2006 CHEVROLET UPLANDER Complaints

I KEPT GETTING FALSE CODES WHEN USING TEST METER TO DIAGNOSE AND REPAIR VEHICLE AFTER REPLACING FUEL PUMP EVAP CANISTER GAS CAP PLUGS WIRES BRAKES ROTORS THE ECM HAD IT REPROGRAMMED TO CAR I WAS STILL HAVING THE SAME PROBLEMS AFTER CAREFUL INSPECTION I FOUND UNDER THE DRIVERS SIDE PASSENGER SEAT A SERIES OF LINES THAT JUST SIMPLY PLUG THROUGH THE VEHICLE EXPOSED TO ALL ELEMENTS WHEN DRIVING I CAREFULLY UNPLUGGED THE WIRES AND NOTICED THAT THEY WERE ALL CORRODED AND NOT FUNCTIONAL WHILE NOTICING THIS I HAD NOTICED ITS PROXIMITY TO THE FUEL TANK AND FUEL RAILS JUST DAYS PRIOR TO MY REPAIRS I HAD SMELLED SOME BURNING SMELL IT IS TO MY OPINION THAT THIS IS NOT ONLY A SAFETY ISSUE BECAUSE ITS CLOSENESS TO FUEL RAILS AND TANKS BUT IT IS POOR DESIGN IN THE MANUFACTURING OF THE VEHICLE I NOW HAVE A VEHICLE THAT SITS IN MY DRIVEWAY THAT I AM AFRAID TO PUT MY FAMILY IN BECAUSE OF THE OPPORTUNITY TO EXPLODE AT ANY GIVEN TIME OR CATCH ELECTRICAL FIRE AT THE VERY LEAST I HAVE PICS OF THE WIRES REMOVED AS WELL AS THE LOCATION OF THE WIRES PLEASE HELP SINCERELY [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I BOUGHT THIS VAN AROUND 2010,THE MILEAGE WAS AROUND 60,000. THE FIRST THING I NOTICED WAS THE LIGHT. I WAS PULLED OUT BY THE POLICE ABOUT MY LIGHT. I WENT STRAIGHT TO AUTO ZONE AND CHANGED IT. I HAVE CHANGED MY BULBS MORE THAN TWENTY TIMES. I GOT WARNINGS. SECONDLY, MY REMOTE CONTROL HAVE BEEN ACTING OUT. I CHANGED THE BATTERY SEVERAL TIMES. IT WILL WORK FOR ONLY FEW HOURS AND STOP. I STARTED LOCKING MY DOORS MANUALLY,ONLY THE PASSENGER DOOR IS LEFT TO CONTROL THE BUTTON. THE WORST EXPERIENCE THAT LED ME TO FILE THIS REPORT IS THE FUEL TANK AND THE STEERING WHEEL. MY VAN HAD STOPPED MORE THAN TWENTY TIMES WITHOUT WARNING,EACH TIME I BOUGHT GAS AND IT WILL START WORKING. THE LAST EXPERIENCE IS STILL FRIGHTENING TO ME. I WAS DRIVING ON A HIGHWAY AT 55M/HR MY GAUGE WAS SHOWING JUST BELOW HALF TANK,ALL OF A SUDDEN MY VAN ACCELERATED AND SOUND WENT OFF,I IMMEDIATELY MADE A LEFT TURN ON A GREEN LIGHT TO A STREET THAT WENT DOWN THE HILL. I COULD NOT CONTROL MY VAN NO MORE,I TURNED OFF THE KEY AND IT WENT TO A STOPPED WITH A BANG NOISE. FIRE FIGHTERS WERE AROUND THAT AREA,THEY IMMEDIATELY RUSHED TO HELP AND SUGGESTED I BUY GAS WHICH I DID AND MY VAN STARTED WORKING AGAIN.I APPROACHED SOMEBODY USING THE SAME TYPE OF VAN,SHE SAID SHE EXPERIENCED SAME ISSUES SEVERAL TIMES. MY DAUGHTER HAD AN ACCIDENT WITH THIS VAN ONCE,I BEGIN TO WONDER WHAT MIGHT HAVE CAUSED IT ALTHOUGH SHE SAID ANOTHER DRIVER CAUSED IT AND FLED,NOW EVEN IF MY GAS IS SHOWING FULL TANK I WILL MAKE SURE I STILL BUY MORE.I AM SCARED TO GIVE MY VAN TO MY CHILDREN TO DRIVE.I ESCAPED ACCIDENT MORE THAN FOUR TIMES BECAUSE OF THE SAME ISSUE.I DON'T DRINK,NEVER SMOKE, I USE MY VAN MAINLY TO WORK.RECENTLY THE ROD THAT HOLDS THE TIRE DON'T KNOW THE NAME JUST BROKE INTO TWO WITHOUT ANY REASON.I WAS JUST TRYING TO REVERSE AND I NOTICED MY VAN WILL NOT MOVE. CAME DOWN AND I SAW THAT. I JUST REPLACED MY TAIL LIGHT FEW DAYS AGO. *TR

