2003 CHEVROLET TRAILBLAZER EXT Complaints

2003 CHEVY TRAILBLAZER EXT HAS CRACK WHERE FUEL FILLER NECK MEETS THE FUEL TANK. IT CAUSES DTC P0440 TO BE SET, SES LIGHT TO ILLUMINATE AND FUEL TO LEAK FROM FUEL TANK.

2003 CHEVROLET TRAILBLAZER EXT LEAKING FUEL AT FILLER NECK/FUEL TANK. CHECK ENGINE LIGHT CONTINUED TO COME ON WITH VARIATIONS IN DURATION AFTER RESET. CODE INDICATED SMALL FUEL LEAK. STRONG ODOR OF FUEL SURROUNDING VEHICLE, AND SOMETIMES CAME INSIDE OF VEHICLE AFTER FILL UP. FINALLY, DISCOVERED LEAK AFTER COMPLETELY FILLING TANK AND PARKING ON HILL. GAS POURED OUT. *AK

TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT STATED THAT THE ENGINE FAILED TO START, THE INSTRUMENT PANEL PRODUCED A HISSING NOISE, AND THE INSTRUMENT GAUGES FLUCTUATED ERRATICALLY. THE VEHICLE WOULD START AFTER SEVERAL ATTEMPTS WERE MADE. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE HAS OCCURRED THREE TIMES AT 39,650, 40,210 AND 40,227 MILES. THE CURRENT MILEAGE IS 40,227 AND FAILURE MILEAGE WAS 39,650.

ON APRIL 29, 2007, WHILE MY WIFE AND CHILDREN WERE PREPARING TO GO OUT TO THE STORE, THE REAR WINDOW ON MY 2003 CHEVROLET TRAILBLAZER SHATTERED. NO ONE WAS IN THE CAR AT THE TIME AND THERE IS NO APPARENT CAUSE FOR THIS EVENT. GLASS FROM THE WINDOW WENT EVERYWHERE AND EVEN STRUCK MY 6 YEAR OLD SON IN THE LEG. I HAVE REPORTED THIS TO MY INSURANCE COMPANY AND REPLACEMENT OF THE WINDOW WILL OCCUR ON 5/2/07. *TR

ABOUT TWO YEARS AGO WHILE I WAS TRYING TO CLOSE THE GLASS REAR HATCH ON MY 2003 CHEVROLET TRAILBLAZER IT EXPLODED IN MY FACE. I WAS CUT ON MY HANDS, FACE, AND GOT GLASS IN MY EYES. I WENT DIRECTLY TO THE DEALER (ARROW CHEVROLET, NOW CALLED SUNRISE CHEVROLET, IN MIDLOTHIAN IL.) THE SERVICE DEPT. LOOKED AT THE DAMAGE AND SAID THEY NEVER SAW ANYTHING LIKE THAT, (I FOUND OUT LATER THAT IT IS COMMON) THEY SENT THE VEHICLE OUT TO A "WINDOW REPAIR SHOP" TO HAVE THE GLASS REPLACED. WHEN I GOT THE CAR BACK, I NOTICED THAT THE WINDOW WAS NOT ALIGNED PROPERLY; THE SERVICE DEPT. LOOKED AT IT QUICKLY AND TOLD ME THAT IT WAS FINE. THREE WEEKS AGO WHILE DRIVING DOWN THE INTERSTATE AT 70 MPH A LOUD VIBRATION CAME FROM THE GLASS WINDOW HATCH, AS I SLOWED DOWN THE HIGH MOUNT REAR STOP TAIL LAMP ASSEMBLY, WHICH IS A LARGE FIBERGLASS BODY PIECE AS WIDE AS THE CAR AND 3 FEET ACROSS FLEW OFF MY CAR STRIKING A CAR IN BACK OF ME. I PULLED OVER AND SO DID THE OTHER DRIVER, THE OTHER DRIVER WAS VERY SHAKEN AS SO WAS I. SLIGHT DAMAGE TO THE HOOD AND THE BUMPER OF THE OTHER CAR AND HE SAID THAT IT WAS OK SINCE THE CAR WAS OLD. MY CAR NOW IS MISSING A LARGE PIECE OF THE BODY AND THE THIRD BRAKE LIGHT. IT WAS RUN OVER BY A TRUCK... THE WINDOW COMPANY THAT REPLACED THE REAR HATCH WINDOW DID NOT AFFIX THE PANEL PROPERLY TO THE WINDOW; I HAVE SEEN MAY COMPLAINTS ON OTHER WEB SITE THAT THE FACTORY INSTALL AND THE DOUBLE FACE TAPE THAT IS USED MALFUNCTIONS ALL THE TIME, PLEASE HELP ME, WE ARE DEALING WITH TWO ISSUES HERE, THE REAR WINDOW EXPLODING AND INJURING ME AND THE FAULTY DOUBLE FACED TAPE THAT IS USED TO SECURE OUTSIDE PARTS TO THE CAR. IN ADDITION, THE ILLINOIS STATE POLICE STOPPED AND TOLD ME THAT THEY COULD HAVE GIVEN ME A TICKET FOR DRIVING AN UNSAFE VEHICLE BUT THEY GAVE ME A PASS AND TOLD ME TO WRITE TO YOU AND SEND THEM A COPY OF MY LETTER. *TR

