2003 CHEVROLET TRAILBLAZER Complaints

I HAVE A 2003 TRAILBLAZER EXT. JUST GOT IT FROM MY IN-LAWS, ONLY 21K MILES ON IT. GASOLINE VENTS ON THE GROUND WHEN FILLING THE TANK FULL. THE CHECK ENGINE LIGHT REMAINS ILLUMINATED. I COUNTED MORE THAN 20 COMPLAINTS JUST LIKE MINE ON THE NHTSA COMPLAINT LIST. EXAMPLE ODI ID NUMBERS ARE 10191706, 10190967, 10188345, 10187405, 10186556, 10185694, 10184336, 10183773, 10182724, 10182384, ETC. I ASSUME IT IS A CRACKED FILLER NECK. I CALLED GM CUSTOMER SERVICE. THEY SEEMED HELPFUL AND GAVE ME A CASE NUMBER, BUT ADVISED ME TO GO TO A GM DEALER FOR AN OFFICIAL DIAGNOSIS BEFORE THEY CAN PROCEED WITH HELPING ME FURTHER. NO PROMISES AT THIS TIME. I ASSUME I'LL HAVE TO PAY FOR THE DIAGNOSIS. THIS IS A DANGEROUS MALFUNCTION, IT CAUSES FUMES, ODORS, AND PUDDLES OF GASOLINE BENEATH HOT VEHICLES. *TR

SERVICE ENGINE LIGHT CAME ON. MY PRIVATE MECHANIC FOUND IT TO BE CODE P0440 INDICATING THE FUEL EVAPORATION SYSTEM HAD A PROBLEM. INITIAL INSPECTION FOUND NOTHING BUT UPON PERFORMING A SMOKE TEST OF THE FUEL SYSTEM, THE FUEL INLET NOZZLE ON THE FUEL TANK WAS FOUND LEAKING. ONLY FIX WAS TO REPLACE THE TANK. TOTAL COST WAS $2200. I NOTIFIED GM AND WAS TOLD THEY CANNOT DO ANYTHING SINCE THE VEHICLE IS OUT OF WARRANTY. FUEL TANKS SHOULD NOT BE LEAKING, ESPECIALLY WHEN THEY ARE ONLY 4 YEARS OF AGE. MANY OTHER SIMILAR COMPLAINTS ON THIS WEBSITE SHOW THIS TO BE A COMMON PROBLEM WITH THIS VEHICLE. A RECALL TO CHECK ALL FUEL TANKS SHOULD BE DONE BEFORE SOMEONE IS KILLED OVER THIS POOR DESIGN/QUALITY ISSUE. *TR

2003 CHEVY TRAILBLAZER EXT HAS CRACK WHERE FUEL FILLER NECK MEETS THE FUEL TANK. IT CAUSES DTC P0440 TO BE SET, SES LIGHT TO ILLUMINATE AND FUEL TO LEAK FROM FUEL TANK.

NO WARNING. WHILE DRIVING DOWN THE ROAD, THE CAR JUST SHUTS DOWN. THE FIRST TIME WE HAD IT TOWED TO AAA AUTOMARK, THEY REPLACED THE BATTERY BUT DID NOT FIND ANYTHING ELSE WRONG. IT HAS HAPPENED 3 TIMES SINCE. WE HAVE BEEN ABLE TO COAST OFF OF THE ROAD WITHOUT INCIDENCE SO FAR, BUT THIS IS DANGEROUS. I WENT TO THE WEBSITE BELOW, SEVERAL PEOPLE HAVE EXPERIENCED AND DESCRIBED THE SAME CONDITIONS. I DO NOT DRIVE THE CAR ON THE HIGHWAY AT THIS TIME. HTTP://WWW.TOPIX.NET/FORUM/AUTOS/CHEVROLET-TRAILBLAZER/T0L7P7IH6L5H33N4S/P3

2003 CHEVROLET TRAILBLAZER EXT LEAKING FUEL AT FILLER NECK/FUEL TANK. CHECK ENGINE LIGHT CONTINUED TO COME ON WITH VARIATIONS IN DURATION AFTER RESET. CODE INDICATED SMALL FUEL LEAK. STRONG ODOR OF FUEL SURROUNDING VEHICLE, AND SOMETIMES CAME INSIDE OF VEHICLE AFTER FILL UP. FINALLY, DISCOVERED LEAK AFTER COMPLETELY FILLING TANK AND PARKING ON HILL. GAS POURED OUT. *AK

TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT THE ENGINE FAILED TO START, THE INSTRUMENT PANEL PRODUCED A HISSING NOISE, AND THE INSTRUMENT GAUGES FLUCTUATED ERRATICALLY. THE VEHICLE WOULD START AFTER SEVERAL ATTEMPTS WERE MADE. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE HAS OCCURRED THREE TIMES AT 39,650, 40,210 AND 40,227 MILES. THE CURRENT MILEAGE IS 40,227 AND FAILURE MILEAGE WAS 39,650.

