2013 CHEVROLET VOLT Complaints

WHILE COMING TO A STOP AT A MODERATE RATE OF DECELERATION, I NOTICED THAT MY DRIVERS SEAT HAD FORWARD/BACKWARD PLAY IN IT. THE ISSUE WAS IDENTIFIED WHEN COMING TO A STOP AND NOTICING THAT MY SEAT BACK SHIFTED FORWARD (~1/2" OF PLAY). I WAS ABLE TO REPLICATE THE ISSUE AT A STOP BY SHIFTING MY WEIGHT IN THE SEAT. ALL MOTION APPEARS TO SOURCE FROM THE RECLINING MECHANISM, NOT THE SEAT RAILS. THIS ISSUE WAS PRESENTED TO THE CHEVROLET DEALERSHIP BUT THE RESPONSE WAS THAT THE ISSUE WAS IDENTIFIED IN A NEW VEHICLE SO IT WAS LABELED AS "INTENDED OPERATION." A REPEAT INVESTIGATION IN SEPTEMBER 2014 ALSO PRODUCED THE SAME RESPONSE. AS AN INTEGRAL PART OF THE SAFETY SYSTEM IN THE VEHICLE, IT IS INAPPROPRIATE FOR A SEAT TO HAVE PLAY IN THE RECLINING MECHANISM AND EQUALLY AS INAPPROPRIATE FOR THAT TO BE CONSIDERED "INTENDED OPERATION." THE PASSENGER SEAT DOES NOT EXHIBIT THESE ISSUES, AND A REVIEW OF THE GM-VOLT.COM FORUMS INDICATES THAT WHILE THE PROBLEM EXISTS IN OTHER VEHICLES, IT IS BY NO MEANS UNIVERSAL ACROSS THE MODEL. *TR

I'VE LEASED MY 2013 VOLT FOR 1 1/2 YEARS. JULY 3RD I GOT 2 FLAT TIRES (BOTH DRIVER SIDE, REAR AND FRONT). I BOUGHT 2 NEW TIRES AND THE SERVICE AT CHEVY PUT THEM ON THE 2 FRONT WHEELS. EXACTLY 2 MONTHS LATER, I GOT 2 MORE FLAT TIRES (PASSENGER SIDE, FRONT AND REAR). I FIND IT INCREDIBLY HARD TO BELIEVE THAT 4 NEW TIRES ARE NOW FLAT. I'VE BEEN DRIVING FOR 40 YEARS AND HAVE OWNED MANY DIFFERENT NEW CARS, AND THIS HAS NEVER HAPPENED! I FEEL THERE IS SOMETHING EITHER ABOUT THE CAR BEING ELECTRIC OR THE TYPE OF TIRES THAT IS CAUSING FLATS. BESIDES BEING VERY EXPENSIVE, IT IS ALSO VERY UNSAFE TO DRIVE ON FLAT TIRES. *TR

