2003 CHEVROLET TRAILBLAZER EXT Complaints

MY 2003 TRAILBLAZER EXT SMELL OF FUMES. I TOOK IT TO THE DEALERSHIP IN THE FIRST CASE THEY TOLD ME THAT I NEED A NEW GAS TOP AND A SEAL. THE CHECK ENGINE LIKE CAME ON AGAIN THIS TIME THEY TELL ME THAT THE FUEL TANK AT THE SPROUT HAS A LEAK AND I NEED A NEW GAS TANK. *JB

RIGHT PASSENGER WINDOW WAS ROLLED DOWN AND THEN WOULD NOT COME UP. WINDOW GLASS WAS LOOSE WOULD NOT STAY UP. TOOK TO DEALER. WINDOW REGULATOR REPLACED FOR A TOTAL OF $350.00. *NM

WHILE DRIVING ACROSS THE WILLIAMSBURG BRIDGE I SUDDENLY LOST THE ABILITY TO ACCELERATE. THE RPM GAUGE SHOT TO THE HIGH END AND I HAD TO COAST THE VEHICLE OFF OF THE BRIDGE. I WAS TOWED TO THE DEALERSHIP WHO WITHOUT LOOKING AT IT, KNEW IMMEDIATELY THAT THE TRANSMISSION HAD FAILED. I ASKED THE SERVICE TECHNICIAN WAS THIS A COMMON PROBLEM AND HE POINTED ME TO EDMUNDS.COM TO SHOW HOW MANY POSTS THERE WERE CONCERNING THIS PROBLEM. THE DEALERSHIP "OVERHAULED" THE TRANSMISSION AND TOLD ME I SHOULD CONSIDER A TRANSMISSION COOLER. I'VE NEVER TOWED ANYTHING WITH THE VEHICLE AND AM CONCERNED THAT I AM ABOUT TO EXPERIENCE THE SAME PROBLEM, EXCEPT THIS TIME MY WARRANTY IS EXPIRED.

I HAVE A 2003 CHEVY TRAILBLAZER EXT, WHICH ALSO HAS A LEAK IN THE PLASTIC GAS TANK. IT WAS DETECTED IN THE GARAGE BY THE STRONG ODOR. I WAS TOLD BY THE MECHANIC TODAY THAT THIS IS NOT UNCOMMON FOR THIS MODEL. THE PLASTIC BREAK IS WHERE THE NECK IS MOLDED INTO THE TANK. VERY DANGEROUS SITUATION, CONSIDERING MANY HOMES, AS OURS, HAS THE WATER HEATER IN THE GARAGE. *JB

I OWN A 2003 CHEVROLET TRAILBLAZER EXT. I SMELLED A STRONG ODOR OF GAS EMANATING FROM MY VEHICLE RECENTLY. AFTER SOME INVESTIGATING, I DISCOVERED THAT THERE WAS FUEL LEAKING OUT OF THE TOP OF MY FUEL TANK ONLY WHILE THE ENGINE WAS RUNNING. I DROPPED THE FUEL TANK AND DISCOVERED THAT THE METAL NIPPLES FROM THE TOP OF THE FUEL PUMP THAT CONNECT THE FUEL LINES TO THE FUEL PUMP WERE COMPLETELY RUSTED AND WHEN THE VEHICLE WAS RUNNING, FUEL WAS JETTING ALL OVER THE UNDER CARRIAGE OF MY VEHICLE. THE METAL RING THAT HOLDS THE FUEL PUMP TO THE TANK WAS ALSO SEVERELY RUSTED. GM SHOULD KNOW BETTER THAN TO PUT EXPOSED METAL FITTINGS IN A RECESSED TANK WHERE IT IS SUBJECT TO RUST, SALT, CORROSION ETC. I HAD TO REPLACE THE FUEL PUMP AT A SIGNIFICANT COST. I ALSO BELIEVE THAT THIS COULD BE A POTENTIAL FIRE HAZARD AS THE FUEL WAS JETTING ALL OVER THE UNDERCARRIAGE AND ITS PROXIMITY TO THE EXHAUST. MY FITTINGS WERE SO BRITTLE THAT YOU COULD CRUSH THEM WITH YOUR BARE HANDS. LEFT UNCHECKED, UNDOUBTEDLY I WOULD HAVE EXPERIENCED A LOSS OF POWER AND WOULD HAVE BEEN A HAZARD TO THE OTHER VEHICLES ON THE ROAD-YET ALONE PROBABLY WOULD HAVE BEEN STRANDED WHEN THE VEHICLE DIED. THE OLD PARTS ARE AVAILABLE FOR INSPECTION. A FUEL PUMP SHOULD LAST MORE THAT (3) YEARS IN MY OPINION. THIS IS A DESIGN AND/OR PRODUCT FAILURE. *JB

I HAVE A HAD TO REPLACE MY DRIVER SIDE FRONTAL AIR BAG TWICE ALREADY THIS IS GOING ON MY THIRD TIME IN THE LAST YEAR. USING DIFFERENT COMPANIES. THERE IS A PROBLEM WITH THE WIRING AND THE CONNECTOR IN THE HORN OF THE STEERING WHEEL, AND IT WILL NOT STAY CONNECTED. I HAVE CALLED CHEVY SEVERAL TIMES TO SEE IF THERE IS OR WAS A RECALL AND I HAVE BEEN TOLD NO MORE THEN ONCE. *JB

