2004 CHEVROLET TRAILBLAZER Complaints

RUSTED FUEL LINES- GARAGE CHECKED STRONG FUEL SMELL AND DISCOVERED RUSTED FUEL FILLER AND LINES

2004 CHEVY TRAILBLAZER KEEPS GETTING CAM POSITION SENSOR FAULT. CAUSING CHECK ENGINE LIGHT TO COME ON. SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL. WE HAVE REPLACED THIS PART THREE TO FOUR TIMES ON OUR TRUCK. TRUCK BEGAN TO RUN ROUGH ENGINE KNOCKED AND HAD REDUCED POWER.

PART # 19120564 RUBS ON TAILGATE WHEN OPENING . DOES SECURE PROPERLY. EVENTUALLY, FLEW OFF WHILE DRIVING.

THE SAME THING RUNNING OFF THE FUSE TO THE CPU GROUNDS OUT ON THE BODY BLOWING THE FUSE MAKING IT SEEM LIKE THE CPU IS BAD. I WENT AND STARTED IT AND PUT IN DRIVE, FUSE BLEW, AND THE ENGINE SHUT DOWN

TRANSMISSION OIL COOLER LINES ARE CORRODED TO THE POINT WHERE THEY ARE LEAKING FLUID AND THE VEHICLE ONLY HAS 130000 MILES ON IT.

AFTER STARTING MY 2004 CHEVY TRAILBLAZER THE GAUGES ON THE INSTRUMENT PANEL DID NOT WORK. BUT THE ABS, SEAT BELT, BREAK AND CHECK ENGINE LIGHTS ARE ON. THE INDICATOR FOR GEARS IS OUT. THE SPEEDOMETER JUMPS SO NOT ALWAYS SURE HOW FAST I'M GOING. I HAVE ONLY OWNED THIS VEHICLE FOR A SHORT TIME. BUT AFTER SOME RESEARCH I HAVE DISCOVERED THAT THIS IS A VERY COMMON PROBLEM WITH THIS VEHICLE.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. THE CONTACT STATED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS SEVERELY RUSTED. THE CONTACT BECAME AWARE OF THE CORROSION BY VISIBLY INSPECTING THE VEHICLE. THE CONTACT STATED THAT THE REAR STABILIZER BAR WAS TOTALLY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THE SUBFRAME THAT SUPPORTED THE REAR SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED CASE NUMBER: 8-4669457241. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

DRIVING CONDITIONS DARK, 11PM, UNLIT, STARS VISIBLE PAVED COUNTRY ROAD WITH HILLS, CURVES AND 2-5 FOOT DITCHES. WEATHER WET BUT DRYING. VISIBILITY GOOD. VEHICLE IN MOTION NEAR LEGAL SPEED LIMIT 80 KM/HR. OCCASIONAL ONCOMING TRAFFIC, SO OCCASIONALLY SWITCHING BETWEEN LOW AND HIGH BEAMS. NOTICED LOW BEAM HEADLIGHTS FLICKERED OCCASIONALLY. EFFECT WAS ONLY VISIBLE AFTER ONCOMING TRAFFIC HAD PASSED, BEFORE SWITCHING BACK TO HIGH BEAM HEADLIGHTS. I HAD ATTRIBUTED THE EFFECT TO MY EYES ADJUSTING AFTER THE ONCOMING HEADLIGHTS. ON ONE OCCASION, AFTER THE ONCOMING VEHICLE HAD PASSED, I SWITCHED BACK TO LOW BEAM SETTING, BUT THE LOW BEAM HEADLIGHTS WERE NOT ILLUMINATING THE ROAD AT ALL. ALL I COULD SEE WAS A SMALL AMOUNT OF YELLOWISH LIGHT OFF TO THE SIDES OF THE VEHICLE FROM THE OTHER RUNNING LIGHTS, INCLUDING YELLOW LIGHTS ON THE SIDE-VIEW MIRRORS. THERE WAS INSUFFICIENT LIGHT TO SEE ANY DISTANCE DOWN THE ROAD, SO I CEASED TO DEPRESS THE ACCELERATOR PEDAL, AND COVERED THE BRAKE APPLYING GENTLE BRAKING. I STILL HAD MY FINGERS ON THE LEVER AND WAS ABLE TO SWITCH BACK TO HIGH BEAMS AFTER SEVERAL SECONDS. FORTUNATELY THE HIGH BEAMS STILL WORKED. I BROUGHT THE VEHICLE TO A STOP AT THE NEXT AVAILABLE SAFE OPPORTUNITY, TO ASSESS WHAT HAD HAPPENED. ALL OTHER LIGHTS, INCLUDING THE FOG LIGHTS WERE WORKING. I DROVE AT REDUCED SPEED ALTERNATELY USING THE FOG LIGHTS AND HIGH BEAMS. THE LOW BEAMS OCCASIONALLY STARTED WORKING AGAIN. BY THE TIME I WAS HOME, THEY HAD CEASED TO WORK. I REPLACED THE GM HDM MODULE, AND THE LOW BEAMS WORKED FOR A YEAR OR SO UNTIL THAT MODULE FAILED. THERE IS A RECALL TO REPLACE GM HDM 15016745 WITH GM HDM 13506836 BUT THE RECALL APPARENTLY DOES NOT APPLY TO MY 2004 MODEL YEAR. NHTSA RECALL NO. : 15V-519 MANUFACTURER RECALL NO. : 14291 I CONSIDER THIS TO HAVE BEEN A SEVERE LIFE THREATENING EVENT.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE OPERATING THE VEHICLE, THE LOW BEAM HEADLIGHTS AND THE BRAKE LIGHTS RANDOMLY STOPPED ILLUMINATING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE LIGHT BULBS, CIRCUIT BOARDS, AND FUSES; HOWEVER, THE FAILURES CONTINUED. WHEN REPLACING THE BRAKE LIGHTS, THE BULBS MELTED INTO THE CIRCUIT BOARD. THE LOCAL DEALER WAS NOT NOTIFIED OF THE FAILURES. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2004 CHEVROLET TRAILBLAZER. WHILE DRIVING 45 MPH, THE CONTACT DETECTED A FUEL ODOR COMING THROUGH THE VENTS. THE CONTACT MENTIONED THAT THE CHECK ENGINE INDICATOR ILLUMINATED PRIOR TO THE FAILURE. THE CONTACT ALSO STATED THAT THE INSTRUMENT PANEL DID NOT ILLUMINATE AND THE SPEEDOMETER DID NOT OPERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FUEL PRESSURE REGULATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 153,000.