2003 CHEVROLET TRAILBLAZER EXT Complaints

THE EXHAUST MANIFOLD ON MY 2003 CHEVY TRAILBLAZER EXT HAS CRACKED AT 54000 MILES, AND MUST BE REPLACED AT A COST OF AROUND $400. I CONTACTED GM DIRECTLY, AND WAS TOLD THAT THIS IS CONSIDERED "NORMAL WEAR AND TEAR." I DISAGREE. IF THAT IS THE CASE, THEN WHY WOULD I KEEP THE VEHICLE, KNOWING I CAN ANTICIPATE ANOTHER COSTLY REPAIR WITHIN THE REASONABLE LIFE OF THE VEHICLE. MY LOCAL CHEVY DEALERS SERVICE MANAGER TELLS ME GM IS REPAIRING MANY OF THESE PARTS ON THE 4.2 L. ENGINE OF NOT ONLY THE TRAILBLAZER, BUT OTHER VEHICLES AS WELL. A LOCAL AFTERMARKET PARTS STORE ALSO SAYS HIS SUPPLIERS HAVE MANY OF THESE PARTS ON HAND. MORE THAN ONE MIGHT EXPECT IF THIS WERE AN UNEXPECTED OCCURRENCE. I BELIEVE GM KNOWS IT HAS A PART THAT IS UNSOUND, BUT IT IS UNWILLING TO CORRECT THE PROBLEM AT ITS EXPENSE. AN EXHAUST MANIFOLD IS NOT SUPPOSED TO FAIL WITHIN LESS THAN 4 YEARS, AND AT 54000 MILES. THAT IS NOT "NORMAL WEAR AND TEAR. *JB

TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT HE SMELLS GAS FUMES WHILE DRIVING THE VEHICLE. WHILE PUMPING GAS, THE CONTACT NOTICED FUEL LEAKING. THE MANUFACTURER SENT A TECHNICAL SERVICE BULLETIN FOR AN ICV FRACTURE AND STATED THAT THE FUEL TANK WOULD BE REPLACED. THE DEALER REFUSED TO REPLACE THE TANK. THE CURRENT AND FAILURE MILEAGES WERE 83,000.

TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER LTZ. WHILE DRIVING 35 MPH, THE VEHICLE'S WINDSHIELD WIPERS WOULD NOT TURN OFF. THE CONTACT HAS TO REMOVE THE FUSE TO DEACTIVATE THEM AND PLACE THE FUSE BACK TO ACTIVATE THEM AGAIN. SHE WAS TOLD THAT HER VEHICLE WAS NOT INCLUDED IN RECALL # 04V046000 (VISIBILITY:WINDSHIELD WIPER/WASHER). THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE IS 103,000 AND FAILURE MILEAGE WAS 60,000. THE CONSUMER STATED THAT THIS IS A SERIOUS SAFETY CONCERN. UPDATED 09/05/07 *TR

SMELL OF FUEL AFTER DRIVING. FUEL LEAKING IN VICININTY OF GAS TANK ONTO DRIVEWAY. BROUGHT 2003 TRAILBLAZER FOR SERVICING. FUEL PUMP WAS LEAKING FUEL WHERE CONNECTED TO SENDING UNIT. FUEL PUMP REPLACED. ORIGINAL SENDING UNIT TRANSFERRED ONTO NEW PUMP. PARTS COST $500.00 AND LABOR $180. *AK

TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT HAS HAD BOTH HEADLIGHTS REPLACED ON HER VEHICLE AND NOW THEY FAIL TO ILLUMINATE. WHEN IT GETS DARK OUTSIDE, THE HEADLIGHTS WOULD NORMALLY ACTIVATE AUTOMATICALLY, BUT THEY FAIL TO ACTIVATE ANY LONGER. THE DEALER AND THE MANUFACTURER HAVE NOT BEEN CONTACTED. THE VIN, ENGINE SIZE, AND FAILURE MILEAGE WERE UNKNOWN. THE CURRENT MILEAGE IS 120,000.