THE REAR POWER DOORS ON MY 2006 UPLANDER HAVE CONSTANTLY NEEDED SERVICE. THERE HAVE BEEN TIMES THE DOOR ALARM GOES OFF WHEN THE DOOR IS NOT ACTUALLY OPEN, WE HAVE TO PULL OVER AND RESET THE DOORS BY OPENING AND CLOSING THEM. THE ROLLER BEARINGS HAVE BEEN REPLACED TWICE ON THE DRIVERS SLIDER. BOTH DOORS HAVE BEEN SERVICED AT LEAST 10 TIMES FOR IMPROPER CLOSING, FAULTY SENSOR ALARM DINGING EVEN WHEN THE DOORS ARE CLOSED, SOMETIMES IT TAKES MANY ATTEMPTS FOR THE DOORS TO CLOSE. THE DRIVER SIDE DOOR ALMOST CAME COMPLETELY OFF WHEN THE ROLLER BEARINGS BROKE. THESE DOORS ARE UNSAFE AND BEYOND DEFECTIVE. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET UPLANDER. THE CONTACT STATED THAT THE REAR SLIDING DOOR ON THE DRIVER'S SIDE OCCASIONALLY OPENED AUTOMATICALLY. THE DEALER WAS NOTIFIED AND ADVISED THE CONTACT TO BRING THE VEHICLE IN FOR INSPECTION. THE VEHICLE WAS IN THE PROCESS OF BEING TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 71,000.

VEHICLE HAS OCCASIONAL FLICKERING HEADLIGHTS. THERE ARE OTHER OCCASIONAL ELECTRICAL SYSTEM PROBLEMS THAT LAST FOR ONE DAY ONLY, BUT ALL DAY, AND THE NEXT DAY ARE GONE, UNTIL THEY REPEAT, BUT ONLY FOR ONE DAY, EVERY TIME. THESE ARE: THE RADIO WILL NOT WORK; THE ALARM AUDIBLE SIGNAL AND DASH INDICATOR LIGHT FOR THE PARKING BRAKE BEING ON WILL SOUND WHEN DRIVING, EVEN THOUGH PARKING BRAKE IS NOT ON; AND THE REAR HEATER FAN WILL COME ON AND STAY ON AT HIGH SPEED EVEN THOUGH IT IS SWITCHED OFF AT THE DASH. HAVE TAKEN THE VAN TO TWO DEALERS AND THEY COULD NOT DUPLICATE. TOOK VEHICLE TO DEALER SERVICE MANAGER WHILE THE REAR FAN WAS BLOWING ON ITS OWN. HE OBSERVED THE PROBLEM, BUT I HAD TO MAKE AN APPOINTMENT FOR THE NEXT WEEK, AND THEN, OF COURSE, THE FAN WAS NOT BLOWING. I NOW OPEN THE FUSE BOX UNDER THE HOOD AND PULL THE REAR HEATER BLOWER FAN FUSE WHEN THIS HAPPENS; AND REPLACE THE FUSE IN THE MORNING OF THE FOLLOWING DAY WHEN (I KNOW BY NOW) THE PROBLEM IS CORRECTED... UNTIL THE NEXT TIME IT HAPPENS AGAIN. THE ODD THING IS THAT THESE THREE PROBLEMS WILL ONLY LAST FOR ONE DAY. BUT THEY WILL LAST THE WHOLE DAY. THE PARKING BRAKE ALARM WILL SOUND SPORADICALLY AT THE START OF THE DAY, BUT WILL BE A CONSTANT RINGING WHILE BEING DRIVEN AS THE DAY GOES ON. BUT THE NEXT DAY THE PROBLEM IS GONE, UNTIL IT HAPPENS AGAIN, WEEKS OR MONTHS LATER. *JB

