2016 CHEVROLET VOLT Complaints

On [XXX] the check engine light turned on in my 2016 Chevy Volt (VIN: [XXX] miles 145,xxx). I was 2 hours from home in the freezing cold snow but thankfully the vehicle allowed me to drive home without any issues (no reduced propulsion power). When I returned to the vehicle to have a diagnostic check the error light disappeared and I was unable to check for error codes. Still no issues driving under EV/gasoline. Later that day, the car stopped going completely, no shifting out of park either. EV range was reporting 0 miles despite having full charge. I plugged in the charger but it would not work (first time this happened), " Not able to Charge" message displayed. After cycling power the EV range was full range and I was able to shift into drive again. These issues were intermittent over 3 weeks, frequently standing me temporarily. After cycling power, opening and closing the door, cycling power again, the car would function normally and I could drive under battery or gasoline power. I managed to capture these error codes while the MIL light was on: U2603, U2604, U2605, U2606, U2617, U2618, U2619, U2620, U2621, U2622, U2623, U2624 [XXX] my vehicle no longer drives or shifts out of park, "Not able to charge" message displayed, CEL light on. A class action lawsuit revealed a technical service bulletin 18-NA-261 released in 2018 (see attached) accusing GM of continuing support of the known faulty module. The result of the case was Special Coverage Bulletin N232432680 which acknowledges and addresses the above mentioned issues by replacing a faulty BECM common to ALL Chevy Volt models years 2016-2018. My VIN is EXCLUDED from coverage due to being a CARB compliant vehicle despite exhibiting the same behaviors, error codes, and sharing the same faulty BECM. Of the 60,000 Volts sold in 2016-2018, only 19,000 (~33%) qualify under the special coverage terms. 100% of the vehicles that qualify for coverage are NON-CARB compliant. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552

BECM failure leaving car stranded in traffic with no ability to move under its own power.

Vehicle had the Battery Energy Control Module fail at about 87,000 miles. Vehicle will not start and will leave you stranded when this happens. This is a known defect and GM issued a special coverage to extend the warranty for this specific component, but for some reason only applies to a handful of VINs. Mine was not one of them, so I got stuck with a $2500 repair bill. I love the car and am not mad that they are breaking, engineering is hard. I am mad that even after a requirement from the NHTSA, Chevy is refusing to repair a known defect with their vehicles that can leave the owner stranded and is making the owners foot the several thousand-dollar repair bill. This was my first Chevy, and due to the poor way this has been handled, probably my last.

The contact owns a 2016 Chevrolet Volt. The contact stated that while the vehicle was parked, the check engine warning light illuminated. The contact used a scanner and retrieved DTC: U2603-U2606 and U2607-U2622. The dealer was made aware of the failure. The vehicle was scheduled for an upcoming diagnostic test. The vehicle was not yet diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 95,000.

CAR LOST POWER IN 02/2024, WAS TAKEN TO DEALER. ISSUE WAS NOT ADDRESSED PROPERLY. 12/2024 THE CAR WOULD NOT MOVE, TOWED TO DEALER, ESTIMATE $2000 TO REPLACE BECM, KNOW ISSUE FOR THESE VEHICLES.

EGR valve has failed leaving me stranded on side of the road. Problem was confirmed by a Chevrolet dealership. Engine light came on moments before it happened.

My experience is proof for the investigation on “loss of motive power, including a stall, reduced power state, and/or a no-start condition due to the Battery Energy Control Module (BECM).” My safety and the safety of others were affected because the reduced engine propulsion caused me to drive at a max speed of around 50 mph, and eventually the car left my stranded a few weeks later when it would not start at all in a parking lot. The gas engine would run at an extremely high RPM to make up for the failure of battery propulsion. The dealer covered the work under warranty. The work was performed during the pandemic chip shortage in 2022 and my car was at the dealership for two months from about August to October. The check engine light would come on sporadically before the problem started, and when the failure would occur, I would get a “Propulsion reduced” message in the driver screen and the gas engine would kick on to an extremely high RPM even when the car should have been running on battery. Accelerating from a stop to a normal speed would sound like you are flooring down the accelerator to get on a highway on-ramp. I no longer have the paperwork to confirm this, but it was performed at the Fort Collins (Colorado) Dellenbach Chevrolet dealer, it may be possible for me to get the paperwork, but I no longer live in Colorado. The process went all the way up to corporate Chevrolet before the warranty was honored, and I was compensated with company points.

With PHEV battery at 0%, it's normal for the gas engine to kick in. What's not normal is when the infamous BCEM propulsion system failure happened. First, it shut off the ICE engine and reverted to EV mode when I have 0% charges left. The system also reduced power to the car. Luckily, I wasn't on the freeway, or this could end up really badly. I was at the point where I could no longer accelerate and was coming to a stop really quick. Because I was still on local street, was able to safely pull over to the side of the road and turned off the system completely. I waited a minute or 2, turn the car back on and the engine kicked on immediately. Please have GM issue a recall for this problem TSB 18-NA-261 because if this happens to someone on the freeway when their battery is at 0% and BCEM shuts off the gas engine with loss propulsion failure, it can result in serious accidents and deaths.

Shift to park message & audible alarm. Display while in motion pulling into home driveway. Vehicle stalled midway while in motion. Halfway in the street & half driveway. Displaying propulsion power reduced & Engine not available service soon. After 30 minutes of starting & restarting was able to move out of the street. However vehicle will NOT move. Transmission will shift, however will not move. Shift to park keeps popping up.

The contact owns a 2016 Chevrolet Volt. The contact stated that while starting and driving at an undisclosed speed, the "Reduced Propulsion" message was displayed. Additionally, after parking the vehicle, the "Shift To Park" message was displayed, and the vehicle failed to turn off. The contact pressed the Start/Stop button and then opened and closed the front driver's side door to turn off the vehicle. The vehicle later failed to charge and start as needed. The vehicle was towed to the dealer, where it was determined that the Battery Energy Control Module (BECM) needed to be replaced; however, the part was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 83,574. The VIN was unavailable.