REAR AC/ENGINE COOLANT LINE WAS RUBBED THRU DUE TO THE DEFECTIVE INSTALLATION OF A HEAT SHIELD. THE TWO LINES PROVIDE FREON AND ENGINE COOLANT TO THE REAR AC/HEATER. THE GM PART NUMBER IS 15113349 AND IS ON NATIONAL BACK ORDER BECAUSE THIS PART IS NOT SUPPOSE TO FAIL. GM CURRENTLY HAS OVER 100 OPEN TICKETS WHERE THIS PART IS FAILING AND THEY DO NOT HAVE ANY SUPPLY OF REPLACEMENT PARTS AS THIS PIPE IS AN ALUMINUM PIPE THAT ONES FROM THE FRONT TO THE BACK AND IS NOT SUPPOSE TO FAIL. *TR

WHEN GETTING THE OIL CHANGED FOR OUR TRAILBLAZER, THEY TOLD US THAT THE DRIVER'S SIDE REVERSE LIGHT WAS OUT. WHEN THEY WENT TO REPLACE IT, THEY INFORMED US THAT THE ENTIRE AREA FOR THE BULB WAS RUSTED OUT. WE HAVE NOTICED THAT MOISTURE COLLECTS IN BOTH BRAKE LIGHT AREAS WHEN IT RAINS OR AFTER A CAR WASH. IS THERE A RECALL FOR THIS? *TR

I HAVE A 2003 CHEVROLET TRAILBLAZER EXT. THE "SERVICE ENGINE SOON" LIGHT CAME ON. I TOOK IT IN TO A CHEVROLET DEALERSHIP. IT WAS FOUND THAT THE GAS TANK WAS LEAKING GAS AND THE TANK WOULD NOT HOLD PRESSURE THUS CAUSING THE LIGHT TO COME ON. THE TANK WAS LEAKING WHERE THE FILLER NECK ATTACHES TO THE TANK. THE DEALERSHIP SERVICE DIRECTOR STATED THAT THE THE CRACK WAS CLEARLY A DEFECT AND WAS NOT CAUSED BY DAMAGE OR MISUSE. BECAUSE THE VEHICLE WAS OUT OF WARRANTY HE STATED THE REPAIR WOULD BE AT MY EXPENSE AND WOULD BE APPROXIMATELY $750-$800.00. I PHONED CHEVROLET CUSTOMER ASSISTANCE AND FILED A COMPLAINT. AFTER THEY COMMUNICATED WITH THE CHEVROLET DISTRICT SERVICE REP. THEY CONCLUDED THAT GM WARRANTY WOULD NOT PAY FOR THE REPAIRS, EVEN DESPITE THE DANGER AND LIABILITY INVOLVED. THEY DID SUGGEST THAT IF THE DEALERSHIP WOULD APPROVE, TO HAVE THEM DO IT AT THE DEALERSHIP COST. THE GM CUSTOMER ASSISTANCE REP STATED THAT MY ONLY OTHER FORM OF ARBITRATION WAS THROUGH THE BETTER BUSINESS BUREAU. AS OF THIS DATE THE REPAIRS HAVE NOT BEEN MADE. I HAVE FOUND QUITE A NUMBER OF TRAILBLAZER OWNERS ON THE INTERNET WHO HAVE HAD THE SAME PROBLEM AND HAVE HAD TO PAY TO HAVE THE REPAIR MADE OUT OF POCKET.

THE AUTOMOBILE STARTS OUT IN 2ND GEAR AND AT HIGHWAY SPEED THE TRANSMISSION HUNTS FOR THE CORRECT GEAR SHIFTING BACK AND FORTH.

I HAVE A 2003 TRAILBLAZER EXT. JUST GOT IT FROM MY IN-LAWS, ONLY 21K MILES ON IT. GASOLINE VENTS ON THE GROUND WHEN FILLING THE TANK FULL. THE CHECK ENGINE LIGHT REMAINS ILLUMINATED. I COUNTED MORE THAN 20 COMPLAINTS JUST LIKE MINE ON THE NHTSA COMPLAINT LIST. EXAMPLE ODI ID NUMBERS ARE 10191706, 10190967, 10188345, 10187405, 10186556, 10185694, 10184336, 10183773, 10182724, 10182384, ETC. I ASSUME IT IS A CRACKED FILLER NECK. I CALLED GM CUSTOMER SERVICE. THEY SEEMED HELPFUL AND GAVE ME A CASE NUMBER, BUT ADVISED ME TO GO TO A GM DEALER FOR AN OFFICIAL DIAGNOSIS BEFORE THEY CAN PROCEED WITH HELPING ME FURTHER. NO PROMISES AT THIS TIME. I ASSUME I'LL HAVE TO PAY FOR THE DIAGNOSIS. THIS IS A DANGEROUS MALFUNCTION, IT CAUSES FUMES, ODORS, AND PUDDLES OF GASOLINE BENEATH HOT VEHICLES. *TR