2012 CHEVROLET VOLT Complaints

Airbag Service Light comes on for unknown reason. This appears to be a very common problem amongst Chevy Volt owners (2012-2013). Why no recall for this serious safety issue?

The contact owns a 2012 Chevrolet Volt. The contact stated that while his son was driving 55 MPH, the vehicle lost motive power. The vehicle was taken to the dealer and diagnosed with engine software failure. The contact was informed that the engine software needed to be updated. The vehicle was not repaired and remained at the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 113,000.

CAR SUDDENLY ENTERSINTO A NO START AND STALL.THIS IS BEING REPAIRED BY H&H CHEVROLET IN OMAHA AT OWNERS EXPENSE.THE PROBLEM SEEMS TO BE IN A FAULTY BATTERYCHARGE SENSOR. THE PART IS BEING ORDERED BY H&H SERVICE DEPARTMENT ANDIS NOTYET INSTALLED.AS OF 2/9/2022.

The contact owns a 2012 Chevrolet Volt. The contact stated while driving 40 MPH, the brake pedal was applied however, the vehicle failed to stop. The contact was able to maneuver the vehicle and coast to a parking lot. There were no warning lights illuminated. The vehicle was towed to the local dealer to be diagnosed. The contact was informed that the brake module modulator needed to be replaced. The contact stated that the failure was related to NHTSA Campaign Number 13V271000: (Electronic Stability Control, Service Brakes). The manufacturer was notified of the failure however, no further assistance was provided. The failure mileage was approximate 84,682. Vehicle exhibited the issues listed in the recall but your VIN is not included.

My 2012 Chevrolet Volt has had a failure with the passenger air bag presence sensor. As a result, the passenger air bag indicator has been going on and off intermittently while someone is riding in the passenger seat. This has been happening since 2017. It has gotten worse over time and is usually off when it should be on. My passengers no longer feel safe. This is a failure that could result in the passenger’s death if the air bag fails to deploy in a crash. The repair cost from the dealer is also unreasonably expensive at over $1,000. The part alone costs $400 and requires proprietary dealer programming equipment for installation. A critical safety failure like this should be immediately recalled and fixed at no cost to the owner. This is not an isolated incident and has been widely reported across the internet.

We began receiving the intermittent warning message "Service Airbag" on our 2012 Chevy Volt at around 65,000 miles, and are continuing to receive it at 69,000 miles. Research reveals that other Volt owners have encountered the same problem. Cost of repair: $1,000. It appears to be a manufacturer sensor defect that requires a recall.

While traveling slowly (about 25mph) on an uphill grade, my Volt suddenly, with no warning messages or other alerts to me, lost propulsion, power brakes and power steering. This car is extremely hard to steer and to brake without the power assists, so I really had to wrestle with the wheel to avoid losing control of the car, and I really had to jam on the brake pedal to get it to a stop, even though I was moving slowly and had a gravity assist from the uphill slope. It seems to me an event such as I experienced could be catastrophic if it occurred at high speed, and / or on a steep downhill slope or a street with a lot of traffic. Incidentally, when this happened I had just turned onto a side road from a highway with lots of traffic moving at 60-80 miles an hour on a slope so steep that in spite of numerous warning signs, accidents, including fatal accidents, occur regularly on this section of the highway due to drivers failing to apply their brakes hard enough or early enough to keep the car on the road. As a result I felt like I had barely escaped with my life, only as a result of a sudden whim that entered my head to leave the highway for the scenic side road. It may also be relevant that the incident occurred directly after I picked up the car from the Chevy dealer following repair for another incident where I lost propulsion, power brakes, and power steering - the difference being that the car was stationary during the previous incident. The photo shows the electrical connections that the dealer ultimately determined were responsible for the second (Oct. 20) incident, and maybe the first as well. These terminals are enclosed, and not visible to the car owner, even with the hood lifted. Checking the terminals is not part of any maintenance recommended in the owner's handbook, nor apparently in the standard service procedures, even when a car comes in with symptoms that could be caused by a loose connection, even after replacing the 12V battery, as they did.

LCD Driver panel, fuel,odometer, speedometer, screen is completely black. Started flickering then went out. No warnings given. I have no idea how fast I am going nor how much gas/ battery power I have.

2012 Chevy Volt, has been stalling out on the highway since it was brand new, every 6 months. It has been to the Chevrolet dealer many times and they just reset it and move on. In every case the car works for a short time, 6 to 8 months max and dies out again. They have updated the software many times, but nothing has changed it. It keeps stalling out on the interstate with high speed traffic, a severe hazard. Chevy dealerships have never been able to get to the core of the issue. The last time it died, the dealer said they did not know what else to do and told me to call GM. I have every receipt of this happening. The last time this happened is today, 9/29/2021 and has happened 3 times in the last month now. My wife and kids life was at risk several times with this car. It is an extreme safety hazard.

My instruments cluster that displays speedometer/fuel/battery charge indicator went absolutely blank while vehicle was in motion on busy highway. Only remedy recommend by Chevy dealer was to replace the entire assembly and reprogramming. I feel failure of essential display of basic functions to the driver is definitely a hazard to the vehicle operator and to the general public.