ENGINE KEPT MAKING THIS VERY LOAD ROARING NOISE. HAD TO GET THE CLUTCH FAN REPLACED LIKE MANY OTHER TRAILBLAZER OWNERS. GM NEEDS TO RECALL THIS PART! *TR

TL* THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER. WHILE DRIVING APPROXIMATELY 5 MPH THE VEHICLE BEGAN MAKING A LOUD NOISE. THE CONTACT PULLED OVER AND NOTICED THAT THE REAR DRIVER'S SIDE TIRE WAS FLAT. WHILE ATTEMPTING TO REMOVE THE SPARE TIRE THE HOIST FAILED TO CRANK TO RELEASE THE SPARE TIRE. THE SERIAL NUMBER FOR THE CRANK WAS NOT VISIBLE. THE MECHANIC STATED THAT THE WIRES FOR THE HOIST WERE CROSSED. THE CURRENT AND FAILURE MILEAGES WERE 48,000.*AK

ON APRIL 29, 2007, WHILE MY WIFE AND CHILDREN WERE PREPARING TO GO OUT TO THE STORE, THE REAR WINDOW ON MY 2003 CHEVROLET TRAILBLAZER SHATTERED. NO ONE WAS IN THE CAR AT THE TIME AND THERE IS NO APPARENT CAUSE FOR THIS EVENT. GLASS FROM THE WINDOW WENT EVERYWHERE AND EVEN STRUCK MY 6 YEAR OLD SON IN THE LEG. I HAVE REPORTED THIS TO MY INSURANCE COMPANY AND REPLACEMENT OF THE WINDOW WILL OCCUR ON 5/2/07. *TR

ABOUT TWO YEARS AGO WHILE I WAS TRYING TO CLOSE THE GLASS REAR HATCH ON MY 2003 CHEVROLET TRAILBLAZER IT EXPLODED IN MY FACE. I WAS CUT ON MY HANDS, FACE, AND GOT GLASS IN MY EYES. I WENT DIRECTLY TO THE DEALER (ARROW CHEVROLET, NOW CALLED SUNRISE CHEVROLET, IN MIDLOTHIAN IL.) THE SERVICE DEPT. LOOKED AT THE DAMAGE AND SAID THEY NEVER SAW ANYTHING LIKE THAT, (I FOUND OUT LATER THAT IT IS COMMON) THEY SENT THE VEHICLE OUT TO A "WINDOW REPAIR SHOP" TO HAVE THE GLASS REPLACED. WHEN I GOT THE CAR BACK, I NOTICED THAT THE WINDOW WAS NOT ALIGNED PROPERLY; THE SERVICE DEPT. LOOKED AT IT QUICKLY AND TOLD ME THAT IT WAS FINE. THREE WEEKS AGO WHILE DRIVING DOWN THE INTERSTATE AT 70 MPH A LOUD VIBRATION CAME FROM THE GLASS WINDOW HATCH, AS I SLOWED DOWN THE HIGH MOUNT REAR STOP TAIL LAMP ASSEMBLY, WHICH IS A LARGE FIBERGLASS BODY PIECE AS WIDE AS THE CAR AND 3 FEET ACROSS FLEW OFF MY CAR STRIKING A CAR IN BACK OF ME. I PULLED OVER AND SO DID THE OTHER DRIVER, THE OTHER DRIVER WAS VERY SHAKEN AS SO WAS I. SLIGHT DAMAGE TO THE HOOD AND THE BUMPER OF THE OTHER CAR AND HE SAID THAT IT WAS OK SINCE THE CAR WAS OLD. MY CAR NOW IS MISSING A LARGE PIECE OF THE BODY AND THE THIRD BRAKE LIGHT. IT WAS RUN OVER BY A TRUCK... THE WINDOW COMPANY THAT REPLACED THE REAR HATCH WINDOW DID NOT AFFIX THE PANEL PROPERLY TO THE WINDOW; I HAVE SEEN MAY COMPLAINTS ON OTHER WEB SITE THAT THE FACTORY INSTALL AND THE DOUBLE FACE TAPE THAT IS USED MALFUNCTIONS ALL THE TIME, PLEASE HELP ME, WE ARE DEALING WITH TWO ISSUES HERE, THE REAR WINDOW EXPLODING AND INJURING ME AND THE FAULTY DOUBLE FACED TAPE THAT IS USED TO SECURE OUTSIDE PARTS TO THE CAR. IN ADDITION, THE ILLINOIS STATE POLICE STOPPED AND TOLD ME THAT THEY COULD HAVE GIVEN ME A TICKET FOR DRIVING AN UNSAFE VEHICLE BUT THEY GAVE ME A PASS AND TOLD ME TO WRITE TO YOU AND SEND THEM A COPY OF MY LETTER. *TR