I OWN A 2003 CHEVY TRAILBLAZER LT @ 35,825 MILES I REPORTED MY VEHICLE BINDS UP ON TURNS & OF COURSE THE GARAGE FOUND NOTHING (DROVE IT 20 MILES FOR COMPARISON @ THE TIME). SO NOW THAT I AM UP TO 82,090 MILES NOW I MENTION SUSPENSION ISSUES STILL & OF COURSE THEY FIND BOTH LOWER BALL JOINTS NEED REPLACED @ $320.06 & LEFT OUTER TIE ROD END BROKEN @ $170.80. ALSO THEY INFORM ME I NEED TO REPLACE 3 OF MY 4 STABILIZER BAR LINKS ARE LOOSE & RATTLING @ AN ESTIMATE OF $320.00 (HAVEN'T DONE YET) ALSO, I HAVE LOOKED ON A WEBSITE CALLED MYCARSTATS.COM & FOUND MANY OTHERS WITH THESE SAME ISSUES WITH THIS VEHICLE @ MUCH LOWER MILEAGE & WHERE TIE ROD ISSUE CAUSED AN ACCIDENT -- THEY WEREN'T AS LUCKY AS ME. ALSO PEOPLE I WORK WITH WHO HAVE THIS SAME YR & MODEL VEHICLE HAVE HAD TO HAVE BALL JOINTS, SWAY BARS REPLACED, AND OTHER SUSPENSION WORK @ LOWER MILEAGES. I ALSO HAD AN ISSUE WITH MY 4-WHEEL DRIVE BECOMING INOPERATIVE & THIS DID ALMOST CAUSE ME TO WRECK GOING UP HILL DURING WINTER WEATHER. THEY REPLACED FRONT DIFFERENTIAL ENGAGEMENT ACTUATOR. ALL THESE THINGS IN MY MIND SHOULD NOT HAVE HAPPENED AT THESE MILEAGES. THE 4-WHEEL DRIVE QUIT @ 80,000 MILES. ALL THESE ISSUES CAN CREATE SAFE DRIVING ISSUES FOR THE CONSUMER ESPECIALLY SOMEONE WHO PAYS OVER $30,000 FOR A VEHICLE WHEN IT'S NEW. LET ME ADD NOW THAT THE LATEST EXPENSIVE REPAIR TO ADD TO MY LIST IS THE FAN CLUTCH ASSEMBLY ON MY ENGINE COOLING FAN SYSTEM $573.00 -- ALSO FOUND MANY GM OWNERS OF BRAVADA, RAINERS, ENVOYS & TRAILBLAZERS EXPERIENCING THIS ITEMS FAILURE TOO. *JB