DRIVER SIDE SEAT DETACHED FROM SEAT FRAME RECENTLY. I TURNED TOWARDS THE BACK OF MY CHEVY TRAILBLAZER EXT TO TALK TO MY KIDS AND THE RIGHT SIDE OF THE DRIVERS SEAT BROKE FROM THE SEAT FRAME. UPON INSPECTION, THERE'S A FLIMSY PIECE OF METAL HOLDING THE SEAT TO THE SEAT FRAME. WHEN I BROUGHT IT IN TO THE SERVICE DEALER, HE SAID THE WHOLE SEAT NEEDS TO BE REPLACED AT A COST OF OVER $800. HE SAID I CAN CALL GM TO REPORT THE ISSUE AND THAT THEY MAY OFFER ME A DEAL TO SPLIT THE COST SINCE THE VEHICLE IS OUT OF WARRANTY. I BELIEVE THIS IS A MANUFACTURER'S DEFECT BECAUSE IT HAS NEVER HAPPENED BEFORE IN ANY CAR THAT I'VE OWNED IN THE PAST. WAITING RESOLUTION TO MY COMPLAINT FROM GM, BUT THIS IS CONDITION MAY LEAD TO FUTURE ACCIDENTS!! *JB

MY WIFE AND I HAVE BEEN SMELLING GAS OUTSIDE AND WITH OUR 2003 CHEVY TRAILBLAZER EXT. I BROUGHT IT TO MY MECHANIC AND HE FOUND A SPLIT AT THE TOP OF THE FUEL TANK (NECK FILLER PLATE). I CALLED THE CHEVY NUMBER AND BROUGHT THE VEHICLE TO CROTON AUTO PARK. THEY FOUND THE SAME PROBLEM AND SAID IT WOULD COST MY OVER $750 TO REPLACE THE TANK. I VIEW THIS ISSUE TO BE A MANUFACTURES DEFECT AND ESCALATED THE MATTER TO CHEVY. THEY ARE OFFERING A 50% REBATE TO FIX. I DON'T BELIEVE I SHOULD PAY FOR THIS DEFECT. I HAVE RESEARCHED THE ISSUE AND FOUND MORE PEOPLE THAT HAD THE SAME PROBLEM WITH THEIR CHEVY TRAILBLAZER (SAME MODEL AND YEAR). REFER TO WEB SITE: HTTP://WWW.TOPIX.NET/FORUM/AUTOS/CHEVROLET-TRAILBLAZER/TC82DA8F4UEJOJ6VF/P2#LASTPOST. I AM WAITING ON CHEVROLET'S DECISION AS TO WHO IS GOING TO PAY FOR THIS. I CANNOT DRIVE THIS AUTOMOBILE IN ITS CURRENT CONDITION OUT OF EXTREME FEAR OF FIRE AND EXPLOSION!!!!!!! PLEASE FEEL FREE TO CALL ME FOR MORE DETAILS. *JB

THERE IS A STRONG GASOLINE SMELL NEAR THE REAR OF MY 2003 CHEVROLET TRAILBLAZER EXT. NO DRIPPING GASOLINE IS VISIBLE. *NM

WE HAVE A 2003 CHEVY TRAILBLAZER AND HAVE HAD NOTHING BUT PROBLEMS WITH IT SINCE WE BOUGHT IT BRAND-NEW. IT WAS BACK IN THE SHOP WITHIN 2 MONTHS OF PURCHASING IT DUE TO NEEDING THE ENTIRE FUSE BOX REPLACED. IT HAS BEEN BACK IN FOR REPAIRS NUMEROUS TIMES FOR ENGINE FAILURE AND PROBLEMS WITH THE GAUGES. WE HAVE HAD THE ENTIRE SPEEDOMETER PANEL REPLACED AT OUR EXPENSE AND SPENT $1200 ON REPAIRS RELATED TO THE TRANSMISSION. WE RETURNED IT TO THE DEALER 2 MONTHS LATER DUE TO THE EXACT SAME DIFFICULTIES WITH THE ENGINE STALLING AND THEY TOLD US THE COMPUTER NEEDED TO BE REPROGRAMMED. WE PAID FOR THAT AND NOT ONE WEEK LATER THE VEHICLE IS CONTINUING TO STALL ON US. IT HAS BEEN EXTREMELY DANGEROUS AND IN AT LEAST ONCE CIRCUMSTANCE HAS ALMOST CAUSED AN ACCIDENT. THIS VEHICLE IS UNSAFE TO DRIVE. THE ENGINE HAS QUIT ON US ON AT LEAST 12 DIFFERENT OCCASIONS WITHIN THE LAST 2 MONTHS, DESPITE BEING IN FOR REPAIRS TWICE FOR THE SAME ISSUE. WE ARE EXTREMELY DISAPPOINTED IN THIS VEHICLE AND ARE SADDENED BY THE FACT THAT WE HAVE SPENT SO MUCH MONEY AND TO NO AVAIL. WE HAVE SINCE LEARNED THAT MANY, MANY OTHER PEOPLE ARE EXPERIENCING THE SAME TROUBLE. WE ARE TAKING IT BACK TO THE DEALER TOMORROW AND TRADING IT IN. WE NEED SOMETHING THAT IS RELIABLE AND SAFE OUT ON THE ROADS. AND THIS VEHICLE IS DEFINITELY NOT SAFE.