I BOUGHT MY UPLANDER AT DEALERSHIP MILAGE WAS AT 24,000. THE DOOR WOULD OPEN AND NOT CLOSE WE FINALLY GOT THIS FIXED I HOPE. JUST YESTERDAY AT MILAGE 45,000 WE HAD TO REPLACE TIE ROD ON PASSENGER SIDE. FOUND OUT THAT IT DID NOT HAVE GREASE PIN ON IT CALLED MANUFACTOR AND THEY SAY SOMEONE HAD TO HAVE REPLACED IT. I DO NOT BELIEVE IT HAD EVER BEEN REPLACED AND THIS IS WHAT IS CAUSING TIRE WEAR AND VIBRATIONS IN THE UPLANDERS WHICH ALSO COULD CAUSE ACCIDENTS EVEN DEATHS. ALSO WHEN DRIVING ALL LIGHTS WILL GO OFF UNTIL YOU HIT BRAKES I HAVE HAD DIAGNOTICS CHECKED TO SEE IF ANYTHING WOULD SHOW UP. NOTHING DOES. SO THIS IS A MAJOR CONCERN ALSO . THERE SEEMS TO BE THE SAME PROBLEMS LISTED FROM ALMOST EVERYONE AND SOME OF THESE THINGS COULD COST CONSUMERS THEIR LIFE OR THEIR FAMILIES. WHILE I LIKE THE UPLANDER I AM CONCERNED THAT THE SAFETY ISSUES ARE NOT BEING HANDLED BY MANUFACTOR AND NO ONE SEEMS TO CARE. WHAT WILL IT TAKE TO MAKE THIS VEHICLE SAFE. *TR

THIS UNIT WHEN STEERING INPUT TO THE LEFT MAKES A HUMMING NOISE SYNONYMOUS TO THE STEERING KNUCKLE RECALL BULLETIN. WHEN I TOOK IT TO THE DEALER FOR DIAGNOSIS THEY ASKED FOR SERIAL NUMBER THAT I PROVIDED AND THEY STATED MY UNIT IS NOT UP FOR THE RECALL AND NOW WHAT IS MY RECOURSE?? I HAVE SPOUSE AND 3 TODDLERS AND COMMUTE DAILY AT 110 KM PER HOUR FOR OVER 300 KM. I AM QUITE WORRIED AND AFRAID IF SOMETHING SHOULD FAIL MECHANICALLY AS THE NOISE IS FROM THE DRIVERS SIDE AND PUTS US IN THE DIRECT LINE OF ONCOMING TRAFFIC FOR A POTENTIAL HEAD ON COLLISION AND THE DEALER REPS WERE NOT AT ALL SYMPATHETIC OR CONCERNED AND JUST BRUSHED ME OFF WITHOUT OFFERING AN OPTION AT THE VERY LEAST. ANY HELP IS MUCH APPRECIATED. THANK YOU. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET UPLANDER.THE CONTACT STATED THAT WHILE DRIVING 5 MPH THE VEHICLE EXHIBITED AN ABNORMAL SOUND FROM THE FRONT END. THE CONTACT TOOK THE VEHICLE TO A DEALER. THE DEALER DIAGNOSED THE FAILURE AS A FRACTURED TIE ROD. THE CONTACT ALSO STATED THAT THE REAR BRAKES WOULD MALFUNCTION AT LOW SPEEDS, INCREASING THE STOPPING DISTANCE. THE DEALER REPAIRED THE FRONT SUSPENSION AND THE REAR BRAKES. THE FAILURE AND CURRENT MILEAGE WAS 61,000. UPDATED 05/10/12*LJ