CHEVY VOLT IS AN EXTENDED RANGE ELECTRIC VEHICLE, IT USES A GAS POWERED GENERATOR TO PROVIDE ELECTRIC POWER FOR DRIVING IF THE BATTERY HAS DROPPED BELOW A CERTAIN VOLTAGE. I PARKED MY VEHICLE IN MY GARAGE AT HOME AND NEGLECTED TO POWER DOWN THE ELECTRIC SYSTEMS IN THE VEHICLE. THERE IS A BLUE POWER BUTTON ON THE CENTER CONSOLE, IF YOU DO NOT PRESS THIS BUTTON VERY DELIBERATELY THE SYSTEM DOES NOT POWER DOWN. THIS IS NOT READILY APPARENT SINCE THE CENTER CONSOLE STAYS LIT EVEN WHEN POWERED DOWN. I OPENED THE CHARGE PORT AND PLUGGED THE VEHICLE IN. IF THE VEHICLE IS POWERED DOWN THE CAR WILL GIVE AN AUDIBLE BEEP AND THE CHARGE LIGHT WILL GO FROM ORANGE TO GREEN AFTER A PERIOD OF ABOUT 4-5 SECONDS. IF THE VEHICLE IS NOT POWERED DOWN THE LIGHT STAYS ORANGE AND NO WARNING IS GIVEN TO THE OPERATOR. I LEFT THE VEHICLE, I HAD THE REMOTE WITH ME. THE FOLLOWING MORNING MY WIFE DISCOVERED THE CAR IN THE GARAGE WITH THE GENERATOR RUNNING AT VERY HIGH RPM'S THE TEMPERATURE IN THE GARAGE WAS VERY HOT, THE DOOR HANDLE TO THE GARAGE WAS HOT TO THE TOUCH. THE CAR USED ALMOST ALL OF IT'S GASOLINE SUPPLY, ABOUT 10 GALLONS, THAT EQUATES TO ABOUT 190 POUNDS OF CO2 PRODUCED IN MY HOME. I BACKED THE CAR OUT OF THE GARAGE, THE CONCRETE UNDERNEATH THE CAR WAS TOO HOT TO TOUCH AND STILL WARM 10 HOURS LATER. THE CAR WAS TOWED TO MY LOCAL CHEVROLET DEALER, THEY REPAIRED THE HEAT DAMAGE AND RETURNED THE CAR TO ME. I HAVE SINCE TESTED THIS SAME SCENARIO AND THE VEHICLE WILL START ITS GAS POWERED GENERATOR IF LEFT POWERED ON. NO GAS MOTOR IS RUNNING WHEN VEHICLE IS PARKED, IT IS OPERATING ON ITS BATTERY SYSTEM. ONCE THE BATTERY IS DEPLETED IT WILL SELF START ITS GENERATOR EVEN IF: 1 THE CAR IS IN PARK 2 THE CHARGE DOOR IS OPEN 3 THE CAR IS PLUGGED IN TO IT'S CHARGER 4 THERE IS NO DRIVER IN THE DRIVERS SEAT 5 THE VEHICLE IS NOT MOVING 6 THE REMOTE NOT IN THE VEHICLE. FAILURE TO WARN VEHICLE IS ON. *TR

THE CAR'S ELECTRICAL / SOFTWARE ISSUES CAUSED (1) ALL OF THE WINDOWS TO ROLL DOWN IN UNISON (IN FOR REPAIR 3 TIMES TO FIX THIS ONE), (2) CAUSED THE CAR TO NOT RECOGNIZE THAT IT WAS IN "PARK", THUS NOT SHUTTING OFF, AND (3) CAUSED THE CAR TO LOSE POWER WITHOUT TOUCHING ANY OF THE BUTTONS ON THE CONSOLE (I.E. THE "DRIVE" BUTTON OR THE "POWER" BUTTON). THE LATEST INCIDENT OCCURRED LAST FRIDAY (AUGUST 1, 2014) WHEN THE CAR JUST LOST POWER WHILE I WAS DRIVING AT 65 MPH ON I-85 NORTH AT AROUND 4:00PM. I HAD TO GET OVER FROM 4 LANES OF TRAFFIC WITH NO POWER AT ALL IN THE CAR AND LUCKILY DID SO WITHOUT INCIDENT. ONSTAR'S DIAGNOSTICS SHOWED THAT THE ELECTRICAL SYSTEM, BRAKING SYSTEM, ENGINE, AND OTHER PARTS OF THE CAR SHOWED THE CAR NEEDED IMMEDIATE ATTENTION. I PUT THE CAR IN PARK AND WHILE STILL WITH ONSTAR THE DASHBOARD LIT UP AND THE POWER BUTTON LIT UP TOO. I HIT THE POWER BUTTON AND DROVE STRAIGHT TO THE RICK HENDRICK CHEVY DEALERSHIP IN DULUTH. WHEN I WENT TO PICK THE CAR UP LATER SATURDAY MORNING, I WAS TOLD THAT THERE'S NOTHING THEY CAR DO BECAUSE THEY CAN'T RECREATE THE PROBLEM. THEY HAVE REFLASHED VARIOUS ECUS, BUT AT THE END OF THE DAY CANNOT "RECREATE" THE PROBLEMS AND CANNOT FIX THEM. SO THEY JUST WIPE THEIR HANDS CLEAN OF THESE ISSUES AND ACT LIKE THEY DON'T EXIST. (THE SERVICE MANAGER ACTUALLY CALLED ME "IGNORANT" ONCE AND LATER APOLOGIZED.) I PRAY IT DOESN'T TAKE PEOPLE DYING IN THESE CARS BEFORE CHEVROLET AND/OR GENERAL MOTORS DOES SOMETHING TO FIX THEM. *TR