I OWN A 2003 TRAILBLAZER AND RECENTLY I BEGAN SMELLING LARGE AMOUNTS OF FUMES AND FUEL SPILLING ONTO THE GROUND WHEN FILLIING THE GAS TANK. FROM MY RESEARCH, I'VE FOUND THAT BASED ON THE SYMPTOMS LISTED ABOVE A MANUFACTURER'S DEFECT ON THE GAS TANK WAS HONORED ON THE 2002 MODEL TRAILBLAZER BUT WAS NOT BEING ISSUED ON THE SAME DESIGN FLAW ON THE 2003 MODEL. IT WAS STATED THAT THIS WAS NOT A SAFETY HAZARD WHICH IS HARD FOR ME TO COME TO TERMS WITH. GM HAS STATED THAT IT WOULD COST $1200 TO BE REPAIRED AT THE CUSTOMER'S EXPENSE WHICH IS JUST UNACCEPTABLE SINCE THIS IS THE SAME PROBLEM CARRIED OVER FROM THE 2002 MODEL. *TR

I SMELLED A STRONG ODOR OF GASOLINE, AND HAD FUEL LEAKING FROM THE GAS TANK. I WAS AFRAID TO KEEP DRIVING IT LIKE THAT, I TOOK IT TO GET REPAIRED. THE SERVICE TECHNICIAN HAD TO REPLACE THE SENDING UNIT MODULE, PART # MU1377. HE SAID IT WAS CORRODED.*AK

TL*THE CONTACT OWNS A 2003 CHEVROLET TRAILBLAZER EXT. THE CONTACT OPENED THE REAR HATCH AND HEARD A CRACKING NOISE COMING FROM THE TOP. APPROXIMATELY THREE TO FOUR DAYS LATER THE CONTACT NOTICED THAT THE CENTER HIGH MOUNTED STOP LAMP BRACKET FAILED. THE VEHICLE WAS BROUGHT TO THE DEALER SIMMONS-ROCKWELL CHEVROLET. THE DEALER TOOK THE VEHICLE TO ANOTHER MECHANIC, AND INFORMED THE CONTACT THAT THE FAILURE WAS TYPICAL FOR THAT TYPE OF VEHICLE AND WAS INDEED A SAFETY ISSUE. THE MECHANIC STATED THAT THE ENTIRE CENTER HIGH MOUNTED STOP LAMP COULD BECOME DETACHED WHILE DRIVING AND STRIKE ANOTHER VEHICLE. THE CONTACT FOUND ANOTHER COMPLAINT ONLINE WITH ODI # 10061979. THE CONTACT FILED A COMPLAINT WITH THE MANUFACTURER, AND WAS GIVEN CASE # 71-500170558. ALSO, THE CONTACT STATED THE FUEL SYSTEM FAILED. IN JANUARY OF 2007, THE CONTACT DETECTED AN AROMA OF GAS WHILE DRIVING THE VEHICLE. THE ODOR BECAME INCREASINGLY POTENT, AND THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THE FUEL PUMP MODULE WAS CORRODED AND LEAKED. AND THE DEALER QUOTED A REPAIR PRICE OF $800. THE FUEL PUMP FILTER WAS REPAIRED, AND AFTER SERIOUS NEGOTIATIONS, THE CONTACT WAS ONLY REQUIRED TO PAY $196.00. THE CONTACT SEARCHED ONLINE ,AND FOUND AN OPEN INVESTIGATION , PE07013 FROM NHTSA DATED MARCH 12, 2007 FOR THE FUEL SYSTEM. THE FAILURE MILEAGE WAS 42,229. *AK

I OWN A 2003 CHEVY TRAILBLAZER EXT. I BEGAN SMELLING GAS, AND SOON AFTER NOTICED IT LEAKING FROM MY VEHICLE. AFTER TAKING IT INTO MY LOCAL DEALERSHIP IT WAS FOUND THAT MY FUEL MODULE AND GAS LINES NEEDED TO BE REPLACED BECAUSE OF CORROSION. BECAUSE OF THE WORD CORROSION IT THEN VOIDED BEING COVERED UNDER MY EXTENDED WARRANTY. THE SUV SAT AT THE DEALERSHIP FOR 5 WEEKS BECAUSE OF A NATIONAL BACKORDER ON THE FUEL LINES. SO, WITH HAVING NO VEHICLE RENTAL WOULD NOT BE COVERED BECAUSE IT WAS NOT WARRANTY WORK. I WAS STUCK WITH A $900.00 BILL ON A VEHICLE THAT WAS THREE AND A HALF YEARS OLD. *AK