I BOUGHT MY 2006 CHEVY UPLANDER USED WITH 74,000 IN FALL OF 2011. WHILE AT AN BUSY INTERSECTION STOP SIGN, THE TRACTION CONTROL AND STABILITY SERVICE LIGHTS CAME ON, THEN ALL DASHBOARDS LIGHTS CAME ON AND THE VAN STALLED. ALL LIGHTS (BOTH INTERIOR AND EXTERIOR) SHUT OFF AND I COULDN'T RESTART VEHICLE. ROAD CONDITIONS WERE DRY AND CLEAR. AFTER ROLLING ONTO THE SIDE OF THE ROAD AND LETTING IT SIT FOR AROUND 5 MINUTES, IT STARTED AND DID NOT HAVE ANY MORE PROBLEMS. THE FOLLOWING WEEK, IT HAPPENED AGAIN WHILE DRIVING ON THE HIGHWAY. ROAD CONDITIONS WERE SLICK AND SNOWY AND THE TRACTION CONTROL AND STABILITY LIGHTS CAME ON, THEN THERE IS A "CLICKING" SOUND IN STEERING COLUMN. THE VAN STALLED, STARTED, STALLED, AND STARTED AGAIN ON WHILE I AM DRIVING DOWN THE ROAD. I WAS ABLE TO TURN ONTO A COUNTRY ROAD AND SHUT IT OFF (BASICALLY IT DIED). I WAITED AND RESTARTED TO TRY TO GET TO TOWN. IT BEGAN HAPPENING AGAIN AND THIS TIME I LOST CONTROL AND ENDED UP IN A FIELD (LUCKILY NO INJURIES). AFTER GETTING IT OUT I TOOK IT TO THE DEALERSHIP (NO ISSUES ON WAY THERE) THEY HOOKED IT UP AND THERE WEREN'T ANY CODES COMING THROUGH. TECH DROVE IT OVER 4 DAYS AND IT NEVER HAPPENED TO HIM. THEN TODAY AS I WAS DRIVING INTO TOWN, IT HAPPENED AGAIN. THE TRACTION/STABILITY LIGHT COMES ON, YOU HEAR A "CLICKING" SOUND IN THE STEERING COLUMN, AND IT BEGINS TO DIE/START AGAIN WHILE CONTINUING TO DRIVE. EVENTUALLY IT JUST DIES. I WILL LET IT SIT FOR A TIME AND THEN RESTART IT. DEPENDING ON HOW LONG IT SITS (OVER AN HOUR IS BETTER) IT WILL EITHER CONTINUE WITH ISSUES OR DRIVE NORMALLY FOR UPTO A WEEK BEFORE ISSUE BEGINS TO REOCCUR. *TR

OUR 2006 CHEVY UPLANDER FIRST STARTING HAVING PROBLEMS AT ABOUT 20,000 MILES WHEN OUR TIRES (CONTINENTAL BRAND THAT CAME INSTALLED ON BRAND NEW VEHICLE FROM DEALER) NEEDED TO BE REPLACED DUE TO SEVERE CUPPING ON ALL 4 TIRES. WE WERE TOLD IT WAS AN ALIGNMENT ISSUE, SO WE HAD THE TIRES REPLACED AND HAD A 4 WHEEL ALIGNMENT. TIRES NEEDED TO BE REPLACED AGAIN AT 45,000 MILES DUE TO SAME CUPPING ISSUE. AGAIN, ANOTHER 4 WHEEL ALIGNMENT WAS PERFORMED. FUEL SENSOR WAS READING EMPTY ON A FULL TANK OF GAS AND THE FLOAT WAS REPLACED AT 16,000 MILES. NOW AT 50,000 MILES, SENSOR READS CONSISTENTLY EMPTY AGAIN ON A FULL TANK OF GAS. SEVERE RATTLING/VIBRATION FROM UNDER THE VEHICLE AT HIGHWAY SPEEDS THAT RESONATES FROM BETWEEN THE FRONT DRIVER AND PASSENGER SEATS. (POSSIBLY E-BRAKE CABLE OR HEAT SHIELD?) BOTH FRONT AND REAR SHOCKS AND STRUTS NEEDED TO BE REPLACED AT 54,000 MILES. THERE IS A SEVERE ISSUE CONCERNING THE STEERING. WHEN TURNING EITHER LEFT OR RIGHT STEERING HAS SOME SLOP. THE RACK AND PINION NEED TO BE REPLACED. THE ELECTRONIC STABILITY CONTROL SENSOR, ABS SENSOR, AND TRACTION CONTROL SENSOR ALL ILLUMINATE AT RANDOM TIMES WHILE NORMAL DRIVING IS OCCURRING. *TR