TL* THE CONTACT OWNS A 2013 CHEVROLET VOLT. WHILE PULLING OUT THE DRIVEWAY AT 10 MPH, THE PARKING BRAKE AUTOMATICALLY APPLIED AND THE VEHICLE STALLED. THE CHECK ENGINE INDICATOR ILLUMINATED. THE DEALER STATED THAT WATER LEAKED INTO THE BATTERY CHARGING RECEPTACLE CAUSING THE RESISTANCE OF THE INTERLOCK TO DROP OVER A PERIOD OF TIME, WHICH CONTRIBUTED TO THE PARKING BRAKE BECOMING ENGAGED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 6,500. UPDATED 12/2/14*CN THE CONSUMER STATED THE INCIDENT CAUSED THE TRANSMISSION TO GO INTO PARK.

WHEN IN LOW GEAR (HIGHER REGENERATIVE BRAKING), WHEN BRAKING AND GOING OVER SOME BUMPS, THE REGEN BRAKING STOPS CAUSING A FEELING OF A LURCH FORWARD. A 'LOW TRACTION" LIGHT APPEARS. THIS CAUSES A REDUCTION IN BRAKING FORCE OF APPROXIMATELY 35BHP, A VERY UNSAFE CONDITION. AN ANTI-LOCK BRAKE STYLE PULSATION OF THE REGEN SHOULD BE EMPLOYED, NOT A DISCONTINUATION OF THE REGEN BRAKES. *TR

THE VEHICLE HAS REPEATEDLY SHUT DOWN WHILE DRIVING/FAILED TO START SINCE JUNE 2013. THE VEHICLE HAS BEEN IN SERVICE DUE TO REPAIRS = 42 DAYS IN THE LAST 10 MONTHS. GM CONTINUES TO REPLACE/RECALL PARTS ON THE HYBRID BATTERY AS WELL AS OTHER PARTS CONCERNING SECONDARY PROBLEMS. I AM AFRAID THIS VEHICLE WILL SHUT DOWN AGAIN WHILE I AM DRIVING CAUSING AN ACCIDENT HURTING ME OR OTHERS ON THE ROAD. CLEARLY, IT IS A POTENTIAL DEATH TRAP. *TR

LETTER FROM CONSTITUENT REGARDING HIS WIFE 2013 CHEVROLET VOLT, WHO HAVING ISSUES WITH THE HVAC SYSTEM NOT COOLING THE REAR SEATS WHEN THE TEMPERATURE WAS NEAR 100 DEGREES; REQUESTING THAT GM ACCEPT THE RETURN OF THE VEHICLE AND PURCHASE PRICE BE REFUNDED.*SD THE CONSUMER STATED THE WINDOWS WOULD FOG UP WHENEVER HUMIDITY WAS PRESENT, THE NAVIGATION SYSTEM, WAS READING THE VEHICLE WAS IN DETROIT, THE RE-GENERATIVE BRAKING SYSTEM AND ACCELERATION HAD DOWNGRADED AFTER THE LAST SOFTWARE UPDATE.*JB

WHEN A CELL PHONE IS PLACED ON THE CENTER OF THE PASSENGER SEAT, THE PASSENGER SEAT BELT WARNING LIGHT ILLUMINATES AND ARMS THE PASSENGER AIR BAG. NO WEIGHT REQUIRED. *TT

TL* THE CONTACT OWNS A 2013 CHEVROLET VOLT. THE CONTACT STATED THAT HE ERRONEOUSLY DEPRESSED THE DRIVE MODE BUTTON AND ALL THE ELECTRICAL POWER FAILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURE WAS NOTIFIED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 7,500 AND CURRENT MILEAGE WAS 7,900.