2017 CHEVROLET VOLT Complaints

My service engine light came on. After that happened, my engine started to get hot. It got up to 230degF, received a reduced propulsion message and wanted to shut down when going 70mph on the interstate (depended on the construction). Quick reaction on my side before the engine shut down I had "held" the battery (which i do for long trips to ensure options in event of emergencies). Meaning i still had energy in the battery that could be used to propel the vehicle. I was able to shut down the engine by unholding the battery before losing control of the vehicle due to no propulsion. The electric propulsion took over and I could get off the freeway. Conditions were: I was driving in a rain storm on a very busy interstate around Eau Claire wisconsin right around 5-6pm with lots of road construction. If I would have lost the engine and power, I would have crashed at a high rate of speed. I would have lost steering, windshield wipers and headlights. Investigation showed that fuse F03 (walk home fuse) was blown. Further investigation showed that the EGR Valve circuitry was causing this failure. After unplugging EGR valve and replacing the fuse, engine was able to run and not overheat. Plug the EGR valve back in and the fuse blows again This is a well known issue on these vehicles and has been around since 2019-2020. Lots of data and information available on this issue on the internet. To make the issue worse. No parts are available for replacing this faulty valve at the moment. Only 6 valves available in the whole USA with those promised to other customers (i Called the dealers). Additionally there are more vehicles waiting for these valves.. Vehicle goes to the shop on [XXX] for confirmation of issue and get on a waiting list for the EGR Valve. I can't believe this is allowed to continue with GM. THis needs to be fixed!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While car will turn on as normal, wheb put I to drive is says "Action Required - Shift to Park". The CEL code indicates, among other things, "EV/Hybrid Battery ppsitive contactor circuit stuck closed". I've read this has happened to may owners. Reading online seems to indicate

Shift to park warning comes and car will will not shut down I have already had this repaired in 2019

While driving on the interstate car suddenly flashed a "reduced propulsion power " warning indicator. At this time the car was speed limited and made us a liability on the interstate. We were about 80 miles from our home so ended up driving the car back home being speed limited. Took car into the shop and was told the EGR valve was bad which kept causing the "no walk fuse" to blow. Ended up having the EGR valve, gasket and cap replaced. All together with labor total for repair was $1,738 on a car that we had only been driving for a year. Bad EGR valves seem to be very commonplace for 2nd generation Chevy Volts but it seems GM refuses to do anything about this issue. I have no plans to every purchase another GM vehicle. Very frustrated!

My 2017 Chevy Volt has been making a clicking noise coming from the brake booster assembly since I have bought it. When your foot is released from the brake pedal, there is an audible click (3-4 times a second) inside of the cabin and I've decided to make a formal complaint as GM isn't taking the appropriate action to fix this issue. My reasoning is that this issue is not only common on the Chevy Volt, but also the Chevy Bolt as they share the exact same brake booster. For the Volt, dealers are instructed to replace the Brake Pedal Retainer - GM (39081933) and the Brake Master Cylinder - GM (84006919). This repair is often quoted in excess of $2,000 even though there is a very high likelihood of the issue returning even when the parts are replaced. For the Chevy Bolt, dealers were instructed to stop replacing the brake booster as they determined there was a software fix that could solve the issue. There was a TSB regarding this which details both the problem and the repair procedure (# [XXX]) [XXX] While GM fixed this issue on the Bolts, the Volts have the exact same issue and owners are being directed to spend $2,000+ to make a repair that won't even fix the issue. GM needs to release the software fix for the Volts so that the issue can be resolved properly. This burdens current Volt owners improperly, as GM has proven that a software release can fix this but has thus far refused to address and implement it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Chevrolet Volt. The contact stated while driving at approximately 70 MPH, the message "Reduce Propulsion" was suddenly displayed, and the vehicle decelerated to 30 MPH. The vehicle was later taken to the local dealer who diagnosed that the ERG was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 22,000.

Had to replace EGR valve after losing power on the highway back in 2022. Lost power steering and reduced engine power while driving at highway speeds, luckily was able to get off the highway and limp the car back to my house. I almost crashed due to loosing engine power and power steering. It's appears to be a BECM issue.

We bought the car for our son when he began to drive. We liked the idea that it was gas and electric. At the time, our son was into electric vehicles. At 44, 000 miles, 7/10/20 the car was taken to the dealership. The engine light was on at this point, the message displayed "Propulsion Power is Reduced". Once the diagnostic was done it was said that the EGR valve needed replacing. Of course, this is during the of COVID. Everything was shut down. No one is working. It is now a wait game. Prior to this our Chevy Volt has been in and out of the dealership with either recall or something else. We enjoy the car because of how it operates with gas and electric. Fast forward it is 80,000 miles now, and the car is at the dealership again. It has currently been there for almost a month. After blowing fuses it has be diagnosed as the EGR valve needs replacing again. The part is not available currently. No one seems to know when it might be available. The part cannot be purchased from our local distributor. GM is the only ones who makes it is our understanding. There is no other dealership near us that has certified technicians who can work on them. We called around and asked. We want to know what the solution is. How can this be prevented? We were over an hour away from home and no dealership was open when it went out the last time. It became worse to the point that we were stopped on the road with flashers on because it was not safe to pullover. Prayer works.

On [XXX] while traveling at highway speed my Chevrolet volt abruptly lost propulsion and an alert was displayed to pull over and turn car off. I was on [XXX] in California a 4 lane highway forced to cross 3 lanes of traffic at an exceptionally slow speed in heavy traffic. It is a miracle a crash did not occur. Fortunately other drivers were aware and able to stop or quickly change lanes. AAA towed directly to Stewart Chevrolet in Colma Ca. It was diagnosed and I was advised it is under warranty HOWEVER parts are on back order. Today [XXX] ~ the car still has not been repaired and I have been advised parts will not ship until September 2024. This is both dangerous and unacceptable. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Chevrolet Volt. The contact stated that while driving at approximately 60 MPH, the Battery Range Zero Miles message displayed, and the check engine warning light illuminated. The Propulsion Power Reduced message was then displayed, and the engine inadvertently shut off. The contact coasted the vehicle to the side of the road and shifted the transmission into park(P) when the Shift to Park message was displayed. The vehicle was towed to the dealer, who reprogrammed the power inverter module, and cleared the DTC codes. The failure recurred 60 days later, and the vehicle was towed to Chevrolet Van Nuys (5949 Van Nuys Blvd, Van Nuys, CA 91401), where the 12V battery was replaced and the DTC codes were cleared; however, the failure persisted. The vehicle was towed back to Chevrolet Van Nuys (5949 Van Nuys Blvd, Van Nuys, CA 91401), but the vehicle was not yet diagnosed or repaired. The manufacturer was not made aware of the failure. The contact related the failure to NHTSA Action Number: PE23022 (Electrical System). The failure mileage was 61,956.