved This incident created a significant safety concern, as the vehicle became disabled shortly after leaving a dealership during travel. Please contact me as soon as possible to discuss next steps

Vehicle is prompting a “decreased acceleration “ warning, will not shift past 3rd gear, and will not shift into reverse.

The car appeared to run out of gas. It had a half tank of gas. Lucky when it happened I was in the parking lot of my hotel for the night. I was pulling a boat at the time and was 50 miles from a Chevy dealership. Had the car towed to a repair shop where they determined the fuel control module failed. Chevy refused to cover the repair or my inconvenience. There was no previous indication there might be a problem.

My Tahoe has 108,000 miles on it. It broke down in the middle of the road and refused to go into gear with zero symptoms prior to this. We had it towed to the dealership and were told it is the Transmission Valve Body. This is a known issue but our VIN isn't covered for some reason so we have to pay out of pocket for this costly repair that is a known problem!

Suspension system failed- had to replaced, Car difficult to control when operating. Repaired by dealer- Country Chevrolet, Benton KY- owner paid for repair. [XXX] Engine failure- knocking and difficult to drive on returning trip from Louisville KY to Benton, KY. Taken to dealer on 4.6.2026 - made it without being towed- extremely slow- traffic hazard- Tahoe has lots of road miles- always repaired and serviced by dealer. There were no warning lights, symbols or indicators that there was a problem. Dealer still determining the extent of the damage. [XXX] Benton KY INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The component at issue is the engine, which suffered a sudden and catastrophic failure due to unknown causes. At no time prior to this incident were there any warnings, symptoms, or indications of an underlying mechanical defect that would have allowed for preventative action. While operating the vehicle on the highway with my family present, multiple warning indicators activated simultaneously, including a blinking check engine light, traction control light, ESC warning, and a forward collision warning. Immediately thereafter, the vehicle experienced a rapid and significant loss of power accompanied by a loud and persistent engine knocking noise, rendering the vehicle unsafe to operate and placing the occupants at risk. It is important to emphasize that traction control and ESC systems are not causally related to an engine misfire condition, further supporting that this event was abrupt and not part of a progressive or diagnosable issue. A diagnostic scan performed at that time identified a misfire in cylinder 1. Upon delivery of the vehicle to the dealership for inspection, it was determined that the engine had suffered complete internal failure and was deemed “blown.” This finding confirms the occurrence of a catastrophic mechanical breakdown. Based on the sudden onset, absence of prior warning, and severity of the failure, there is no reasonable basis to attribute this condition to normal wear and tear, operator misuse, or neglect. Rather, the facts support the conclusion that this was the result of a latent defect or internal mechanical failure beyond the operator’s control. Accordingly, this matter should be addressed under applicable warranty coverage or consumer protection standards.

During highway driving, alert on dashboard stated “electrical system failing enter idle mode”. Tahoe slowed down and then engine began knocking right as it shut off resulting in needing to coast to the shoulder of the highway safely since engine was off. Towed to dealership and then they came back saying needed a new battery, new alternator belt, pulley and water compartment. After those installed, additional call was made indicating the engine needed a full replacement as it keeps overheating despite no sensor alerts and codes are being tripped. Here we are asked to pay 16K for new engine install and unable to fix.